Operator`s manual

•
WARNING: Gases given
off by a
battery being charged are highly
explosive. Always charge in a well ven-
tilated area. Keep battery away from
cigarettes or open flames. Avoid skin
contact
with electrolyte.
6. Coat electrical connections and swit-
ches with a greaseless metal protec-
tor, if unavailable, use petroleum
jelly.
7. Store unit in a cool, dry place.
0
NOTE: To prevent battery from dis-
charging, store it on a wooden shelf
away from moisture. A stored battery must
be recharged at least every
40 days.
Chassis
Clean the vehicle thoroughly, removing
all dirt and grease accumulation.
"W' CAUTION: Plastic alloy com po-
T nents such as fuel tank, wind-
shield, controls, etc., can
be cleaned
using mild detergents or isopropyl al-
cohol.
Do not use strong soaps, de-
greasing solvents, abrasive cleaners,
paint thinners, etc.
Inspect the hood and repair any damage.
Clean the frame. For the unpainted alumi-
num portion use only "Aluminum clean-
er" and follow instructions on the con-
tainer.
Touch up
all metal spots where paint has
been scratched off. Spray all bare metal
parts with metal protector. Wax the hood
and the painted portion
of the frame for
better protection.
0
NOTE: Apply wax on glossy finish
only. Protect the vehicle with a cov-
er to prevent dust accumulation during
storage.
"W' CAUTION: If for some reason the
T snowmobile has to be stored out-
side it
is necessary to cover it with an
opaque tarpaulin. This caution will pre-
vent the sun rays and grime from af-
fecting the plastic components
and the
vehicle finish.
General Inspection
Check the electrical wiring and compo-
nents, retighten loose connections. Check
for stripped wires or damaged insulation.
Thoroughly inspect the vehicle and tigh-
ten loose bolts, nuts and linkage.
0
NOTE: Leave the drive belt off the
pulleys for the entire storage pe-
riod.
Suspension Stopper Strap
Replace annually and/or as condition dic-
tates. Torque nut to
10 N•m (89 lbf•in).
_________________________ 37