Installation / Operation Instruction Manual

SECTION I: IMPORTANT INFORMATION

READ CAREFULLY

This gas-fired water heater is design certified by CSA International under the American National Standard, Z21.10.3 (as

indicated on the rating plate) and CAN/CGA 4.3-M (as indicated on the rating plate) available from CSA Standards

Association, 5060 Spectrum Way, Mississauga, Ontario, CANADA L4W 5N6.

This water heater must be installed in accordance with local codes. In the absence of local codes, it must be installed in

compliance with the National Fuel Gas Code (ANSI Z223.1-Latest Edition), or in Canada CAN/CGA B149.1 Natural Gas

Installation Code (Latest Edition) or CAN/CGA B149.2 Propane Installation Code (Latest Edition).

The following terms are used throughout this manual to bring attention to the presence of hazards at various

risk levels, or to important information concerning product life.

DANGER

CAUTION

Indicates an imminently hazardous situation,

which, if not avoided, will result in death, serious

injury or substantial property damage.

Indicates potentially hazardous situation, which, if

not avoided, may result in moderate or minor

injury or property damage.

WARNING

NOTICE

Indicates a potentially hazardous situation,

which, if not avoided, could result in death,

serious injury or substantial property damage.

Indicates special instructions on installation,

operation or maintenance, which are important

but not related to personal injury hazards.

NOTICE

This water heater has a limited warranty. The warranty for this water heater is valid only if the water heater has

been installed, maintained, and operated in accordance with these instructions.

SECTION I: IMPORTANT INFORMATION ........ 2

SECTION II: SPECIFICATIONS ......................... 5

SECTION III: GENERAL INFORMATION .......... 6

SECTION IV: INSTALLATION

INSTRUCTIONS ................................................. 8

SECTION V: VENTING .................................... 13

SECTION VI: WATER CONNECTIONS ........... 21

SECTION VII: GAS CONNECTIONS ............... 23

SECTION VIII: ELECTRICAL

CONNECTIONS ................................................25

SECTION IX: OPERATING INSTRUCTIONS ...26

SECTION X: MAINTENANCE ...........................35

SECTION XI: SERVICE AND

TROUBLESHOOTING GUIDE ..........................39

NOTES ..............................................................59

TABLE OF CONTENTS