Owner`s manual

ManualsBrandsCasablanca ManualsFanCHELSEA

HEHE

LSEALSEA

LSEA

™™

™

Safety and the proper operation of your Casablanca fan both require a thorough knowledge of the product and proper

installation; therefore, before attempting to install and operate your Casablanca fan, read this owner’s manual completely and

carefully. Retain this manual for future reference.

CAUTION: To avoid possible electrical shock, make certain that electricity is turned off at the circuit breaker or fuse box

before attempting any installation procedure.

CHELSEA

™

Owner’s Manual

READ AND SAVE THESE INSTRUCTIONS!

CONTENTS

INTRODUCTION

Before You Start . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

Safe Use . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

MOUNTING RECOMMENDATIONS

General Guidelines . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

Sloped Ceiling Installations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

FAN INSTALLATION

Getting Started . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

Crossbar Mounting Bracket Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

Lag Screw Installation (Optional) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

Canopy Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

Blade Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

Fan Preparation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

Hanging the Fan . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

Canopy Electrical Connections . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

Canopy Hatch Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

Switch Housing Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

Optional Light Kit Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9

VERSA•TOUCH2™ CONTROL INSTALLATION

Control Bracket Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10

Changing Transmitter Frequency Setting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11

Remote Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11

TROUBLESHOOTING TIPS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12

CARE RECOMMENDATIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13

AUTHORIZED SERVICE CENTERS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14

PRODUCT SPECIFICATIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16

C11U66M AA1205

Summary of content (16 pages)

PAGE 1
CHE LSEA™ HELSEA CHELSEA™ Owner’s Manual READ AND SAVE THESE INSTRUCTIONS! Safety and the proper operation of your Casablanca fan both require a thorough knowledge of the product and proper installation; therefore, before attempting to install and operate your Casablanca fan, read this owner’s manual completely and carefully. Retain this manual for future reference.
PAGE 2
INTRODUCTION BEFORE YOU START • CAUTION: RISK OF ELECTRICAL SHOCK! All wiring must be performed in accordance with national and local electrical codes. If you are unfamiliar with the wiring codes, you should use a qualified electrician. To avoid overheating and possible damage to other equipment, do not install control to a receptacle, fluorescent light fixture, motor operated appliance, or transformer-supplied appliance. • This fan is designed to be installed on an existing electrical outlet box.
PAGE 3
CHE LSEA™ HELSEA MOUNTING RECOMMENDATIONS GENERAL GUIDELINES Before mounting your Casablanca fan, read the following helpful recommendations. The location of the fan, air circulation, and fan size are all important factors to consider before installation. Location Ceiling fans have practical uses in almost every room in your home. We suggest you follow these mounting recommendations as you decide where to install your Casablanca fan.
PAGE 4
FAN INSTALLATION GETTING STARTED Installing a New Ceiling Fixture Outlet Box Using Existing Ceiling Fixture Outlet Box If you do not have an existing fixture located where you wish to place your Casablanca fan, an approved ceiling fixture outlet box must be installed and wired. After turning the power OFF at its source (either circuit breaker or fuse box), lower the old fixture and disconnect the wiring. Check the ceiling fixture outlet box to be sure that it is marked “Approved for Ceiling Fan Mounting.
PAGE 5
CHE LSEA™ HELSEA LAG SCREW INSTALLATION (OPTIONAL) NOTE: This step is required only under two conditions: If the fan weighs 36 lbs. or more (which does not pertain to this fan) or if the existing ceiling fixture outlet box needs to be modified for a ceiling fan application (for example, if the house is not new construction and you are replacing an existing light fixture). We recommend that the ceiling box be of sufficient capacity to support the weight of the fan and light fixture under any conditions.
PAGE 6
BLADE INSTALLATION BLADE HARDWARE (not to scale) Blades (4) (not included) Pack C: Blade Screws and Washers (17) Blade Irons (4) Pack D: Blade Iron Screws (9) Attach Blade Irons Step 4a. Using the blade screws in Pack C and the provided screwdriver, attach the blades to the blade holders by aligning the screw holes of the blade iron with the holes in the blade. Attach the blade iron using the four blade screws provided for each blade, as shown. Tighten securely by hand only. Blade Installation: Step 5.
PAGE 7
CHE LSEA™ HELSEA FAN PREPARATION (CONT.) Step 6c. Using the provided Allen wrench (attached to the paper motor warning shield), loosen the Allen set screw from the hanger adaptor. Insert the downrod into the motor coupling and turn it clockwise until it stops turning, ensuring that the pole has bottomed out. Step 6d. Tighten the set screw with the provided Allen wrench to ensure safe operation of your fan. If it is tight enough, you should not be able to turn the downrod counterclockwise with your hands.
PAGE 8
CANOPY ELECTRICAL CONNECTIONS Step 9. Attach the fan wires to the ceiling fixture outlet box wiring by placing the bare ends of the wires side by side and then securing with a wire nut. Test that the connection is secure by pulling on the wire nut. Connect in this order: • GREEN leads from mounting plate and downrod assembly of fan to GROUND conductor of power source. Secure with wire nut. • WHITE wire from fan to white NEUTRAL wire in ceiling fixture outlet box. Secure with wire nut.
PAGE 9
CHE LSEA™ HELSEA SWITCH HOUSING INSTALLATION (CONT.) Step 11d. Install the third screw and securely tighten all three screws by hand only using the provided screwdriver. Note: If you are not installing the optional light kit proceed to step 12. If you are installing the optional light kit, proceed to step 13. Installing the No Light Cap Step 12a. Using Pack E and the screwdriver provided; install each of the 3 screws into the switch housing mounting plate, as shown. Step 12b.
PAGE 10
VERSA•TOUCH2™ CONTROL INSTALLATION VERSA•TOUCH2™ HARDWARE (not to scale) 12v Battery W-73 Control Wood Screw 1" (2) Drywall Anchor 6-32 (2) Screw 6-32 X 3/8" (2) Screw 6-32 X 1" (2) W-73 Control Holder CONTROL BRACKET INSTALLATION SAFETY FIRST: To reduce the risk of electrical shock, this fan must be installed with an isolating wall control/switch. CAUTION! Do not use with wall dimmer. Step 8. Follow instructions for the type of transmitter control bracket you will be using.
PAGE 11
CHE LSEA™ HELSEA REMOTE OPERATION Fan Control To start the fan. Press the selected speed button to run the fan at the desired speed. Send Signal LED LOW=Low speed MED=Medium speed HIGH=High speed UPLIGHT To turn off the fan, press the FAN OFF button. Airflow Direction MED To reverse the airflow, press the REVERSE button. REVERSE operates at any speed whether the fan is on or off. The fan returns to its set speed after reversing.
PAGE 12
TROUBLESHOOTING TIPS Please refer to this troubleshooting guide before requesting service or contacting your dealer for assistance. PROBLEM POSSIBLE REMEDIES Fan will not start • Check the main circuit fuses, circuit breakers, and wall switch position. Check all wire connections. Make sure the power is turned off during this inspection. • The battery is weak. Install a fresh battery. • The fan receiver is defective. Replace fan receiver.
PAGE 13
CHE LSEA™ HELSEA CARE RECOMMENDATIONS Fan Finishes • For cleaning, a soft brush or lint-free cloth should be used to prevent scratching the finish. • A vacuum cleaner brush nozzle can remove heavier dust. • Surface smudges or an accumulation of dirt and dust can be removed easily by using a mild detergent and slightly dampened soft cloth. An antistatic agent may be used, but never use abrasive cleaning agents as these will damage the finish.
PAGE 14
AUTHORIZED SERVICE CENTERS STATE/CITY ZIP SERVICE CENTER NAME PHONE ALABAMA MOBILE TUSCALOOSA HUNTSVILLE 36618 35405 35816 AZALEA CITY SERVICE CENTER LTG. & APPL./LIGHTING PLUS SOUTHERN HOME & HEARTH INC. 251-341-0663 205-345-8900 256-534-1715 ALASKA ANCHORAGE 99518 PRIMARY ELECTRIC INC. 907-563-7988 ARIZONA TUCSON PHOENIX GREEN VALLEY SEDONA PRESCOTT LAKE HAVASU CITY SCOTTSDALE GLENDALE PHOENIX YUMA MESA MESA TUCSON YOUNGTOWN TUCSON 85735 DESERT BREEZE FAN & ELEC.
PAGE 15
CHE LSEA™ HELSEA STATE/CITY ZIP SERVICE CENTER NAME PHONE TYPE IOWA (CONTINUED) MONTICELLO CARROLL CORALVILLE DAVENPORT 52310 51401 52241 52803 REM ELECTRIC INC. J & L ELECTRIC INC. RALSTON CREEK SHAW ELECTRIC INC. 319-465-3346 712-792-2444 319-351-2189 563-323-3611 KANSAS WICHITA EMPORIA OVERLAND PARK OVERLAND PARK WICHITA MANHATTAN TOPEKA LENEXA SALINA OVERLAND PARK OVERLAND PARK 67211 66801 66213 66210 67226 66502 66611 66215 67401 66223 66212 ACTION APPLIANCE SERVICE INC. C.A.P.
PAGE 16
STATE/CITY ZIP SERVICE CENTER NAME PHONE OKLAHOMA OKLAHOMA CITY OKLAHOMA CITY OKLAHOMA CITY 73105 73132 73127 APPLIANCE SERVICE BY CK LARKIN E. STEVENSON JAMES LIGHTING INC. 405-525-8862 405-728-8810 405-947-6663 OREGON PORTLAND BEND 97225 97701 SYLVAN ELECTRONICS INC. DESIGN LIGHTING INC.