Operator`s manual
18
MAINTENANCE
Service Dates
Check for loose fasteners X
Check soft vinyl boot X
Check tire pressure X
Check engine oil level X
Lubricate X
Clean X X
Maintain engine per instructions below and in engine manual.
Before each use
After each use
Every season
Before storage
CUSTOMER RESPONSIBILITIES
• Readandfollowthemaintenancescheduleandthemaintenanceprocedureslistedinthissection.
MAINTENANCE SCHEDULE
Fill in dates as you
complete regular service.
BEFORE EACH USE
CHECKFORLOOSEFASTENERS
• Make a thorough visual check of the Chip-N- Vac
for any bolts and nuts which may have loosened.
Retighten any loose bolts and nuts.
CHECKVINYLBOOT
• Checkthesoftvinylboot(onfrontofhardtop)for
wear. Replace if worn or damaged.
CHECKTIREPRESSURE
• Checktirepressureregularly.Recommendedtire
pressure is 12-14 Lbs.
CHECKENGINEOILLEVEL
• Checkoillevelbeforeeachuse.Maintainengineoilas
instructed in the separate engine manual.
LUBRICATION
• At the beginning of each season, lubricate the latch,
latch pivot bolt, and the axle where the hitch tongue
pivots, with a light machine oil.
• Atleastonceaseason,greaseoroilthewheel
bearings. Use automotive wheel bearing type grease
or 20 weight oil.
WARNING: Always stop engine and
disconnect spark plug wire before cleaning,
lubricating or before performing any repairs
or maintenance.
ENGINE MAINTENANCE
• Checkoil level before each use. Maintain engine oil
as instructed in the separate engine manual.
• Serviceair cleaner every 25 hours under normal
conditions. Clean every few hours under extremely
dusty conditions. Poor engine performance and
oodingusuallyindicatesthattheaircleanershould
be serviced. To service the air cleaner, refer to the
separate engine manual.
• Thespark plug should be cleaned and the gap
reset once a season. Spark plug replacement is
recommended at the start of each season. Check
the engine manual for correct plug type and gap
specications.
CLEANING
• Makesurethecart,thesideandfrontpanelsand
top are cleaned after each use. Grass clippings and
leaves left in the cart will mildew and cause damage if
not cleaned out.
• Clean the engine regularly with a cloth or brush.
Keepthecoolingnsontheenginehousingclean
to permit proper air circulation which is essential to
engine performance and life. Be sure to remove all dirt
anddebrisfrommuferarea.