OPERATOR'S MANUAL MODEL #100571 3500W Portable Inverter Generator REGISTER YOUR PRODUCT ONLINE at championpowerequipment.com or visit championpowerequipment.com SAVE THESE INSTRUCTIONS. This manual contains important safety precautions which should be read and understood before operating the product. Failure to do so could result in serious injury. This manual should remain with the product.
CARBON MONOXIDE SAFETY: THE BIG PICTURE As the only safe way to use a portable generator, taking your generator outside is absolutely mandatory to keep your family safe from carbon monoxide. But there’s even more you can do. By educating yourself about all carbon monoxide risks, you’ll be better prepared to protect your family from this colorless, oderless threat.
Table of Contents 100571 - 3500W Portable Inverter Generator TABLE OF CONTENTS Maintenance................................................. 24 Cleaning the Generator........................................... 24 Introduction.................................................... 4 Changing the Engine Oil.......................................... 25 Safety Definitions........................................... 4 Cleaning and Adjusting the Spark Plug...........................
Introduction 100571 - 3500W Portable Inverter Generator INTRODUCTION SAFETY DEFINITIONS Congratulations on your purchase of a Champion Power Equipment (CPE) product. CPE designs, builds, and supports all of our products to strict specifications and guidelines. With proper product knowledge, safe use, and regular maintenance, this product should bring years of satisfying service. The purpose of safety symbols is to attract your attention to possible dangers.
Important Safety Instructions 100571 - 3500W Portable Inverter Generator IMPORTANT SAFETY INSTRUCTIONS DANGER Operate equipment with guards in place. WARNING Rotating parts can entangle hands, feet, hair, clothing and/or accessories. Traumatic amputation or severe laceration can result. Cancer and Reproductive Harm – www.P65Warnings.ca.gov DANGER Keep hands and feet away from rotating parts. Generator exhaust contains carbon monoxide, a colorless, odorless, poisonous gas.
Important Safety Instructions 100571 - 3500W Portable Inverter Generator CAUTION WARNING Spark from removed spark plug wire can result in fire or electrical shock. Start the generator and allow the engine to stabilize before connecting electrical loads. When servicing the generator: Connect electrical equipment in the off position, and then turn them on for operation. Disconnect the spark plug wire and place it where it cannot contact the plug or any other metal object.
Important Safety Instructions 100571 - 3500W Portable Inverter Generator Fuel Safety When transporting or servicing the generator: Always check that the fuel valve is in the OFF position and the gasoline tank is empty. DANGER GASOLINE AND GASOLINE VAPORS ARE HIGHLY FLAMMABLE AND EXPLOSIVE. Disconnect the spark plug wire. Fire or explosion can cause severe burns or death. Store away from sparks, open flames, pilot lights, heat and other sources of ignition.
Important Safety Instructions 100571 - 3500W Portable Inverter Generator Safety and Dataplate Labels These labels warn you of potential hazards that can cause serious injury. Read them carefully. If a label comes off or becomes hard to read, contact Technical Support Team for possible replacement.
Important Safety Instructions 100571 - 3500W Portable Inverter Generator Safety Symbols Some of the following symbols may be used on this product. Please study them and learn their meaning. Proper interpretation of these symbols will allow you to more safely operate the product. SYMBOL MEANING Read Operator’s Manual. To reduce the risk of injury, user must read and understand operator’s manual before using this product. Clearance. Keep all objects at least 5 feet (1.5m) from generator.
Important Safety Instructions 100571 - 3500W Portable Inverter Generator Operation Symbols Some of the following symbols may be used on this product. Please study them and learn their meaning. Proper interpretation of these symbols will allow you to more safely operate the product. SYMBOL MEANING SYMBOL MEANING On or Run Neutral Floating. Neutral circuit IS NOT electrically connected to the frame/ ground of the generator.
Important Safety Instructions 100571 - 3500W Portable Inverter Generator Quick Start Label Symbols Some of the following symbols may be used on this product. Please study them and learn their meaning. Proper interpretation of these symbols will allow you to more safely operate the product. 1 2 3 5 4 1 6 10W-30 2 3625-L-OP-A Starting the Engine Stopping the Engine DANGER Move generator outside and far away from windows, doors and intake ventilation covers. APN 1.
Controls and Features 100571 - 3500W Portable Inverter Generator CONTROLS AND FEATURES Read this operator’s manual before operating your generator. Familiarize yourself with the location and function of the controls and features. Save this manual for future reference. Generator 1 5 6 4 7 2 3 8 1. Carrying Handle – Used to lift or carry the unit. 5. Fuel Cap – Remove to add fuel. 2. Recoil Starter – Used to manually start the engine. 6. Spark Plug Access Cover 3.
Controls and Features 100571 - 3500W Portable Inverter Generator Control Panel 3 4 5 2 6 1 7 B 9 8 A 1. EZ Start Dial – Used to start, stop and choke the generator. RECEPTACLES 2. Intelligauge – See Intelligauge section. 3. CO Shield® LED – The CO Shield® technology monitors for accumulation of poisonous carbon monoxide (CO) gas produced by engine exhaust when the generator is running. If CO Shield® detects elevated levels of CO gas, it automatically shuts off the engine.
Controls and Features 100571 - 3500W Portable Inverter Generator Intelligauge Five modes digital meter for displaying voltage, frequency, session run time, total run time and power output. Mutli-colored LED indicates CO shutoff or fault. MODE DESCRIPTION Output voltage of the generator. Voltage (V) Example: 120 volts Output frequency in hertz. Frequency (H) Example: 60.0 hertz Run time of the generator for the current session.
Controls and Features 100571 - 3500W Portable Inverter Generator FCC Statement Parts Included Accessories 1. This device complies with Part 15 of the FCC Rules. Operation is subject to the following two conditions: Dual Port USB Adapter (5v/2.4A)................................... 1 1a. This device may not cause harmful interference. Engine Oil....................................... 13.5 fl. oz. (400 ml) 1b.
Assembly 100571 - 3500W Portable Inverter Generator ASSEMBLY Add Engine Oil Your generator requires some assembly. This unit ships from our factory without oil. It must be properly serviced with fuel and oil before operation. WARNING DO NOT attempt to crank or start the engine before it has been properly filled with the recommended type and amount of oil. Damage to the generator as a result of failing to follow these instructions will void your warranty.
Assembly 100571 - 3500W Portable Inverter Generator 3. Remove oil fill cap/dipstick to add oil. NOTICE 4. Using a funnel(included), add up to 12.9 fl. oz. (380 ml) of oil (included). DO NOT OVERFILL. Replace oil fill cap/dipstick and secure maintenance cover. The first 5 hours of run time are the break-in period for the unit. During the break in period stay at or below 50% of the running watt rating and vary the load occasionally to allow stator windings to heat and cool.
Assembly 100571 - 3500W Portable Inverter Generator Use clean, fresh, regular unleaded gasoline with a minimum octane rating of 87 and an ethanol content of 10% or less by volume. y b c NOTICE The generator engine works well with 10% or less ethanol blended gasoline. When using ethanol-gasoline blends there are some issues worth noting: DO NOT mix oil with gasoline. 1. Remove the gasoline cap. – Ethanol-gasoline blends can absorb more water than gasoline alone. 2. Slowly add gasoline to the tank.
Operation 100571 - 3500W Portable Inverter Generator Neutral Bonded to Frame* In the event of an engine shut off, when you approach the generator to investigate, a blinking red LED light in the CO Shield® area provides notification that the generator shut off due to an accumulating CO hazard. The red LED light will blink for at least five (5) minutes after an engine shut off event. – Neutral circuit IS electrically connected to the frame/ground of the generator.
Operation 100571 - 3500W Portable Inverter Generator Generator Location NOTICE WARNING CO Shield® will detect the accumulation of carbon monoxide (CO) from other fuel burning sources such as engine powered equipment, or propane heaters used in the area of operation. If another generator is used and the exhaust stream is pointed at a CO Shield® equipped generator, the CO Shield® may initiate a shutoff due to rising carbon monoxide (CO) levels. This is not a fault.
Operation 100571 - 3500W Portable Inverter Generator 4. Pull the recoil cord slowly until resistance is felt and then pull rapidly. WARNING Do not expose to rain or use in damp locations. Keep all objects a minimum of 5 feet (1.5m) away from the generator at all times. Heat from the muffler surface and exhaust gas stream can ignite combustible materials. WARNING If you must operate in rain or damp locations, DO NOT operate without proper protection of the electrical components.
Operation 100571 - 3500W Portable Inverter Generator Do Not Overload Generator NOTICE Capacity If the engine starts but does not continue to run make certain that the generator is on a flat, level surface. The engine is equipped with a low oil sensor that will prevent the engine from running when the oil level falls below a critical threshold. Follow these simple steps to calculate the running and starting watts necessary for your purposes: 1.
Operation 100571 - 3500W Portable Inverter Generator 3. Turn the EZ Start dial clockwise to the “STOP” position. NOTICE Never exceed the specified capacity when adding loads to the generator. Eco (Economy) Mode The Eco Mode button can be activated to turn on economy control in order to minimize fuel consumption and noise while operating the unit during times of reduced electrical output. Eco Mode allows the engine speed to idle during periods of non-use.
Maintenance 100571 - 3500W Portable Inverter Generator 2. Press the button inside the handle as shown below and extend the telescoping handle until a click is heard and the handle is locked in its fully extended position. WARNING Operation using the alternative main jet at elevations lower than the recommended minimum altitude can damage the engine. For operation at lower elevations, the originally supplied standard main jet must be used.
Maintenance 100571 - 3500W Portable Inverter Generator Cleaning and Adjusting the Spark Plug 3. Use an air compressor (25 PSI) to clear dirt and debris from the generator. 1. Remove spark plug access cap from the top panel. 4. Inspect all air vents and cooling slots to ensure that they are clean and unobstructed. To prevent accidental starting, remove and ground the spark plug wire before performing any service. Changing the Engine Oil Change oil when the engine is warm.
Maintenance 100571 - 3500W Portable Inverter Generator Cleaning the Air Filter 7. Position the spark arrestor on the muffler and attach with the screws removed in step 2. 1. Remove the oil drain side maintenance cover by pushing and turning the two fasteners counterclockwise to the unlocked horizontal position. CAUTION Failure to clean the spark arrestor will result in poor engine performance. 2. Locate the air filter plastic cover and remove.
Storage 100571 - 3500W Portable Inverter Generator EVERY 50 HOURS OR ANNUALLY Clean air filter Change oil if operating under heavy load or in hot environments EVERY 100 HOURS OR ANNUALLY Change oil Clean/adjust spark plug Clean spark arrestor Clean fuel valve filter* 4. Let the engine run until fuel starvation has stopped the engine. 5.
Storage 100571 - 3500W Portable Inverter Generator Removing from Storage 13. Clean the generator according to Cleaning the Generator. 14. Store the generator in a cool, dry place out of direct sunlight. NOTICE Long Term Storage (more than 1 year) If the generator has been improperly stored for a period longer than 30 days with ethanol blended gasoline in the gasoline tank and/or carburetor, all fuel must be drained and the carburetor must be thoroughly cleaned of ethanol build up.
Specifications 100571 - 3500W Portable Inverter Generator SPECIFICATIONS Oil Specifications DO NOT OVERFILL. Generator Specifications Type.. ........................................... *See following chart Generator Model............................................ 100571 Capacity........................................ 12.9 fl. oz. (380 ml) Start Type.................................................... Manual Recommended Engine Oil Type Watts (Starting/Running)...............................
Troubleshooting 100571 - 3500W Portable Inverter Generator TROUBLESHOOTING Problem Cause Solution No fuel. Add fuel. Faulty spark plug. Clean and adjust spark plug or replace. Fill crankcase to the proper level. Low oil level. Engine will not start. Place generator on a flat, level surface. Spark plug wire loose. Attach wire to spark plug. Fuel valve is closed. Open fuel valve. EZ Start dial OFF. Turn EZ Start dial ON. Old fuel or water in fuel. Drain fuel and replace with fresh fuel.
Troubleshooting 100571 - 3500W Portable Inverter Generator Problem Cause Solution Move generator to an open, outdoor area. Point exhaust away from people and buildings. Move to fresh air and get medical help if sick, dizzy, or weak. Engine starts and shuts off right away. Both CO Shield® LEDs not blinking 10 times upon start up. Generator cannot supply enough power or overheating. Engine is running but no AC output.
Troubleshooting 100571 - 3500W Portable Inverter Generator Problem Engine hunts or falters. Repeated circuit breaker tripping. Cause Solution Engine governor defective. Contact the help line. Dirty fuel valve. Clean the fuel valve. Carburetor is dirty and running lean. Contact the help line. Choke in wrong position. Move EZ Start Dial to the RUN position. Overload. Review load and adjust. See “Connecting Electrical Loads.” Faulty power cords or device.
WARRANTY 100571 - 3500W Portable Inverter Generator WARRANTY* Other Exclusions CHAMPION POWER EQUIPMENT 3 YEAR LIMITED WARRANTY This warranty excludes: – Cosmetic defects such as paint, decals, etc. – Wear items such as filter elements, o-rings, etc. Warranty Qualifications – Accessory parts such as starting batteries, and storage covers. To register your product for warranty and FREE lifetime call center technical support please visit: https://www.championpowerequipment.
CHAMPION POWER EQUIPMENT, INC. (CPE), THE UNITED STATES ENVIRONMENTAL PROTECTION AGENCY (U.S. EPA) AND THE CALIFORNIA AIR RESOURCES BOARD (CARB) EMISSION CONTROL SYSTEM WARRANTY Your Champion Power Equipment (CPE) engine complies with both the U.S. EPA and state of California Air Resources Board (CARB) emissions regulations.
EMISSION CONTROL SYSTEM WARRANTY The following are specific provisions relative to your Emission Control System (ECS) Warranty Coverage. 1. APPLICABILITY: This warranty shall apply to 1995 and later model year California small off-road engines (SORE) (for other states, 1997 and later model year engines). The ECS Warranty Period shall begin on the date the new engine or equipment is delivered to its original, end-use purchaser, and shall continue for 24 consecutive months thereafter. 2.
EMISSION-RELATED PARTS INCLUDE THE FOLLOWING: (using those portions of the list applicable to the engine) Systems covered by this warranty Parts Description Fuel Metering System Fuel regulator, Carburetor and internal parts Air Induction System Air cleaner, Intake manifold Ignition System Spark plug and parts, Magneto ignition system Exhaust System Exhaust manifold, catalytic converter Miscellaneous Parts Tubing, Fittings, Seals, Gaskets, and Clamps associated with these listed systems.
