SDS
Page 3 of 7
SAFETY DATA SHEET
Prepared to OSHA, ACC, ANSI, NOHSC, WHMIS, 2001/58 & 1272/2008/EC Standards
SDS Revision: 1.
SDS Revision Date: 01/18/2017
7.2
Storage and Handling:
Use and store in a cool, dry, well-ventilated location (e.g., local exhaust ventilation, fans) away from heat and direct
sunlight. Avoid temperatures above 120 °F. Keep away from incompatible substances. Protect containers from
physical damage. To avoid unintentional spraying, keep cap in place when not in use. Storage level 2.
7.3
Special Precautions:
Spilled material may present a slipping hazard if left unattended. Clean all spills promptly.
8. EXPOSURE CONTROLS & PERSONAL PROTECTION
8.1
Exposure Limits:
Ppm (mg/m
3
)
Chemical Name(s)
ACGIH
NOHSC
OSHA
OTHER
TLV
STEL
ES-TWA
ES-STEL
ES-PEAK
PEL
STEL
IDLH
ISOBUTANE 600 750 NF NF NA NA NA NA
PROPANE
1000
NA
1000
NF
NF
1000
NA
2100
8.2
Ventilation &
Engineering Controls
General mechanical (e.g., fans) or natural ventilation is sufficient when this product is in use. Use local or general
exhaust ventilation to effectively remove and prevent buildup of vapors or mist generated from the handling of this
product.
8.3
Respiratory Protection:
No special respiratory protection is required under typical circumstances of use or handling.
In instances where dusts of this product are generated, and respiratory protection is needed,
use only protection authorized by 29 CFR §1910.134, applicable U.S. State regulations, or the
Canadian CAS Standard Z94.4-93 and applicable standards of Canadian Provinces, EC member
States, or Australia.
8.4
Eye Protection:
None required under normal conditions of use. Avoid eye contact. Safety glasses should be
used when handling or using large quantities of this product (e.g., > 1 gallon (3.8 L)).
8.5
Hand Protection:
None required under normal conditions of use. However, may cause skin irritation is some
sensitive individuals. When handling large quantities (e.g., > 1 gallon (3.8 L)), wear rubber,
nitrile or impervious plastic gloves.
8.6
Body Protection:
No apron required when handling small quantities. When handling large quantities (e.g., > 5
lbs.), eye wash station and deluge showers should be available. Upon completion of work
activities involving large quantities of this product, wash any exposed areas thoroughly with
soap and water.
9. PHYSICAL & CHEMICAL PROPERTIES
9.1
Appearance:
Aerosol, Spray Foam
9.2
Odor:
Fresh Fruit
9.3
Odor Threshold
NA
9.4
pH:
6.0 – 8.0
9.5
Melting/Freezing Point
NA
9.6
Initial Boiling Point/
Boiling Range:
NA
9.7
Flashpoint:
-30 °F (-34 °C) TCC for propellant only.
9.8
Upper/Lower
Flammability limits
NA
9.9
Vapor Pressure:
@ 20 °C (68° F) – Can pressure not to exceed 180 psig @ 55 °C (131 °F) 12.4 bar
9.10
Vapor Density
>1
9.11
Relative Density:
0.95 – 1.005
9.12
Solubility:
Soluble
9.13
Partition Coefficient
(log P
ow
):
NA
9.14
Autoignition
Temperature:
NA
9.15
Decomposition
Temperature.
NA
9.16
Viscosity:
Aerosol at ambient temperature
9.17
Other Information:
Evaporation Rate >1: Percent Volatile < 12%