Operator's Manual
Model 100199
GENERAL INFORMATION
19
© 2015 Champion Power Equipment Part No. 101048
FUEL SYSTEM
The engine is tted with a dual master mixer assembly
carburetion system, which allows it to run on either NG or
LPG. It has been congured at the factory to run on NG. If your
installation requires the engine to run on LPG, orices in the
master mixer assembly carburetor must be changed.
BATTERY REQUIREMENTS
Champion requires two (2) 12 volt batteries with a minimum of
18 Ah with a minimum of 270 CCA each. [battery size: 6-7/8
L x 3-7/16 W x 6-1/8 H inches (175 mm L x 87 mm W x 155
mm H)]. Purchase the batteries locally. Install the positive battery
cable rst.
Install a cable from the positive (+) terminal of one battery to the
negative (–) terminal of the other battery. Always connect the
positive (+) battery cable to the generator rst. (Figure 8)
Figure 8
!
CAUTION
For battery installation, maintenance, and safety
requirements refer to purchased manufacturer battery
installation and safety manual.
BATTERY CHARGING
The generator is equipped with an automatic battery charger. The
charger will sense the battery’s state of charge and automatically
charge the battery when required. LED lights on the charger display
the battery state of charge. See Figure 7 on page 17.
MODEL AND SERIAL NUMBER
The model and serial number plate is afxed to the generator
above the control panel. Have this information if calling for
service or ordering parts. (Figure 9)
CHAMPION POWER EQUIPMENT
12039 Smith Ave., Santa Fe Springs, CA 90670 USA
P/N 100970
CARCASA A PRUEBA DE LLUVIA EQUIPADO
BOÎTIER ÉTANCHE À LA PLUIE ÉQUIPÉ
RAINPROOF ENCLOSURE FITTED
RATED CURRENT 70.8 A / 35.4 A (LPG) COURANT NOMINALE 70,8 A / 35,4 A (GPL) CORRIENTE NOMINAL 70,8 A / 35,4 A (LPG)
RATED VOLTAGE 120/240~,single-phase TENSION NOMINALE 120 / 240~,monophasées
TENSIÓN NOMINAL
120 / 240~,monofásicas
RATED FREQUENCY
60 Hz
FRÉQUENCE NOMINALE
60 Hz
FRECUENCIA NOMINAL
60 Hz
POWER FACTOR 1.0 FACTEUR DE PUISSANCE 1,0 FACTOR DE POTENCIA 1,0
MAX LOAD UNBALANCE MAX DÉSÉQUILIBRE DE CHARGE MAX DESEQUILIBRIO DE LA CARGA50% 50 % 50 %
RATED ENGINE SPEED
3600 r/min
RÉGIME MOTEUR NOMINAL
3600 r/min
VELOCIDAD NOMINAL DEL MOTOR
3600 r/min
RATED AMBIENT TEMP TEMPÉRATURE AMBIANTE NOMINALE TEMPERATURA AMBIENTE NOMINAL25-40 ºC 25-40 ºC 25-40 ºC
AISLANTE CLASEISOLATION DE CLASSE
INSULATION CLASS
H H H
Conforms to UL Std.
No. 2200
Certified to
CAN/CSA Standard
C22.2 No. 100
FOR STANDBY SERVICE
PARA EL SERVICIO SUPLENTEPOUR LE SERVICE DE SECOURS
NEUTRAL
FLOATING NEUTRE FLOTTANT NEUTRO FLOTANTE
100199
STATIONARY ENGINE DRIVEN GENERATOR / STATIONNAIRE GÉNÉRATEUR ENTRAÎNÉ PAR UN MOTEUR /
ESTACIONARIO ACCIONADA POR EL MOTOR GENERADOR
MODEL
MODELO
MODÈLE
Figure 9
1
To Starter
To Ground
2