Installation Guide

Classy Caps Mfg. Inc.
Kingsville, Ontario, Canada
[e-mail] / www.fencecaps.com
Lighting Instructions
Mod. SL094
SL092
How Your Solar Powered Post Cap Works
- The solar panel converts sunlight energy into electricity during the day. The photocell
automatically turns the light on at night with the electricity stored in the batteries. It requires no wiring,
because it runs off the sunlight energy to recharge the batteries so there is no cost to run the solar cap.
- The number of hours the light stays on depends on your geographical location, weather conditions and seasonal
sunlight availability.
- Easy “Do-It Yourself” installation.
Each Classy Cap Includes:
- 1- Candle Solar Post Cap
- 2- Mounting Screws
- 2- AA NiCad Rechargeable Batteries
- 1- Adapter
Post Cap Installation
1) Twist the solar lid counter clockwise to remove from cap base as shown (fig.1).
2) Turn the on / off switch to on and twist the lid back into place.
3) Remove the adapter if necessary to fit post as shown (fig.1).
4) Secure solar fixture to post using two mounting screws provided (pre-drill pilot holes into post to easily
fasten screws). An outdoor silicone may be applied to the bottom inside edge of cap before installation
for added security.
5) Remove the thin clear plastic film from solar panel.
6) Allow at least 8 hours of sunlight to fully charge the batteries.
Please note: our copper solar post caps are hand finished to give a natural
weathered appearance, every post cap has its own unique characteristics.
Color variance is normal.
To Replace The Batteries (battery replacement is about 1-2 years)
1) Twist the solar lid counter clockwise to remove from cap base as shown (fig.1).
2) Replace the batteries with new AA size 1.2 V NiCad rechargeable batteries.
Be sure to insert batteries in the proper direction.
3) Twist the lid back into place.
4) Allow the fixture to receive a full 8 hours of sunlight to allow the
rechargeable batteries to reach maximum capacity.
Troubleshooting
If the light does not turn on at dusk after 8 hours of charging:
- Check the batteries to make sure they are making secure contact with the terminal.
- Be sure the solar fixture is in a relatively sunny location.
- Make sure the light’s photocell is not affected by other light.
Caution
- Failure to insert batteries in the correct polarity, as indicated in the battery compartment, may
shorten the life of the batteries or cause them to explode or leak.
- Do not mix old and new batteries.
- Do not mix alkaline, standard (carbon- zinc) or rechargeable (nickel cadmium) or
(nickel metal hydride) batteries.
- Do not dispose of batteries in fire.
Maintenance
Periodically clean light fixture with soft cloth and warm soapy water.
Two Year Limited Warranty
Classy Caps Mfg. Inc. products are warranted to be free from defects in workmanship or materials at the time of purchase
for a period of two years, (excluding batteries). Should a defect occur, please contact our customer service line at
1-866-460-4604 for service. Should any evidence of defects in material or workmanship appear within the warranty
period after the date of purchase, Classy Caps Mfg. Inc. will either repair or replace the product at its option.
Classy Caps Mfg. Inc. is not responsible for injury, property damage, or other consequential damages or damages to
third parties arising directly or indirectly from an actual or alleged defect in material or workmanship of the product.
Removable Lid
Cap Base
Adapter
Fig. 1