Owner`s manual

ManualsBrandsCharmglow ManualsGrillStainless Steel Natural Gas Drop-In 4-Burner Grill

SIDE BURNER

Outdoor Gas Side Burner / Hornilla lateral a gas para uso al aire libre

WARNING/ADVERTENCIA

HAZARDOUS EXPLOSION MAY RESULT IF THESE WARNINGS AND INSTRUCTIONS

ARE IGNORED. READ AND FOLLOW ALL WARNINGS AND INSTRUCTIONS IN THIS

MANUAL TO AVOID PERSONAL INJURY, INCLUDING DEATH OR PROPERTY DAMAGE.

SE PUEDE PRODUCIR UNA EXPLOSIÓN PELIGROSA SI SE HACE CASO OMISO A

ESTAS ADVERTENCIAS E INSTRUCCIONES. LEA Y SIGA TODAS LAS ADVERTENCIAS

E INSTRUCCIONES EN ESTE MANUAL PARA EVITAR LESIONES PERSONALES,

INCLUSO LA MUERTE, O LOS DAÑOS MATERIALES.

SAVE THIS MANUAL FOR FUTURE REFERENCE

GUARDE ESTE MANUAL PARA REFERENCIA FUTURA

NOTICE TO INSTALLER:

LEAVE THESE INSTRUCTIONS

WITH THE SIDE BURNER OWNER

FOR FUTURE REFERENCE.

AVISO PARA EL

INSTALADOR:

ENTREGUE ESTAS

INSTRUCCIONES AL

PROPIETARIO DE LA HORNILLA

LATERAL PARA REFERENCIA

FUTURA.

OWNER’S MANUAL / MANUAL DEL PROPIETARIO

ASSEMBLY AND OPERATING INSTRUCTIONS/INSTRUCCIONES DE ARMADO Y OPERACIÓN

Stainless Steel Natural Gas

Drop-In Side Burner

Hornilla Lateral a Gas Natural

Empotrable de Acero Inoxidable

Summary of content (15 pages)

PAGE 1
Stainless Steel Natural Gas Drop-In Side Burner Hornilla Lateral a Gas Natural Empotrable de Acero Inoxidable Outdoor Gas Side Burner / Hornilla lateral a gas para uso al aire libre OWNER’S MANUAL / MANUAL DEL PROPIETARIO ASSEMBLY AND OPERATING INSTRUCTIONS/INSTRUCCIONES DE ARMADO Y OPERACIÓN SAVE THIS MANUAL FOR FUTURE REFERENCE GUARDE ESTE MANUAL PARA REFERENCIA FUTURA WARNING/ADVERTENCIA HAZARDOUS EXPLOSION MAY RESULT IF THESE WARNINGS AND INSTRUCTIONS ARE IGNORED.
PAGE 2
IMPORTANT SAFETY WARNINGS WE WANT YOU TO ASSEMBLE AND USE YOUR SIDE BURNER AS SAFELY AS POSSIBLE. THE PURPOSE OF THIS SAFETY ALERT SYMBOL IS TO ATTRACT YOUR ATTENTION TO POSSIBLE HAZARDS AS YOU ASSEMBLE AND USE YOUR SIDE BURNER. WHEN YOU SEE THE SAFETY ALERT SYMBOL PAY CLOSE ATTENTION TO THE INFORMATION WHICH FOLLOWS! READ ALL SAFETY WARNINGS AND INSTRUCTIONS CAREFULLY BEFORE ASSEMBLING AND OPERATING YOUR SIDE BURNER. DANGER IF YOU SMELL GAS: 1. Shut off gas to the appliance. 2. Extinguish any open flame.
PAGE 3
TABLE OF CONTENTS General Warnings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 Connecting Instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 Leak Testing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4–5 Pre-start Check List . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
PAGE 4
GENERAL WARNINGS WARNING • Never use liquid propane gas (LP) in a unit designed for natural gas. • Never use charcoal briquets or lighter fluid in a gas side burner. • Leak test all connections before first use, even if side burner was purchased fully assembled and after each time the hose is connected to natural gas supply. • Never check for leaks using a match or open flame. CAUTION! Strong odors, colds, sinus congestion, etc. may prevent the detection of natural gas.
PAGE 5
WARNING • FOR OUTDOOR USE ONLY. DO NOT operate indoors or in an enclosed area such as a garage, shed or breezeway. • Use your side burner OUTDOORS in a well ventilated space away from dwellings or other buildings to prevent dangers associated with gas accumulation and toxic vapors. We recommend your grill be situated at least 10 feet (3.1 m) from buildings. • Maintain a minimum clearance of 36 inches (91 cm) between all sides of side burner and walls or other combustible material.
PAGE 6
WARNING WHEN TO PERFORM A LEAK TEST: • After assembling your side burner and before lighting for the first time, even if purchased fully assembled. • Every time the gas hose is connected to the natural gas supply or if any of the gas components are replaced. • Any time your side burner has been moved. • At least once per year or if your side burner has not been used for more than 60 days. Watch For Bubbles CHECKING FOR LEAKS: 1. 2. 3. 4. 5.
PAGE 7
WARNING PRE-START CHECK LIST: Property damage, bodily harm, severe burns, and death could result from failure to follow these safety steps. These steps should be performed after the side burner has been assembled, stored, moved, cleaned, or repaired. DO NOT operate this side burner until you have read and understand ALL of the warnings and instructions in this manual. PRE-START CHECK LIST: • Ensure that the side burner is properly assembled.
PAGE 8
MATCH LIGHTING THE SIDE BURNER: 1. Open the lid to the side burner before lighting. 2. Make sure control knob is in the "OFF" position. Match 3. Strike and carefully place a match approximately 1/2" (1 to 2 cm) from the side burner. 4. Turn the side burner control knob to the "HIGH" position. The burner should light within 5 seconds. 5. If the burner does not light, turn the control knob to "OFF" and wait 5 minutes for gas to dissipate and repeat lighting procedure. 6.
PAGE 9
COOKING TIPS (CONTINUED) GRILLING TO PROPER TEMPERATURE • Use a meat thermometer to be sure food has reached a safe internal temperature. You may order a Commercial-quality thermometer from Brinkmann. For more information on this product and other Brinkmann accessories, please refer to the accessory pages at the end of this manual. • US Department of Agriculture recommends the minimum temperature be reached for the following food items: Chops . . . . . . . . . . . . . . . . . . . . .145° F (62.
PAGE 10
BURNER ASSEMBLY/MAINTENANCE (CONTINUED) • Although your burner is constructed of brass and cast iron, it may corrode as a result of the extreme heat and acids from cooking foods. Regularly inspect the burner for cracks, abnormal holes, and other signs of corrosion damage. If found, replace the burner. • DO NOT obstruct the flow of combustion and ventilation air. Burner tubes can become blocked by spiders and other insects building their nests.
PAGE 11
WARNING TRANSPORTING AND STORAGE: • Never move a grill when it is hot or when objects are on the cooking surfaces. • Make sure that the natural gas supply is shut off. After moving the grill check that all gas connections are free of leaks. Refer to instructions for Leak Testing. • DO NOT store a spare LP gas cylinder (filled or empty) under or near the grill. • Never store flammable liquids or spray canisters under or near the grill. • DO NOT extinguish grease fires using water.
PAGE 12
FREQUENTLY ASKED QUESTIONS Your grill's serial number and model number, and the contact information for Brinkmann Customer Service, are listed on a silver label found on the back of the grill or on the grill body side, under the side shelf. These questions and answers are for your general knowledge, and may not be applicable to your model grill. Question: Why does my grill not light properly? Answer: Always follow lighting instructions as listed on the control panel or in this manual.
PAGE 13
ASSEMBLY INSTRUCTIONS READ ALL SAFETY WARNINGS & ASSEMBLY INSTRUCTIONS CAREFULLY BEFORE ASSEMBLING OR OPERATING YOUR GRILL. No tools are required to assemble this Natural Gas Drop-In Side Burner: 1 PARTS LIST: 1 1 Cooking Grate 2 1 Side Burner Assembly 3 1 Battery 4 1 Grease Tray FOR MISSING PARTS, PLEASE CALL CUSTOMER SERVICE AT 800-527-0717. (Proof of purchase will be required.) Inspect contents of the box to ensure all parts are included and undamaged.
PAGE 14
WARNING: Do not install this unit into combustible enclosures. Maintain a minimum clearance of 36 inches (91 cm) between all sides of grill and walls or other combustible material. DO NOT use grill under overhead unprotected combustible construction. 12 ” 2 18 12 w ” ” 6” 12 ” 92 ” 36” - 38” Drop-in cutout dimensions for the Stainless Steel Natural Gas Drop-In Side Burner: 5” Length: 18 1/2” (47 cm) Width: 12 3/4” (32.4 cm) 1” 1 Height: 9 /2” (24.
PAGE 15
Hose Connection After dropping in the side burner, run the side burner hose fitting through the side hole and pull hose through as far as possible. Then connect it to the quick-disconnect coupler. Quick-Disconnect Coupler Side Hole Push sleeve back to attach Side Burner Hose Fitting Quick-Disconnect Coupler Sleeve Side Burner Hose Fitting Battery Installation SIDE BURNER Remove burner igniter cap and insert battery with positive end of battery toward igniter cap.