OWNER’S MANUAL & OPERATING INSTRUCTIONS FPO Image 6800 Starting Watts / 5500 Rated Watts PORTABLE GENERATOR MODEL NUMBER 41135 SAVE THESE INSTRUCTIONS Important Safety Instructions are included in this manual. MADE IN CHINA REV 41135-20110701 10006 Santa Fe Springs Road Santa Fe Springs CA 90670 USA / 1-877-338-0999 www.championpowerequipment.
Have questions or need assistance? Do not return this product to the store! WE ARE HERE TO HELP! Visit our website: www.championpowerequipment.
41135 6800 Starting Watts / 5500 Rated Watts PORTABLE GENERATOR Table of Contents Introduction. . . . . . . . . . . . . . . . . . . . . . . . . . . . . Introduction. . . . . . . . . . . . . . . . . . . . . . . . . . . Portable Power Generator. . . . . . . . . . . . . . . . . . Accessories . . . . . . . . . . . . . . . . . . . . . . . . . . . This Booklet. . . . . . . . . . . . . . . . . . . . .
ENGLISH 41135 Introduction Introduction Accessories Congratulations on your purchase of a Champion Power Equipment generator. CPE designs and builds generators to strict specifications. With proper use and maintenance, this generator will bring years of satisfying service. Champion Power Equipment manufactures and sells accessories designed to help you get the most from your purchase. To find out more about our covers, power cables and storm kits, please visit our web site at: www.
41135 ENGLISH Manual Conventions This manual uses the following symbols to help differentiate between different kinds of information. The safety symbol is used with a key word to alert you to potential hazards in operating and owning power equipment. Follow all safety messages to avoid or reduce the risk of serious injury or death. DANGER DANGER indicates an imminently hazardous situation which, if not avoided, will result in death or serious injury.
ENGLISH 41135 Safety Rules WARNING Read this manual thoroughly before operating your generator. Failure to follow instructions could result in serious injury or death. WARNING The engine exhaust from this product contains chemicals known to the state of California to cause cancer, birth defects, or other reproductive harm. DANGER Generator exhaust contains carbon monoxide, a colorless, odorless, poison gas. Breathing carbon monoxide will cause nausea, dizziness, fainting or death.
41135 ENGLISH DANGER Safety Rules WARNING Fuel and fuel vapors are highly flammable and extremely explosive. Fire or explosion can cause severe burns or death. Unintentional startup can result in entanglement, traumatic amputation or laceration. Rapid retraction of the starter cord will pull hand and arm towards the engine faster than you can let go. Unintentional startup can result in entanglement, traumatic amputation or laceration. Broken bones, fractures, bruises or sprains could result.
ENGLISH 41135 Controls and Features Read this owner’s manual before operating your generator. Familiarize yourself with the location and function of the controls and features. Save this manual for future reference. Generator 1 8 2 3 7 4 6 5 5 (1) Fuel Tank – 5.9 gallon (22.4 L) capacity fuel tank. (5) Recoil Starter – Used to start the engine. (2) Choke – Used to start the engine. (6) Oil Filler Cap – Check and fill engine oil level.
41135 ENGLISH Controls and Features Power Panel 1 2 3 4 (1) Engine Switch – Used to turn the generator on and off. (2) Circuit Breakers – Protects the generator against electrical overloads. Push to reset breaker. (3) Voltmeter – Used to display alternator output voltage. (4) 120/240 Volt AC, 30 Amp Twist-Lock Receptacle 5 6 (5) 120 Volt AC, 20 Amp Duplex (2) (NEMA 5-20R) – May be used to supply electrical power for the operation of 120 Volt AC, 20 Amp, single phase 60 Hz electrical loads.
ENGLISH 41135 Controls and Features Parts Included Your 41135 Gasoline Powered Generator ships with the following parts: Wheel Kit –– –– –– –– –– –– –– –– –– –– –– 8” Wheel. . . . . . . . . . . . . . . . . . . . . . . . . Flange Bolt (M10x105 for Wheel) . . . . . . . . Bushing. . . . . . . . . . . . . . . . . . . . . . . . . . Flat Washer 10. . . . . . . . . . . . . . . . . . . . . Nut (M10). . . . . . . . . . . . . . .
41135 ENGLISH Your generator requires some assembly. This unit ships from our factory without oil. It must be properly serviced with fuel and oil before operation. If you have any questions regarding the assembly of your generator, call our help line at 1-877-338-0999. Please have your serial number and model number available. Assembly Install the Support Leg 1. Attach the support leg to the generator frame with cap screws (M8x16) and nuts (M8). 2.
ENGLISH 41135 Assembly Add Engine Oil Cont’d. Add Fuel Cont’d. 3. Clean the area around the fuel cap. 4. Remove the fuel cap. 5. Slowly add fuel to the tank. DO NOT overfill. Allow approximately ¼ inch of space for fuel expansion. 2. Remove oil fill cap/dipstick to add oil. 3. Add 1.16 qt (1.1 L) of oil and replace oil fill cap/ dipstick. See “Specifications” pages for oil recommendations based on operating conditions. 6. Screw on the fuel cap and wipe away any spilled fuel.
41135 ENGLISH Operation Generator Location Starting the Engine Please consult your local authority. In some areas, generators must be registered with the local utility. Generators used at construction sites may be subject to additional rules and regulations. This generator must have at least five feet of clearance from combustible material. Leave at least three feet of clearance on all sides of the generator to allow for adequate cooling, maintenance and servicing.
ENGLISH 41135 Operation Connecting Electrical Loads Do Not Overload Generator 1. Let the engine stabilize and warm up for a few minutes after starting 2. Plug in and turn on the desired 120/240 Volt AC single phase, 60 Hz electrical loads. –– DO NOT connect 3-phase loads to the generator. –– DO NOT connect 50 Hz loads to the generator. –– DO NOT overload the generator.
41135 ENGLISH Operation Wattage Reference Chart Operation at High Altitude Use the chart to determine approximate wattage requirements for your equipment. The density of air at high altitude is lower than at sea level. Engine power is reduced as the air mass and airfuel ratio decrease. Engine power and generator output will be reduced approximately 3½% for every 1000 feet of elevation above sea level. This is a natural trend and cannot be changed by adjusting the engine.
ENGLISH 41135 MAINTENANCE ANd STORAGE The owner/operator is responsible for all periodic maintenance . WARNING Never operate a damaged or defective generator . WARNING Oil Cont’d. NOTE Once oil has been added, a visual check should show oil about 1-2 threads from running out of the fill hole . If using the dipstick to check oil level, DO NOT screw in the dipstick while checking . Tampering with the factory set governor will void your warranty . WARNING Improper maintenance will void your warranty .
41135 ENGLISH Spark Arrester 1. Allow the engine to cool completely before servicing the spark arrester. 2. Remove the three screws holding the cover plate which retains the end of the spark arrester to the muffler. 3. Remove the spark arrester screen. 4. Carefully remove the carbon deposits from the spark arrester screen with a wire brush. 5. Replace the spark arrester if it is damaged. 6. Position the spark arrester in the muffler and attach with the three screws.
Maintenance and Storage Generator Maintenance Make certain that the generator is kept clean and stored properly. Only operate the unit on a flat, level surface in a clean, dry operating environment. DO NOT expose the unit to extreme conditions, excessive dust, dirt, moisture or corrosive vapors. CAUTION DO NOT use a garden hose to clean the generator. Water can enter the generator through the cooling slots and damage the generator windings. Use a damp cloth to clean exterior surfaces of the generator.
41135 ENGLISH Specifications Engine Specifications Spark Plugs –– Engine. . . . . . . . . . . . . . . . . . . . . 338 cc OHV CPE Recommended replacement spark plug: –– NGK BR6ES or equivalent Make certain the spark plug gap is 0.7 – 0.8 mm or (0.028 – 0.031 in.). Generator Specifications –– –– –– –– –– –– –– –– –– –– –– Rated Wattage . . . Starting Wattage. . AC Load . . . . . . . Phase. . . . . . . . . Frequency . . . . . . Fuel Capacity. . . . Gross Weight . .
Specifications Parts Diagram 17 REV 41135-20110701 ENGLISH 41135
41135 ENGLISH Parts List # Part Number Description 1 ST160F-1070007 clip 2 ST05FD-04712003-CARB Air cleaner hose Qty # Part Number Description 2 54 ST188FD-1152010-4 Stator assy 1 1 55 GB7244 10 Spring washer 10 1 56 GB96 10 Washer 10 1 57 ST05FD-1152020-4 Rotor comp 1 58 GB5789 M6×8 Flange Bolt M6×8 2 59 ST05FD-1151600 Cover 1 60 ST05FD-1152008 Plug-A 1 61 ST05FD-1152009 Plug-B 1 62 182FD-GC 182FD-GC style Engine 1 63 ST182FD-1151110-B Handle 1 64 G
Specifications Engine Parts Diagram 19 REV 41135-20110701 ENGLISH 41135
41135 ENGLISH # Part Number Description Qty 1 GB5789--86-FB6-8 ST188F-1060100-G ST188F-1060009 ST188F-1060008 ST160F-1061200 ST188F-1060007 ST188F-1060006 ST188F-1060004 ST188F-1060005 ST188F-1060003 ST188F-1060002 ST188FD-1130004 GB5789--86-FB6-12 ST188FD-1081000-G ST188FD-1030003-A ST188FD-1030014 GB5789-86-FB8-40 ST188F-1030200 ST188F-1050004 ST188F-1050005 ST188F-1050200 ST182F-1050001 ST182F-1050100 ST182F-1050003 ST182F-1050002 ST188F-1080002-G ST188F-1040011 ST188F-1040003 ST188F-1040004 ST188F-
Specifications Wiring Diagram 21 REV 41135-20110701 ENGLISH 41135
41135 ENGLISH Troubleshooting Problem Cause Solution Generator will not start No fuel Add fuel Faulty spark plug Replace spark plug Unit loaded during start up Remove load from unit Low oil level Fill crankcase to the proper level Generator will not start; Place generator on a flat, level surface Generator starts but runs roughly Choke in the wrong position. Adjust choke.
ENGLISH 41135 Warranty WARRANTY CHAMPION POWER EQUIPMENT 2 YEAR LIMITED WARRANTY Warranty Qualifications Champion Power Equipment (CPE) will register this warranty upon receipt of your Warranty Registration Card and a copy of your sales receipt from one of CPE’s retail locations as proof of purchase. Please submit your warranty registration and your proof of purchase within ten (10) days of the date of purchase.