Ropetwist Bathing Pool Specification Sheet

ManualsBrandsAmerican Standard ManualsHot TubRopetwist Bathing Pool 2722.102 LHO

All product names listed herein are trademarks

of AS America, Inc. unless otherwise noted.

HIGH GLOSS ACRYLIC

SHOWN LESS ALL FITTINGS

Local building codes vary by location. Observe all local plumbing and building codes.

Your new bath is shipped to you after careful inspection. All you need to finish the installation are your selected fittings.

To insure maximum performance and pleasure from this product, please follow the instructions and cautions.

• Level

• Square

• Tape Measure

• Pipe Wrench

• Slip Joint Pliers

• Screw Driver

• Standard Woodworking Tools

• Personal Safety Equipment

• Caulking Gun

• Nails

• Plumber’s Putty

• Silicone Sealant

• 1 x 3 or 2 x 4 Stringers

• Drop Cloth

• Mortar Mix or Grout (1 bag)

754049-100 Rev. G

1. WHEN INSTALLING THE MATCHING ROPE TWIST BATH WALLS (MODEL 5030.LBW),

ADDITIONAL STUDS MAY BE REQUIRED. REFER TO THOSE INSTALLATION INSTRUCTIONS

PRIOR TO INSTALLING TUB.

2. ROPE TWIST SHOWER WALLS ARE TO BE INSTALLED OVER STUD WALLS.

3. BATH MAY ONLY BE INSTALLED IN A RECESS TYPE INSTALLAION.

4. THIS BATH IS NOT SELF-SUPPORTING AND MUST BE SUPPORTED ALONG ITS ENTIRE

BOTTOM WITH MORTAR OR GROUT. STRINGERS WILL HELP LEVEL TUB, BUT WILL NOT

PROVIDE ADEQUATE SUPPORT.

5. TAKE EXTRA CARE WHEN DRIVING NAILS OR SCREWS TO AVOID DAMAGING THE BATH.

ROPE TWIST™ BATHING POOL

Installation Instructions

Thank you for selecting American-Standard...the benchmark of fine quality

for over 100 years. To ensure that your installation proceeds smoothly--please

read these instructions carefully before you begin.

BEFORE YOU BEGIN....

GENERAL INSTALLATION INFORMATION ....

TOOLS:

TOOLS & MATERIALS REQUIRED....

NOTE: Take extra care in handling surfaces of the bath. Use only non-abrasive cloths to avoid scratching.

MATERIALS:

HOTLINE FOR HELP

FOR TOLL FREE INFORMATION AND ANSWERS TO YOUR QUESTIONS, CALL:

1 (800) 442-1902, in Canada call 1 (800) 387-0369.

Weekdays 8:00 a.m. to 4:00 p.m. Eastern time.

MODELS: 2722.102 RHO

2722.202 LHO

USED WITH BATH WALLS: 5030.LBW

Summary of content (5 pages)

PAGE 1
Installation Instructions ROPE TWIST™ BATHING POOL HIGH GLOSS ACRYLIC SHOWN LESS ALL FITTINGS MODELS: 2722.102 RHO 2722.202 LHO USED WITH BATH WALLS: 5030.LBW Thank you for selecting American-Standard...the benchmark of fine quality for over 100 years. To ensure that your installation proceeds smoothly--please read these instructions carefully before you begin. 754049-100 Rev. G BEFORE YOU BEGIN.... Local building codes vary by location. Observe all local plumbing and building codes.
PAGE 2
ROUGH-IN INFORMATION: 9-3/8" (238mm) GENERAL SPECIFICATIONS FOR 2722 BATHING POOL 60 x 32 x 17 In. (1524 x 813 x 432mm) 60 Lbs. (27 Kg) WEIGHT WEIGHT w/WATER 393 Lbs.(179 Kg) 40 Gal. (151 L) GAL. TO OVERFLOW 22 x 44 In. (559 x 1118mm) BATHING WELL AT SUMP 25.5 X 53 In.(648 x 1346mm) BATHING WELL AT RIM 10 In. (254mm) WATER DEPTH TO OVERFLOW 29 Lbs./Sq.Ft. (195 Kgs/Sq.m) FLOOR LOADING (PROJECTED AREA) 15.3 PTS.
PAGE 3
2 A.) THIS BATH MUST BE SUPPORTED ALONG IT'S ENTIRE BOTTOM. We recommend the use of mortar as bedding material (sand is not recommended). Apply enough bedding to support the complete bottom of the bath. After the bedding has been poured, and before it sets, position the bath within the recess until the rim is leveled against the leveling stringers (see "Typical Recess Installation") shown below. The rim of the bath MUST NOT support weight.
PAGE 4
3 DRAIN CONNECTION Using recommended drain opening, connect bath drain to waste line. Tighten all drain joints securely. POST INSTALLATION CLEAN-UP Remove all construction debris from bath. Tile grout can be removed with a wooden popsicle stick or tongue depressor. Do not use wire brushes or any other metal implement on bath surface. Post installation clean-up generally can be completed using warm water and liquid dishwashing detergent.
PAGE 5
AS America, Inc. Limited Lifetime Warranty for Rope Twist™ Bathing Pools AS America, Inc. (”American Standard”) warrants to the original consumer purchaser that it will, at its option, repair or replace this bathing pool – American Standard, in its sole judgment, to be defective under normal residential use and maintenance so long as it is owned by the original consumer purchaser. To activate this limited warranty, the purchaser must go online to our website at www.americanstandard-us.