Operator`s manual

PRE-SEASON
PREPARATION------------
To simplify the pre-season preparation we
have drawn up a small chart. The chart
indicates servicing points to
be performed
by you and your dealer. If these services
are performed as suggested, your vehicle
will give many hours of fun
and low cost
use.
PRE-SEASON
PREPARATION CHART
Reinstall battery (electric starting)
Change spark
plugs*
Check chaincase oil level
Replace fuel
filter (located inside fuel tank)
Check track tension and alignment
Lubricate suspension
Inspect drive belt and install
IMPORTANT: Observe all Warnings and
Cautions mentioned throughout this
manual which are pertinent to the item
being checked. When component con-
ditions seem less than satisfactory, re-
place
with genuine Bombardier parts or
suitable equivalents.
TO BE PERFORMED BY DEALER
•
TO BE PERFORMED BY OWNER
0
0
0
0
0
0
0
0
Check steering alignment and ski runner condition
0
Inspect condition of starting rope
0
Check tightness of all bolts, nuts and linkage
0
Refill gas tank
0
Check throttle cable for damage and free operation
•
Check electrical wiring (broken wire, damaged insulation)
0
Inspect seals for possible cuts or leaks
•
Replace injection oil filter
•
Refill injection oil tank
•
Inspect brake condition and operation
•
Set engine timing
•
Check pulleys, verify components and clean. Lubricate
•
Adjust carburetors
•
Adjust oil injection pump
•
0
*NOTE: Before installing new spark plugs, it is suggested to burn the excess
storage oil
by starting the engine, using the old spark plugs.
T CAUTION: Only perform this procedure in a well ventilated area.
38 -------------