T Series Quick Start Guide

6-Propane and Natural Gas Safety
IMPORTANT: READ AND FOLLOW ALL WARNINGS PROVIDED WITH THE PROPANE-GAS CYLINDER.
READ ALL SAFETY INSTRUCTIONS AND WARNINGS REGARDING THE USE OF PROPANE GAS FOUND
IN YOUR OWNER’S MANUAL. FOR NATURAL GAS READ ALL SAFETY INSTRUCTIONS AND WARNINGS
FOUND IN YOUR OWNER’S MANUAL.
7-Routine Maintenance
Your grill must be serviced and maintained properly to ensure optimal performance, appearance, and safety. Clean your grill before and
after each use. Additionally, a deep clean of the entire grill and all its components be performed twice a year (or as needed depending
on use). See owner’s manual for details.
REV 2 - 1901141450
L-C2-484
Screws
Air shutter
Orifice
Igniter wire
Fig. 4-2
Venturi
Connect
Replacement parts can be
ordered from your local
AOG dealer.
4-Grill Setup
Parts Placement Checklist
Place the following items according to their position and orientation
in Fig. 4-1:
Vaporizer panels, cooking grids, and warming rack.
Leave pre-installed burners in place to maintain proper alignment.
Vaporizer Panels
Place the vaporizer panels directly onto the studs on the burners.
The panels allow heat from the burners to be evenly directly
throughout the cooking area.
Cooking Grids
Place the cooking grids (over the burners) onto the grid frame.
Warming Rack
The warming rack comes pre-installed. Remove zip ties before use.
Consult the owner’s manual to remove or replace.
IMPORTANT: See your grill owner’s manual for complete
installation details.
Side Burner
Fig. 5-2
5-Test
WHEN OPERATING THIS
GAS APPLIANCE, ALL
INSTRUCTIONS AND
WARNINGS MUST BE
OBSERVED. FAILURE TO DO
SO MAY RESULT IN A FIRE
OR EXPLOSION CAUSING
PROPERTY DAMAGE, BODILY
INJURY, OR DEATH.
Note: DO NOT turn on more than one valve at a time for either electronic or manual lighting.
1. Open lid(s) or remove cover(s) from burner(s) to be lit.
2. Turn all gas control knob(s) to their OFF position(s).
3. Turn on the gas at its source.
4. Depress the desired control knob, then while pressing turn it counterclockwise to the HI LIGHT
position. Once the burner lights, release the knob.
Note: Turning the knob will create a “click” sound. The pilot will ignite at this point, lighting the burner.
CAUTION: If a burner does not light within five (5) seconds of turning on the control
knob, depress the knob and turn it to the OFF position. WAIT FIVE (5)
MINUTES before repeating step 4. If you smell gas, follow the instructions on
the cover of the grill owner’s manual. If the burners still do not light after several
attempts, refer to the grill owner’s manual for manual lighting.
5. Repeat step 4 for each additional burner to be lit.
Fig. 5-1 - Burner valve control knob
OFF
HI
LIGHT
LOW
T O
TURN OFF
T O TURN ON
Read setting
here
HIGH to
LIGHT
To Turn OFF
To Turn ON
High to
light
Read setting here
30" and 36" model controls
Center main burner
control knob
Left
main burner
control knob
Right
main burner
control knob
Backburner
control knob
(if equipped)
Control panel
screw(s)
Drip
tray
Sideburner
control know
(if equipped)
Fig. 4-1
Cooking Grid
Vaporizer panel
Warming
rack
Rotisserie kit
(if equipped)
Sideburner shelf
(if equipped)
Drip tray
Backburner
(if equipped)
Main
burner
*
*
The burner
ports and carry-
over ports must
be kept clean to
ensure proper
ignition and
operation.