Operator`s manual

Bulb Replacement
If the headlamp bulb is burnt, tilt hood,
unplug the connector from the
head lamp.
Remove the rubber boot and unfasten
bulb retainer clips. Detach the bulb and
replace.
clips \
Retainer~' 0
~
STORAGE
It is during summer, or when a vehicle is
not in use for any length of time that pro-
per storage
is a necessity. Storage of the
snowmobile during long period of inac-
tivity consists of checking and replacing
missing, broken or worn parts, proper
lubrication and treatment to insure that
parts do not become rusted; cleaning
items such
as carburetor of oil mixtures,
to prevent gum varnish formation within
the carburetor; and
in general, preparing
the vehicle
so that when the time comes
to
use the snowmobile again it will be in
top condition.
•
WARNING: Only perform such
pro-
cedures as detailed in this manual.
It
is recommended that dealer assis-
tance
be periodically obtained on other
components/systems not covered
in
this manual. Unless otherwise speci-
fied, engine should be turned
OFF. For
all lubrication and maintenance proce-
dures.
If taillight bulb is burnt, expose the bulb
by removing the
red plastic lens. To re-
move, unfasten the
two (2) screws.
•
WARNING: Always check light op-
eration
after bulb replacement.
General Inspection
Check the electrical wiring and compo-
nents, retighten loose connections. Check
for stripped wires or damaged insulation.
Thoroughly inspect the vehicle and tight-
en loose bolts, nuts and linkage. Inspect
skis and
ski runners for wear.
Track
Inspect the track for wear, cuts, missing
track guides and broken
rods. Make any
necessary replacement.
•
WARNING: Do not operate a snow-
mobile
with a cut, torn or dam-
aged track.
Lift the rear of vehicle until track is clear
of the ground then support with a brace
or
trestle. The snowmobile should be stor-
ed in such a way that the track does not
stay
in contact with the cement floor or
bare ground .
0
NOTE: The track should be rotated
periodically, (every 40 days). Do not
release track tension.
W' CAUTION: To prevent track dam-
T age, temperature in the storage
area must not exceed
38°C (100°F).
34 ________________________ __