User's Manual

Installation

Priming the Chemical Injectors and Approximate Chemical Settings

Each chemical injector can be adjusted using its prime button and concentration adjusting screw.

These controls are located on the right side of the control box located in the lower compartment of the

glasswasher. The white injector rotors are visible through the control box window.

ALL OF THE CHEMICAL SETTINGS BELOW ARE APPROXIMATIONS.

CONSULT A QUALIFIED CHEMICAL REPRESENTATIVE TRAINED IN THE USE OF THE TEST

EQUIPMENT REQUIRED FOR TAKING SAMPLES AND PERFORMING ADJUSTMENTS.

1. Priming the Pumps:

Make sure the proper chemical pick-up tube is in its supply container, then

 pushandholdtheprimebuttonuntilthedetergent,sanitizerandrinse-aidfeedtubesarefullof 

chemical.

2. Approximate Chemical Settings:

The approximate chemical volume dispensed by the chemical injector rotors can be

determined by counting the number of revolutions of the injector rotor.

Detergent - 1 revolution in 1-second of the detergent pump rotor ~ 0.35% concentration.

 Sanitizer- 1revolutionin5-seconds~12.5ppmofIodophoror50ppmofchlorine.

Rinse-aid - 1 revolution in 8-seconds ~ the median volume recommended.

 TurntheInjectorConcentrationscrewsclockwisetoincreaseorcounter-clockwise

to decrease the volume of dispensed chemical.

3. Thedetergentchemicalsettingmustbeperformedwhenthehot-waterllsolenoidvalveisopen. 

 Thehot-watervalveisopenwhenthepowerswitchisintheONpositionduringinitialllandwhen

 thedetergenttankoatassemblycallsforhotwater

 Thesanitizerandtherinse-aidsettingcanbeperformedwheneverthecold-waterllsolenoidvalve

 isopen.Thecold-waterllvalveisopenwhenevertheglasswasherpowerswitchisONand 

 theconveyoristurning.Aseparaterinse-aidisnotneededwhenIodophorisusedasasanitizer. 

 TurntheInjectorConcentrationScrewfullycounter-clockwiseuntiltherinse-aidinjectorrotorstops 

turning.

Push to prime

Turn CW to increase(+)

CCW to decrease (-)

DET

SAN

R/A

Chemical Injector Prime and Concentration Controls

Detergent

Sanitizer

Rinse-aid

Rotor