T Series Quick Start Guide

6-Propane and Natural Gas Safety
FOR PROPANE CONFIGURATIONS; READ ALL SAFETY INSTRUCTIONS AND WARNINGS REGARDING THE USE
OF PROPANE GAS FOUND IN YOUR OWNER’S MANUAL. FOR NATURAL GAS READ ALL SAFETY INSTRUCTIONS
AND WARNINGS FOUND IN YOUR OWNER’S MANUAL.
7-Routine Maintenance
Your grill must be serviced and maintained properly to ensure optimal performance, appearance, and safety. Clean your grill before and
after each use. Additionally, a deep clean of the entire grill and all its components be performed twice a year (or as needed depending
on use). See owner’s manual for details.
REV 2 - 1901141425
L-C2-483
Replacement parts can be ordered
from your local AOG dealer.
4-Grill Setup
Parts Placement Checklist
Place the following items according to their position and
orientation in Fig. 4-1:
Vaporizer panels, cooking grids, and warming rack.
Leave pre-installed burners in place to maintain proper
alignment.
Vaporizer Panels
Place the vaporizer panels directly onto the studs on the
burners. The panels allow heat from the burners to be evenly
distributed throughout the cooking area.
Cooking Grids
Place the cooking grids (over the burners) onto the grill frame.
Warming Rack
The warming rack comes pre-installed. Remove zip ties
before use. Consult the owner’s manual to remove or replace.
IMPORTANT: See your grill owner’s manual for complete
installation details.
Fig. 4-1
Cooking grid
Vaporizer panel
Backburner
(if equipped)
Warming
rack
Rotisserie kit
(if equipped)
Drip tray
Main burner
Note: DO NOT turn on more than one valve at a time for either electronic or manual lighting.
1. Open lid(s) or remove cover(s) from burner(s) to be lit.
2. Turn all gas control knob(s) to their OFF position(s).
3. Turn on the gas at its source.
4. Depress the desired control knob, then while pressing turn it counterclockwise to the HI LIGHT
position. Once the burner lights, release the knob.
Note: Turning the knob will create a “click” sound. The pilot will ignite at this point, lighting the burner.
CAUTION: If a burner does not light within two to three (2-3) seconds of turning on the
control knob, depress the knob and turn it to the OFF position.
WAIT FIVE (5)
MINUTES before repeating step 4. If you smell gas, follow the instructions on the cover of
the grill owner’s manual. If the burners still do not light after several attempts, refer to the
grill owner’s manual for manual lighting.
5. Repeat step 4 for each additional burner to be lit.
Fig. 5-2
5-Test
Fig. 5-1 - Burner valve control knob
OFF
HI
LIGHT
LOW
T O
TURN OFF
T O TURN ON
Read setting
here
HIGH to
LIGHT
To Turn OFF
To Turn ON
High to
light
Read setting here
WHEN OPERATING THIS
GAS APPLIANCE, ALL
INSTRUCTIONS AND
WARNINGS MUST BE
OBSERVED. FAILURE TO DO
SO MAY RESULT IN A FIRE
OR EXPLOSION CAUSING
PROPERTY DAMAGE, BODILY
INJURY, OR DEATH.
30" and 36" model controls
Center main burner
control knob
Left
main burner
control knob
Right
main burner
control knob
Backburner
control knob
(if equipped)
Control panel
screw(s)
Drip
tray
*
The burner
ports and carry-
over slots must
be kept clean to
ensure proper
ignition and
operation.