LTR50001036, Rev.
PRELIMINARY . . . . . . . . . . . . . . . . . . . . i Planning the Best Location . . . . . . . . . . 1 Preparing a Good Foundation . . . . . . . . 2 Electrical Requirements . . . . . . . . . . . . . 3 Natural Gas Installation . . . . . . . . . . . . . 4 Water and Drainage Installation . . . . . . 5 Installation After Delivery . . . . . . . . . . . 6 Cleaning and Maintenance . . . . . . . . . . 12 Limited Warranty . . . .
Planning the Best Location 1 Here are some of the things that you will need to consider when determining where to place your new barbecue island. Safety First Do not place your barbecue island near trees and shrubs. Be certain that your installation will meet all city and local safety codes and requirements. Consider How You Will Use Your Barbecue Island Your barbecue island is mainly used for family recreation. Be sure to leave plenty of room around it for activity.
2 Preparing a Good Foundation Your barbecue island needs a solid and level foundation. Damage caused by inadequate or improper foundation support is not covered by the warranty. It is the responsibility of the owner to provide a proper foundation for the barbecue island. If you do not already have a location for your barbecue island, we recommend you have a concrete slab prepared to accommodate it.
Electrical Requirements 3 You do not need to hire a contractor to install your electrical service, but you must ensure you have all required permits and the installation complies with State and local code. We recommend you hire a certified contractor if you do not wish to do the installation yourself. If your dealer is not a certified contractor, you will need to hire a contractor for installation of your electrical service.
4 Natural Gas Installation You do not need to hire a contractor to install your natural gas service, but you need to make sure you have all required permits and ensure the installation complies with State and local code. We recommend you hire a certified contractor if you do not wish to do the installation yourself. If your dealer is not a certified contractor, you will need to hire a contractor for installation of your gas service.
Water and Drainage Installation If you have a sink or ice maker installed, there are several ways you can provide water and drainage to your barbecue island. A contractor can help you decide on the best solution for your needs. You are responsible for ensuring all plumbing and drainage complies with State and local codes. Water Sources Garden hose -- This is by far the easiest way of getting water to your barbecue island.
6 Installation After Delivery For more information on installing your grill and accessories, see the grill owner’s manual. Connection to Services After your barbecue island is delivered, set in place, and the grill is mounted, you will need to connect all of the services to your hardware. If your dealer is not a certified contractor, you will need to hire a contractor for this. The natural gas line connects to the grill inside the island.
7 Joining the GPV3100 Sections This applies only to Grand Pavillion model GPV3100. Model GPV3100 is built in three sections to make delivery easier. When they arrive, they will need to be bolted together. Use four bolts with four nuts and washers to connect each section. Place the three sections together as shown in the figure below. You may find it easiest to set the center section in place and move the two side sections against it.
8 After the sections are joined, if your barbecue island has a stucco finish, you may want to apply a small line of stucco to the seam. When the sections are connected, continue to the section “Connecting Wiring within the Island” before you connect to gas and electrical services. Barbecue Islands www.calflamebbq.com LTR50001036, Rev.
9 Arranging the LBK870 Sections This applies only to model LBK870. Model LBK870 is built in two sections to make delivery easier. When they arrive, they will need to be placed together. They do not need to be connected. Push the two sections together as close as they will go as shown in the example below. If there is any wiring that goes between the two sections, make sure the holes where the wires will be passed through are aligned.
10 Connecting Wiring within the Island If you have LED lights or a stereo installed, make sure all of the sections are connected together. There are only a few connections and are easily identifiable. Barbecue Islands www.calflamebbq.com LTR50001036, Rev.
11 If your LBK870 island has a built-in electrical service, the two sections have an extension cord that needs to be passed through a small opening in the sides of the two sections as shown below. Barbecue Islands LTR50001036, Rev. D www.calflamebbq.
12 Cleaning and Maintenance About Natural Stone A natural characteristic of granite and marble is its inherent lack of uniformity. Because it is a completely natural material, it can have a great deal of variation in color, shade, finish, tint, hardness, strength, and so on. Any time you use natural stone, you can always expect differences from one tile to the next. You will frequently see dry seams, pit or fossils. These areas are often filled in at the factory.
13 Granite Top Clean stone surfaces with a few drops of neutral cleaner, stone soap (available from Monticello Granite) or a mild liquid dishwashing detergent and warm water. Use a clean rag for best results. Too much cleaner or soap may leave a film and cause streaks. Do not use products that contain lemon, vinegar or other acids on the granite the high acid content may etch the surface. Rinse the surface thoroughly after washing with the soap solution and dry with a soft cloth.
14 Tile If spillage occurs, then clean up as soon as possible. Care • Protect against chipping by using a cutting board. • Protect against scratches, especially on natural stone tiles. • Avoid hard blows that can chip the tile. • Standing water or other liquids can deteriorate tile and grout, and should always be removed. Cleaning Wash with detergent solution, and rinse.
15 DO’s and DON’Ts of Tile Care • Do test scouring pads in a small area first. • Do use a silicone sealer on grout joints if continuous staining is a problem. • Do read and follow label directions for all cleaners. • Do keep this information and refer to it when necessary. • Do not combine ammonia and household bleaches. • Do not use harsh cleaning agents (such as steel wool pads) which can scratch or damage the surface of your tile. • Do not place sharp object on tile surface.
16 Synthetic Panel Do’s • Do dust surfaces frequently. • Do clean synthetic panels with water and mild detergent. Don’ts • • • • Don’t use any cleaning chemical to clean or wash synthetic panels. Don’t use vinegar, lemon juice or other cleaners containing acids. Don’t use cleaners that contain acid such as bathroom cleaners. Don’t mix bleach and ammonia; this combination creates a toxic and lethal gas.
17 Cleaning Products and Materials Avoid using these common cleaning products and materials – they will damage the surface of your stainless steel.
18 1. Clean Thoroughly clean stains, food, and grime using a sponge or damp cloth with warm water and a mild dish soap. Use Fantastik or Formula 409 to remove heavier soil. 2. Rinse Thoroughly rinse all surfaces and dry them completely with a clean towel. Do not allow stainless steel to air dry. 3. Polish We strongly recommend that you apply a surface protectant to all exposed stainless steel surfaces.
19 Rust Removal It is a common misconception that stainless steel does not rust. It does not stain, corrode, or rust as easily as ordinary steel (it stains less), but it is not stain-proof. If not properly protected and maintained, it can corrode, pit, and discolor. Because salt will accelerate rust and corrosion, grill or barbecue island owners who live near the beach need to be diligent in maintaining their stainless steel hardware.
20 Cleaning the Interior of Your Grill 1. Thoroughly clean stains, food, and grime using a sponge or damp cloth with warm water and a mild dish soap. Use Fantastik or Formula 409 to remove heavier soil. 2. Thoroughly rinse all surfaces and dry them completely with a clean towel. Do not allow water to accumulate and puddle on stainless steel. Water from various sources such as garden hoses contains iron which will give the appearance of rusting on stainless steel.
21 Cooking Grates Use a solution equal parts detergent and hot water just as you would for any cooking equipment. A stiff wire brush or steel wool may also be helpful in removing grime and food deposits. Note Do not use a wire brush or stainless steel on any other part of your grill or any other stainless steel surface except the cooking grates or the griddle! Drip Pan The full width drip pan will collect grease from the main grill area.
22 Limited Warranty All Cal Flame barbecue islands are manufactured with the highest quality appliances and are warranted to be free from defects in material and workmanship at time of delivery. LMS warrants barbecue islands from deterioration, corrosion, and defects in material and workmanship for a period of one year from the original date of delivery. Specifically warranted are the structural frame, fireproof panels, the base, and electrical wiring and components, including switches and outlets.
23 qualified to repair stone and tile or a service agent licensed to repair gas or electrical appliances. In the event the consumer is unable to obtain satisfactory customer service from the selling dealer or service agent, written notification must be given to the LMS Customer Relations Department within 30 days of the reported failure. There will be no charge for parts on a covered item. Cost of labor is the responsibility of the owner.
24 • Damage caused by dirt, sand, and/or water damage. • Damage caused by salty and humid conditions (especially in beach or seaside communities) • Damage caused by continued operation of the barbecue with either known or unknown problems. • Damage caused by direct sunlight. • Damage caused as a result of failure to follow the operating instructions as defined in this owner’s manual.
25 Barbecue Islands LTR50001036, Rev. D www.calflamebbq.
LMS Customer Service Department 1462 East Ninth Street Pomona, CA 91766 Toll Free: 1-800-225-7727 Fax: 1-909-629-3890 www.calflamebbq.com LTR50001036, Rev.