Product Manual

With your drill, make a 1/4” hole in the adaptor previously glued. This hole will prevent any air

locking wich might occur.

Screw the pipe with the male adaptor into the 2” discharge opening in the pump. Lower pump

with piping attached into the sewage basin. Make sure that the pump is as close as possible

to the centre of the basin. Adjusting the pump in centre of basin will keep mechanical oat

switch from rubbing on side of basin.

When you are pumping raw sewage, you must have a gas tight cover on the basin and a vent

pipe from basin, connecting to home’s vent system (see diagram). Feed the 2” riser pipe from

pump’s discharge, through the 2” opening in the cover. Secure a 3” vent pipe to the cover and

bring the switch and pump motor power cables through the opening in the cover provided.

Install a 2” check valve (model 450457) union type to the 2” discharge riser pipe coming out

of the cover, to a lenght of 2” ABS/DWV pipe, and run the discharge line as short as possible

to the home’s waste sewer line. Secured the check valve with the provided clamps. Be sure

that the arrow on valve are pointing away from pump.

Connect the 3 prong plug of the switch in a receptacle. Insert the motor 3 prong plug into

female receptacle on exposed piggy-back of switch plug. The mechanical switch provided for

automatic operation is preset to pump. No adjustments are necessary.

Fill the sewage basin with water to test the operation of the submersible sewage pump and

switch operation. Pump should start pumping when the water level reaches 12” to 15” above

the bottom of the basin and above the pump. Allow the pump to go several “ON-OFF” cycles

to assure satisfactory operation.

Secure the gas tight cover and the plug for electrical cords with the gaskets and screws

provided with the cover. Make vent connection to home’s vent system.

SEWAGE SYSTEM TYPICAL PIPING:

STEP 4

STEP 5

STEP 6

STEP 7

STEP 8

STEP 9

STEP 10

Raw sewage discharge line

Pump’s discharge line

Basin

vent line

Home’s vent system

From

bath or shower

From

toilet

From

sink

Sewage basin inlet