Install Instructions

Table 1
Table 2
Table 3
RELUBRICATION INSTRUCTIONS
BROWNING
®
Brand Bearing Units are factory lubricated with
high quality lithium soap grease with an EP additive. The bearing
is ready for use with no initial lubrication required. However, for
slow speed applications less than 100 RPM, operating in dirty or
wet environment, sufficient additional grease should be applied
at start-up to completely fill the void in the bearing. Lubrication
intervals depend upon the type of application, speed and other
external conditions. For general use, suggested intervals are
shown in Table 6 for roller bearings and Table 9 for ball bearings.
Grease charge amounts are shown in Table 7 for roller bearings
and Table 8 for ball bearings. Experience will determine the best
interval for each specific application. For safety, stop rotating
equipment. Add one half the recommended amount shown in Table
7 or 8. Start the bearing and run for a few minutes. Stop the bearing
and add the second half of the recommended amount. Lubricate
with lithium soap grease with EP additive, which conforms to
NLGI 2 consistency and is suitable for an operating range of
–20°F to +250°F.
Compatibility of grease is critical, therefore consult with
BROWNING/EPT Engineering Department and your grease
supplier for current grease specifications to ensure any greases
used are compatible. For applications operating below –20°F,
above 250°F, and all other applications, contact
BROWNING/EPT Engineering Department at 219-465-2211*.
SECNARELOTTFAHSDEDNEMMOCER
)sehcni(eziStfahSlanimoN)sehcni(ecnareloTtfahS
61/511ot8/115000.-/0000.+
61/513
ot20100.-/0000.+
61/514ot45100.-/0000.+
)SGNIRAEBLLAB(GNINETHGITWERCSTES
gnikcoLwercSteSkcoLcirtneccE
eziSeroB
)ni(
002&001
eziSeroB
)ni(
003
eziSeroB
)ni(
wercS
eziS
xeH
eziS
euqroT
).sbl-ni(
8/5-2/11--23-0123/363-82
R4/11-4/31-61/511-2/182-4/18/158-66
4/31-4/111-61/31R4/
11-8/1142-61/523/5461-621
2-61/5112/161/511-4/1142-8/361/3692-822
3-2/122-61/11161/72-202-61/723/7254-843
61/5161/32-61
/11202-2/14/1556-405
-3-61/7261/51 ---
-61/51 - ---
Table 4
KCOLCIRTNECCE
eroB
eziS
wercS
eziS
euqroT
).sbl-ni().sbl-tf()m-N(
61/32ot8/1161/305202092
2/13ot61/7223/706303534
61/514
ot61/734/153554556
Table 5
Table 7
Table 8 Table 9
RELLORROFEGRAHCESAERG
NOITACIRBULERGNIRAEB
EZISTFAHS
)sehcni(
ESAERG
EGRAHC
)secnuo(
4/11ot8/1101.0
61/71ot8/3
122.0
61/111ot2/1123.0
2ot4/3105.0
61/32ot255.0
2/12ot4/1256.0
3ot61/11258.0
2/13ot61/3352.1
4ot61/51305.2
2/14ot61/7
401.3
5ot61/51457.4
LLABROFEGRAHCESAERG
NOITACIRBULERGNIRAEB
EZISTFAHS
)sehcni(
ESAERG
EGRAHC
)secnuo(
4/3ot2/130.0
61/31ot8/701.0
2
/11ot4/1151.0
61/511ot61/11103.0
61/512ot205.0
61/73ot4358.0
4ot2/1305.1
GNINWORBROFSLAVRETNINOITACIRBULER
®
DNARB
SGNIRAEBRELLOR
EVITIDDAPENAHTIWESAERGPAOSMUIHTILYTILAUQA
DESUEBDLUOHS
MPRdeepSerutarepmeTssenilnaelCla
vretnIgnisaerG
001F°521otF°02-naelCshtnoM4-1
005F°051otF°02-naelChtnoM1otkeeW1
0001F°012otF°02-naelCskeeW2-1
ot005
1
mumixaM
gnitaRgolataC
F°051otpUytriDkeew1otyliaD
F°051revOytriDkeew1otyliaD
F°052otpU*ytriDyreVkeew1otyliaD
F°0
52otpU*snoitidnoCemertxEkeew1otyliaD
Table 10
GNINWORBROFSLAVRETNINOITACIRBULER
®
DNARB
SGNIRAEBLLAB
MPRdeepSerutarepmeTssenilnaelCslavretnI.buleR
001F°521otF°02-naelCshtnoM01-4
005F°051otF°02-na
elCshtnoM4ot1
0001F°002otF°02-naelChtnoM1otkeeW1
0051F°002otF°02-naelCylkeewiB
ot0051
mumixaM
gnitaRgolataC
F°051o
tpUytriDkeew1otyliaD
F°002otF°051ytriDkeew1otyliaD
F°002otF°02-*ytriDyreVkeew1otyliaD
F°002otF°02-*snoitidnoCem
ertxEkeew1otyliaD
Disconnect all power before adjusting units
© Emerson Power Transmission Manufacturing, L. P. or affiliates 2006. All rights reserved.
The Emerson Logo is a trademark and a service mark of Emerson Electric Co.
APPLICATION ASSISTANCE:
Please contact Application Engineering at:
Phone: [phone]
Fax: [phone]
Email: [e-mail]
)RELLORLACIREHPS(KCOLWERCSTES
eroB
eziS
wercS
eziS
euqroT
).sbl-ni().sbl-tf()m-N(
61/32ot8/118/305202092
2/13ot61/7
22/153554556
61/514ot61/738/50601090131
)RELLORDEREPAT(KCOLWERCSTES
EROB
EZIS
WERCS
EZIS
EUQROTDEDNEMMOCER
).sbl-ni().sbl-tf()m-N(
61/111ot61/3142-61/5
1441-80121-961-21
2/12ot4/3142-8/3822-08191-5162-02
2/13ot61/11202-2/1045-80454-4316-64
4ot61/51381-8/50411-67859-37921
-99
5ot61/7461-4/30081-0441051-021302-361
GNINETHGITCIRTNECNOCAOB
wercShsilgnE
eziS
xeH
eziS
euqroT
).sbl-ni()m-N(
23-8#52-T07-568-7
42-01#72-T09-0801-9
02-4/10
3-T081-06102-81
81-61/554-T004-06354-04
Table 6