www.all 3oweramenca.
3250W Generator Table of Contents Topic Page Limited Warrant 3 Safety Guidelines 5 General 6 Precautions B att ery 15 Assembly 16 Operation 17 Ins ection, Cleanin and Maintenance 23 Installation 24 Compliance 26 Specifications 27 General Parts Listing 28 WARNING! READ IN THIS MANUAL INSTRUCTIONS AND UNDERSTAND ALL SAFETY PRECAUTIONS BEFORE OPERATING. FAILURE TO COMPLY WITH IN THIS MANUAL COULD RESULT IN PERSONAL INJURY, PROPERTY DAMAGE, AND/OR VOIDING OF YOUR WARRANTY.
OwneP s al3ual Limited Warranty All-Power warrants application warranty to the original (personal, residential are free from defects purchase. All products (i.e. income producing) 90 days from All-Power air tools, will repair in material service or replace, at Al!-Power of All-Power This warranty gives state to state. you specific legal rights, To process a warranty claim original Use reasonable Manual(s).
3250W Generator Limited Warranty (cont'd) THIS WARRANTY DOES NOT COVER: • Merchandise sold as reconditioned, ,, Merchandise that has become cold, heat, rain, excessive accident, failure to operate Owner's Manua!(s) attachments • Repair • Costs costs.
Owi3eP s al3ual Safety Guidelines - Definitions This manual understand EQUIPMENT information. contains important in order to protect PROBLEMS, Please Save These information YOUR SAFETY The following read the manual Important WARNINGS POSSIBILITY ARE to these this sections. Instructions! instructions.
3250W Generator General Precautions WARNING! FAILURE SEVERE Carbon engine THESE iNSTRUCTiONS CAN RESULT iN TO FOLLOW THE TOOLTHESE AND/OR THE iTEM TO iNSTRUCTiONS YOU WORKING CANARE ALSO Monoxide this machine is running, in an enclosed evacuation TO FOLLOW OR DEATH. RESULT DAMAGE CAUTION: iN FAILURE ON. A When iNJURY system area. ensure Run the engine in an enclosed THE GAS THAT DEATH.
OwneP+s General Precautions Gasoline (cont'd) and Oil (cont'd) ,, Do not smoke, tank. or allow Fuel vapors ,, Keep grounded connections sparks, flames or other sources of ignition conductive to avoid ,, Excessive buildup explosive condition. hot engine objects, sparking such as tools, or arcing. of unburned These fuel gases This buildup shutdown. to dissipate ,, Use only engine around the engine and fuel are explosive.
3250W Generator General Precautions (cont'd) Work Area • Keep your work area clean ,, Do not operate liquids, power gases, Electrical Grounded grounded tools or dust. • Keep bystanders, shields as needed. in explosive Generators children, atmospheres, create and visitors benches sparks such which away while and dark areas invite accidents. as in the presence may ignite operating the dust a generator. of flammable or fumes.
OwneP+s General Precautions Electrical codes and conduits electricians, ,, The generator the generator with to connect to the load must al! relevant regulations be earth-grounded and standards ,, Do not attempt soggy and other must codes from and in compliance and standards, electrical (cont'd) Safety (cont'd) ,, All connections licensed anual where for fixed before local, only be installed state, and federal by trained and electrical applicable.
3250W Generator General Precautions Personal ,, Avoid Safety (cont'd) accidental the spark ,, Remove starting. adjusting ,, Use safety goggles. keys or wrenches Keep equipment. Dust appropriate proper the generator. be controlled Generator use" Check reduce switch position, and disconnect shoes, on. Awrench in personal or a key that is injury. at all times.
OwneP+s General Precautions al3ual (cont'd) Servicing Maintain !abe!s !f unreadab!e Generator performed When and name or missing, service must p!ates contact A!!-Power be performed by unqua!ified servicing on the generator personne! a generator, instructions in this manual. may create a risk of electric immediate!y on!y qua!ified could resu!t use on!y identical These carry important information. for a rep!acement. repair personne!.
3250W Generator General Precautions Installation (cont'd) ,, If the generator is installed should not be run outdoors ,, The generator weighs this product. equipment • Before Never lifting outdoors, it must without protection 100 Ibs (approx). using and are rated ensure the lift rigging to lift such under • For trailer away from the full length installation, the suspended • Install sound-and moisture within assist when lifting lugs.
OwneP s General Precautions Mechanical parts • Keep access are moving gloves, follow guards guard removed. clothing, closed and jewelry be seen and locked the generator safety always eye goggles, scheduled wear that the generator or any other away from is running, do not reason. moving parts. Be aware that clearly. when and safety any part of the generator and complete While for maintenance fast they cannot on enclosures • Do not alter or adjust manufacturer.
- i e Genera[ Precautions Extension Cord If an extension cord correct gauge (not included) and length Nameplate full (cont'd) [s used, according Amps m" make sure to use only to the following UL approved cords having the table: (@ Cord Lengths load) 0 ft.- 50 ft. 50 ft.-lO0 ft. 100 ft.-150 ft. 150 ft.-200 5.1 -8 16 14 10 - 8.1 - 12 14 12 - - 12.1 - 15 12 10 - - 15 - 20 10 10 - - 14 ft.
OwneP_s Battery This product does not need a battery.
3250W Generator Assembly No assembly is required.
OwneP s Operation anual Fue, t0n, Control Panel Fuel Switch Pull Start NOTE: THE PARTS CONTROLS LISTED ABOVE MENTIONED ARE HELPFUL FOR LOCATING THE BELOW. CAUTION: PRIOR TO FIRST USING THE GENERATOR, THE FILLED WiTH OiL OF A HiGH QUALITY SAE 10W-30 GRADE ENGINE ENGINE MUST OiL. BE TO DO SO, UNSCREW AND REMOVE THE ENGINE'S OiL DiPSTiCK LOCATED AT THE BOTTOM OF THE ENGINE CRANKCASE. FiLL THE ENGINE'S Before 1. Check "OFF" 2.
3250W Generator Operation (cont'd) Starting 1. Turn the engine The engine system. OFF: To stop switch switch to the ON position. enables and disables the ignition the engine ON: To run the engine 2. The fuel valve is located under the fuel tank. When the valve lever is in the ON position, fuel is allowed to flow from the fuel tank to the carburetor. Be sur to return the fue! valve stopping the engine. 3. To start a cold CLOSED choke engine, position.
3250W Generator Operation (cont'd) Starting 4. Operate the Recoil Starter: Pull the starter grip lightly until you feel then pull briskly. Return the starter grip Pulling crank the starter the recoil starter to the engine 5. If the choke position OPEN i_ ii lever to start position Stopping 1. Turn grip operates resistance, gently. has been moved the engine, gradually as the engine warms to the CLOSED move it to the up. Engine the engine switch to the OFF position. o. _F 2.
Owrlel' s Operation Powering (cont'd) 120 Volt AC Tools And Equipment: 1. Prior to powering capacity power. tools (120 VAC and equipment, @ 20 AMPs) If powering of the tools exceeds and/or DAMAGE the generator and equipment NOTE: sure the generator's TO THE TO PROTECT CAUSING it may be necessary to a separate EQUIPMENT. ALL POWER OR INDIRECT CONDITIONER.
3250W Generator Operation Powering (cont'd) 12 Volt DC tools 1. Prior to powering tools and equipment, capacity (12VDC) is adequate exceeds the generator's equipment 2. Connect make to supply capacity, for connection the power and Equipment: all electrical loads it may be necessary to a separate cord sure the generator's of a 12 VDC rated voltage, and amperage that the unit will power. to group one or more If powering of the tools and/or generator.
OwneP s Operation anual (cont'd) Spark Plug Service In order to service the spark Recommended spark plugs: plug. To ensure proper plug, you will need a spark plug wrench (commercially available). NHSP LD F7TC or NGKBPRGES but we recommend our OEM spark engine operation, the spark plug must be properly gapped and free of deposits. 1. Remove the spark 2. Use a spark 3. Visually plug cap. plug wrench inspect to remove the spark plug with a wire brush plug. the spark Discard plug.
OwneP+s Inspection, Cleaning, Maintenance and WARNING! ALWAYS MAKE SURE THE ENGINE POWER SWITCH "OFF" POSiTiON. DISCONNECT THE SPARK PLUG WiRE FROM AND ALLOW SUFFiCiENT COMPLETELY COOL MAINTENANCE, ,, Before each Loose anual TiME BEFORE FOR THE ENGINE PERFORMING ANY AND (2) iS iN iTS THE ENGINE. GENERATOR iNSPECTiONS, OR CLEANING. use, inspect the generator.
Generator Installation NOTE: PRIOR TO POWERING TOOLS AND EQUIPMENT SURE THE GENERATOR'S RATED VOLTAGE, WATTAGE CAPACITY iS ADEQUATE TO SUPPLY ALL ELECTRICAL THAT THE UNiT WiLL POWER.
OwneP s Installation Supporting Mount (cont'd) and Mounting the generator slab must extend al3uall on a concrete on all sides slab beyond capable of supporting the frame for slab specifications if necessary. Attach expansion anchor bolts (not supplied). the weight by at least one foot. the frame to the concrete of the generator.
3250W Generator Compliance UNITED STATES WASHINGTON, 2005 Model ENVIRONMENTAL ,,Manufacturer Chong • Certificate • Date Number: Date: Issued: Merrylin the terms of Conformity Qing Dajiang Power Equipment Co. Ltd. CDP-NRSl-06-02 12/30/2006 12/30/2006 Zaw-Mon, Transportation Pursuant AGENCY, DC 20460 Year Certifcate • Effective PROTECTION Director, Compliance and Innovation Strategies Division, Office to Section 213 of Clean and conditions Air Act (42 U.S.C.
Distributed by: ALL-POWER AMERICA @2005 ALL-POWER AMERICA 16273 E. Gale Ave City Of Industry, California 91745 www.all powe ra me rica.