Use & Care Guide Model: 415.16152110 I
CALIFORNIA If you smell gas: PROPOSITION 65 2. Extinguish any open flame. 1. Combustion by-products produced when using this product contain chemicals known to the State of California to cause cancer, birth defects, and other 3. Open lld. reproductive 4. If odor continues, keep away from the appliance 2. This product contains chemicals, including lead and lead compounds, known to the State of California to cause cancer, birth defects or other reproductive harm. |. Shut off gas to the appliance.
For Your Safety ...................................... 2 KENMORE Grill Information GRILL WARRANTY Center .............................. 2 Product Record Information........................... 2 One Year Full Warranty Safety Symbols ...................................... 2 If this grill fails due to a defect in material or workmanship within one year from the date of purchase, call 1-800-4-MY-HOME ® to arrange for free repair (or Installation Safety Precautions.........................
LP Tank * The LP Tank used with your grill requirements: must meet the following * Use LP Tanks only with these required / x, II • NEVER store a spare appliance (30.5cm) capacity _/ LP cylinder or in an enclosed under or near the area. (diameter) maximum. measurements: 12" x 18" (45.7 cm) (tall) with 20 lb. (9 kg.) " LP Tanks must be constructed and marked in accordance with specifications for LP Tanks of the U.S.
LP Tank Exchange * Many retailers that sell grills offer you the option of replacing your empty LP tank through an exchange Use only those reputable exchange companies that precision fill, test and certify their tanks. Exchange tank only for an OPD safety feature-equlpped tank described in the "LP Tank" section of this manual. service. inspect, your as Connecting Regulator To The LP Tank l. LP tank must be properly assembly section.) 2. Turn all control secured onto grill.
Leak Testing Valves, Hose and Regulator 1. Turn all grill control knobs to OFF. 2. Be sure regulator is tightly connected to LP tank. 3. Completely open LP tank valve by turning OPD hand wheel counterclockwise. If you hear a rushing sound, turn gas off immediately. There is a major leak at the connection. Correct before proceeding parts at 1-800-4-MY-HOME Hold coupllncj nut and regulator 4. Brush soapy solution picture below: as shown for proper connection to LP tank valve. by calling ®.
For Safe Use of Your Grill and to Avoid Serious Injury: • Do not let children operate or play near grill. • Keep grill area clear and free from materials that burn. Safety Tips A Before opening LP cylinder valve, check the coupling nut for tightness. A When grill is not in use, turn off all control knobs and LP cylinder valve. A Never move grill while in operation or still hot. A Use long-handled barbecue utensils and oven mitts to avoid burns and splatters.
Burner Flame Check " Remove cooking grates and flame tamers. Light burners, rotate knobs from Hi to LOW. You should see a smaller Turn controls In and gas source or tank OFF when not use. flame in LOW position than seen on Hi. Perform burner flame check on sideburner, also. Always check flame prior to each use. If only low flame is seen refer to "Sudden drop or low flame" in the Troubleshooting --HI Section.
3. Remove carryover tubes and burners. 4. Detach electrode from burner. CAUTION NOTE: Removal/Detachment method will depend on the burner configuration. See different configurations in illustrations below. f SPIDER ALERT! 5. Carefully lift each burner up and away from valve openings. We suggest three ways to clean the burner tubes. Use the one easiest for you. (A) Bend a stiff wire (a light weight coat hanger works well) into a small hook. Run the hook through each burner tube several times.
Indirect Cooking Food Safety Poultry and large cuts of meat cook slowly to perfection the grill by indirect heat. Place food over unlit burner(s); heat from lit burners circulates cooking meat or poultry This method fatty greatly gently throughout without when cooking cuts because there is no direct flame and juices that drip during the grill, the touch of a direct reduces flare-ups on the flame. extra to ignite the fats cooking.
Key Qty DeScription 'Part # Key Qty Description Part # 1 1 LEFT LEG ASSEMBLY G550-1300-W1 37 1 CLIP F/ SIDEBURNER G405-0019-W1 2 1 MATCH HOLDER G401-OO79-W1 38 1 SIDEBURNER GRID G430-0053-W1 3 1 RIGHT LEG ASSEMBLY G550-1400-W1 39 1 SHIELD, HEAT, FIREBOX G550-5104-W1 4 1 BOTTOM SHELF G550-0800-W1 40 4 HEAT DIFFUSER G550-OOO6-W1 5 1 FRONT PANEL G550-O900-W3 41 3 COOKING G550-0012-W1 SWING AWAY GRATE G550-0011-W1 GRATE 6 2 TANK EXCLUSION WIRE G550-OOO4-W1
® _i_ _!i_ii_ \ © _2 o 464220511
CAUTION: When unpacking grill components, two people E1 should raise grill head from the shipping box. Bottom Shelf to Legs [] Place bottom shelf end with cut out hole for LP cylinder between leg assembly with axle holes. Attach to right and left leg assemblies with (4) 1/4-20x1-1/2" [] Tighten securely. screws and (4) 1/4-20 1/4-20 Match Holder flange nuts. Flange nuts Qty. 4 1/4-20x1-1/2" Qty.
[] Attach sheet metal screws. Make sure metal tabs for Front Panelfront panel to grill cart with (6) #8-32x3/8" tank exclusion wires are toward the bottom of cart. B #8-32x3/8" sheet metal screws Qty. 6 Tank Exclusion Wire [] Hang tank exclusion wire onto front panel brackets; #8-32x3/8" sheet metal screws. #8-32x3/8" sheet metal screws Qty.
Wheels and Leg Extenders to Cart [] Turn cart assembly upside down. [] Insert axle rod through wheel, wheel spacer, legs and other wheel. Be sure to face "cone" wheel against leg. Attach with (t) axle washer and hitch pin. [] Hammer leg extenders into right legs. Wheel Spacer Hitch Pin Qty. 1 Axle Rod Axle Washer Qty. 1 side of Leg Extenders Qty. 1 Wheel Axle Washer / Wheel Spacer \ Hitch Pin "Cone" side of wheel against leg 464220511 - 15
Grill Head to Cart [] Stand cart upright. [] This step requires two people to lift and position grill head onto cart. [] Carefully lower the grill head onto the cart. Make sure the regulator hose is hanging outside the cart. Attach head to cart with (4) 1/4-20xl/2" screws. 1/4-20xl/2" screws Qty.
Right Side Shelf [] Attach towel bar to right side shelf with (2) #10-24x3/8" screws, 5ram lock washers and 5mm flat washers (A). [] Hook side wall of shelf over support brackets on side of firebox (B). [] Insert (4) 7mm fiber washers and (4) 1/4-20xl/2" screws through inside front of firebox and through outside back of firebox as shown (C). [] Attach shelf with (4) 1/4-20 flange nuts (D). Support Bracket Rig;Side A Towel Bar / #10-24x3/8" Shelf screwSQty. 2 1/4-2o×1/2" 5mm Flat Washer Qty.
Side Burner Shelf [] Hook side wall of side burner shelf over support brackets on side of firebox (A). [] Inside firebox insert (4) fiber washers and (4) 1/4-20xl/2" screws as shown (B). [] Attach shelf using (4) 1/4-20 flange nuts (C). 1/4-20xl/2" screws Qty. 4 Lid removed for clarity Side Burner Shelf / 7mm Fiber Washers Qty. 4 1/4-20 Flange Nuts Qty. 4 Left Fascia [] Attach fascia to firebox with (3) #8-32x3/8" CAUTION: Fascia must be securely tightened sheet metal screws.
Sideburner Valve, $ideburner Sideburner Bezel, Ignitor Wire, Control Knob [] Position valve behind fascia and line up holes (A). [] Insert (1) of the #8-32x3/8" stainless steel screws, but do not fully tighten. [] Slip bezel under inserted screw and position as shown (A). [] Line up other hole and insert (1) #8-32x3/8" stainless steel screw through bezel and into valve. [] Tighten both securely. [] Place sideburner into shelf (B). Make sure to insert valve into sideburner tube.
[] Attach heat shield over burners inside front of grill with (2) #8-32x3/8" Heat Shield sheet metal screws. Heat Shield H #8-32x3/8" sheet metal screws Qty.
Heat Diffusers [] Place heat diffusers over burners by inserting tabs into slots in front of firebox. Opposite ends of heat diffusers rest on pins in back of firebox. Pin Cooking Grate and Swing Away [] Place cooking grates onto grate rests. [] Insert ends of Swing Away pivot wire into holes in sides of grill lid. Insert ends of Swing Away leg wire into holes in sides of firebox. NOTE: Pivot and leg wires, running side-to-side, should be under wires running front-to-back.
Grease Cup Cllp, Grease Cup, Grease Tray [] Hang grease cup clip from bottom the tray into the cart. of grease tray and place grease cup into grease cup clip. Place Tio. Failureto installgrease cup clip and cup will cause hot grease to drip From bottom of grill with risk of fire or propertydamage. Grease Tray Grease Cup Cti F Grease Cup_ LP Tank [] LP tank is sold separately. Use only with an OPD (over-fill protection device) equipped LP tank.
EMERGENCIES: Jf a gas leak cannot be stopped, or a fire occurs due to gas leakage, Gas leaking from • Damaged hose. • Turn off gas at LP cylinder cracked/cut/burned hose. If the hose is cracked grill valve!hose!regulator. until a plumber or gas technician replace the cause could Discontinue has investigated and the problem. • Mechanical Gas leaking from LP cylinder valve. • Failure of cylinder valve from mishandling or mechanical failure. • Turn off LP cylinder valve.
Troubleshootlng (continued) Burner(s) will not light using ignitor. (See Electronic Ignition Troubleshooting also) ELECTRONIC IGNMON: No spark, no ignition No spark, some ignition Sparks, noise. noise. but not at electrode or at full See Section I of Electronic Ignition See Section II of Electronic See Section III of Electronic Ignition System. System. Ignition System. strength. Burner(s) will match not See _GAS ISSUES:" on previous page. light.
Troubleshooting - Electronic Ignltion SECTION No sparks I appear any electrodes Electronic at when not installed • Check battery orientation. • Install battery properly. connectors Ignition and Button is pressed; no noise can be heard from • Battery • Dead battery. Has battery been used "-" (make sure that "+" are oriented correctly, and "-" with "÷'_ end up end down.) • Replace battery with new AA-size button cap assembly alkaline battery. previously? spark module.
o464220511
464220511 °27
Your Home iiiiiiiiiiiiiiiiiiiiii!ii_Y iiiiiiiiiiiiiiiiiiiiii _ iiiiiiiiiiiiiiiiiiiiii iiiiiiiiiiiiiiiiiiiiii iiiiiiiiiiiiiiiiiiiiii iiiiiiiiiiiiiiiiiiiiii iiiiiiiiiiiiiiiiiiiiii iiiiiiiiiiiiiiiiiiiiii iiiiiiiiiiiiiiiiiiiiii For troubleshooting, product manuals and expert advice: managemylife wv, rw.managemylife.
