Install Instructions

Table of Key Words 16
69
We reserve the right to make any changes due to technical modifications.
Installation and maintenance instructions Logano G215 US oil/gas-fired boilers • Issue 2012/10
16 Table of Key Words
A
Anchor rods . . . . . . . . . . . . . . . . . . . . 22
Aquasmart . . . . . . . . . . . . . . . . . . . . . 38
Assembly of boiler sections . . . . . . . . . . . . 16
B
B-Kit components: . . . . . . . . . . . . . . . . . 12
Blank flange . . . . . . . . . . . . . . . . . . . . 24
Boiler back panel . . . . . . . . . . . . . . . . . 28
Boiler block . . . . . . . . . . . . . . . . . . . . 58
Boiler block leak test . . . . . . . . . . . . . . . . 25
Boiler fill & drain valve
. . . . . . . . . . . . . . . 24
Boiler room . . . . . . . . . . . . . . . . . . . . . . 5
Burner door . . . . . . . . . . . . . . . . . . . . 58
Burner door installation . . . . . . . . . . . . . . 27
Burner installation . . . . . . . . . . . . . . . . . 37
Burner, guidelines for starting up . . . . . . . . . 43
C
Cable entry . . . . . . . . . . . . . . . . . . . . . 32
Capillary tubes . . . . . . . . . . . . . . . . . . . 40
Check the temperature safety cut-out (STB) . . . 45
Checking for leaks (heating water side) . . . . . . 36
Circuit diagrams . . . . . . . . . . . . . . . . . . 65
Clearances . . . . . . . . . . . . . . . . . . . . . 14
Combustion chamber . . . . . . . . . . . . . . . 49
Compression tool . . . . . . . . . . . . . . . . . 19
Connect electrical power supply . . . . . . . . . . 41
Correcting burner faults . . . . . . . . . . . . . . 55
D
Disposal . . . . . . . . . . . . . . . . . . . . . . . 5
Distribution tube . . . . . . . . . . . . . . . . . . 22
E
Emergency stop switch – heating system . . . . . 47
F
Fitting adjustable feet . . . . . . . . . . . . . . . 26
Fitting the control panel . . . . . . . . . . . . . . 39
Fitting the side panels . . . . . . . . . . . . . . . 30
Fitting the tie-bars . . . . . . . . . . . . . . . . . 29
Flue outlet . . . . . . . . . . . . . . . . . . . . . 24
H
Heating circuits, multiple . . . . . . . . . . . . . . 56
Hinge lobes
. . . . . . . . . . . . . . . . . . . . 28
Hinge pins
. . . . . . . . . . . . . . . . . . . . . 27
Hot gas baffle plates, removing
. . . . . . . . . . 49
Hot gas flues, cleaning
. . . . . . . . . . . . . . . 49
I
If you notice a smell of gas . . . . . . . . . . . . . 4
Initial start-up
. . . . . . . . . . . . . . . . . . . 42
Inserting the hot gas baffle plates . . . . . . . . . 27
Installation diagram . . . . . . . . . . . . . . . . 36
Installation of boiler drain
. . . . . . . . . . . . . 35
Installation of the boiler jacket
. . . . . . . . . . . 28
Installing B-Kit
. . . . . . . . . . . . . . . . . . . 35
Installing boiler fill and drain valve
. . . . . . . . . 35
Installing the boiler cover . . . . . . . . . . . . . 31
Installing the burner door jacket . . . . . . . . . . 45
Installing the temperature sensor set . . . . . . . 40
Installing thermal insulation . . . . . . . . . . . . 30
Insulation . . . . . . . . . . . . . . . . . . . . . . 30
L
L.h. closing . . . . . . . . . . . . . . . . . . . . . 27
Leaking boiler block . . . . . . . . . . . . . . . . 25
M
Main shut-off valve . . . . . . . . . . . . . . . . . 43
Main switch . . . . . . . . . . . . . . . . . . . . . 47
Maintenance procedure . . . . . . . . . . . . . . 54
Maintenance, subject to demand . . . . . . . . . 48
O
ON/OFF switch . . . . . . . . . . . . . . . . . . . 47
On-site test pressure . . . . . . . . . . . . . . . . 37
Original components . . . . . . . . . . . . . . . . .4
P
Pressure relief valve . . . . . . . . . . . .35, 37, 42
Pressure test port . . . . . . . . . . . . . . . . . 44
Pressure/temperature gauge
. . . . . . . . . . 42
, 51
Protocol, start-up . . . . . . . . . . . . . . . . . . 46
Protocols, inspection and maintenance . . . . . . 52
Providing a fuel supply . . . . . . . . . . . . . . . 38
R
Raising flue gas temperature . . . . . . . . . . . 44
Routing the burner cable . . . . . . . . . . . . . . 40
S
Sealing rope, replacing . . . . . . . . . . . . . . . 50
Sealing the boiler hub . . . . . . . . . . . . . . . 24
Sensor well . . . . . . . . . . . . . . . . . . . . . 23
Sensor wire . . . . . . . . . . . . . . . . . . . . 40
Shutting down . . . . . . . . . . . . . . . . . . . 47
Side panels . . . . . . . . . . . . . . . . . . . . . 30
Strain relief installation . . . . . . . . . . . . . . . 41
Supply/return header . . . . . . . . . . . . . . . . 22
T
Technical information . . . . . . . . . . . . . . . .7
Test port
. . . . . . . . . . . . . . . . . . . . 23
, 40
Tools
. . . . . . . . . . . . . . . . . . . . . . . . .5
Troubleshooting . . . . . . . . . . . . . . . . . . 55
W
Wet cleaning . . . . . . . . . . . . . . . . . . . . 50