cacor a rr renee Installation Instructions Epicure’ Cooktop Models: EG366, EG486 THIS APPLIANCE HAS BEEN TESTED IN ACCORDANCE WITH THE LATEST EDITION OF ANSI 221.1 STANDARD FOR HOUSEHOLD GAS APPLIANCES. Part No. 102025 Rev.
Table of Contents Important Safety INStruCtiONS .........cccceeeeeseseseseeereerereeees Important Information About Safety Instructions.............. General Safety Precautions ...............cccccccccccceeeeeeeeeeenenenes Installation Requirements ..........ccccccecececeeeeeeeeeeeseseneeeeeeeees Electrical Requirements 0.0.0... cccccccccesessssssssesseeeeeeeeees Gas Supply Requirements ...............ccccceceeecceeeeeeeeeeeeenenenes Product DIMENSIONS ..........
Important Safety Instructions Important Information About DANGER Safety Instructions IMPORTANT: * « The Important Safety Instructions and warnings in this manual are not meant to cover all possible problems and conditions that can occur. Use common sense and caution when installing, maintaining or operating this or any other appliance. * Always contact the Dacor Customer Service Team about problems and conditions that you don’t understand. See Customer Service Information. Do not use or.
Important Safety Instructions General Safety Precautions To reduce the risk of fire, electric shock, serious injury or death when using your appliance, follow basic safety precautions, including the following: WARNING Read the accompanying use and care manual completely before operating this appliance. Keep packaging materials away from.children. Plastic: sheets and bags can cause suffocation. If you receive a damaged product, immediately .contact your dealer or builder.
Installation Requirements Gas Supply Requirements WARNING *. Observe all governing codes and ordinances during planning and installation. Contact your-local building department for further information. *« Check your local building codes for the proper method of installation. In the absence of local codes, this appliance should be installed in accordance with the National Fuel Gas Code ANSI Z223.1/NFPA 54.
Installation Requirements Cabinet and Countertop Layout * The installation must allow access to the underside of the cooktop for service and inspection purposes, including the ability to turn off the cooktop gas supply valve and electrical outlet. « All contact surfaces between the cooktop and the counter must be solid and level.
Installation Requirements Cabinet/C utout Dimensions Cabinet tolerances +1/16” -0 (+1.6 mm, 0) unless otherwise noted. 4 1/2” (38 mm) 10” (254 mm) to combustible side typical countertop thickness wall Min. both sides > 1/2” (13 mm) overhang, both sides rC e He— 7 3/4” (197 mm) @;e Cooktop platform 1” (25 mm) Min.
Installation Requirements Cabinet/Countertop Dimensions (cont.} Cutout tolerances +1/16” -0 (+1.6 mm, 0) unless otherwise noted. Gas and electrical connections at right rear section of chassis AY iT =\ Gas connection and power cord may be routed through bottom or back of chassis Increase countertop and overhang additional 2 1/2” (64 mm) Min.
Installation Requirements Non combustible rear 2 5/8” 3/8” (10 mm) Min. (67 mm) countertop overhang wall recommended 10” (254 mm) Min. to | t | | } t E 7 combustible bustib! wa Il above countertop, both sides | $< | Open to below to allow for raised vent, gas and electrical connections > 1/2” (13 mm)—| | ¢ i 15” 417/16" 294 SS ( mm) +f 2 £ 2 3 8 1” thick mounting platform Min. e l 7 —+| 1/2” | | | overhang 9 Hole 1/2” dia.
Installation Instructions Unpack the Cooktop Cooktop Installation WARNING » *..--To prevent damage. to the gas pressure regulator, install it only-after the cooktop is mounted in its permanent position. «The cooktop is. heavy. A minimum of two people are required to ‘safely install it. «..Do-not-over-tighten the hold down bolts. Over tightening the hold down bolts ‘may. result in improper operation of the dual gas burners.
Installation Instructions Gas Line Connection WARNING «Verify that the gas supply meets specifications before connection. See page 3. «. . The maximum «~ Do-not-install or use the cooktop without: the included gas regulator installed: «Ensure gas supply pressure to the regulator must never.exceed ’4 pounds per square inch (psi) or 3.5 kPa. thatthe arrow on the regulator points in the direction of the gas flow, towards the cooktop. «...Do-not-apply excessive pressure.
Installation Instructions Burner Component Installation WARNING «Never attempt to operate the cooktop with any of the burner. parts removed. »- Do not attempt to adjust-the burner air.mixture settings. All adjustments are preset-at-the factory. * Remove the burner parts and grates from their shipping packages. * — Install the burners as shown. When installing the burn- er components, twist each piece back and forth slightly Crown Spill tray until it drops completely into place.
Installation Instructions Burner Knob Installation CAUTION Installing the cooktop knobs in the wrong position may result in damage.to the.cooktop griddle. The knobs for the center burners.are.-marked with the: maximum griddle settings. There are two (2) different types of knobs supplied with the cooktop. The knobs for the center burners have the words MAX GRIDDLE on them. * Put the knobs with the words MAX GRIDDLE onto the inner (center burner) valve shafts.
Installation Instructions Verifying Proper Operation NOTE: If the cooktop does not operate properly, follow these troubleshooting steps: WARNING «Make sure that power-to the electrical outletis turned off atthe circuit breaker or.fuse box and that the gas is turned off at the gas supply valve before. proceeding. * The cooktop must be properly grounded at-all times when electrical power is applied. Prior to operating the cooktop, read the accompanying and care manual carefully. use 1.
Installation Instructions Installation Checklist WARNING * To ensure-a safe and proper installation, the following checklist should be.completed by the installer to ensure that no.part of the installation has been overlooked. *- Proper installation is. the responsibility-of the homeowner. The importance.of proper installation of your Dacor-cooktop cannot-be overemphasized.
= (e) — oy) le) a) ey oo 120V, 60Hz, 0.25A POWER SUPPLY VERIFY PROPER OPERATION AFTER SERVICING & RL LED HARNESS B IGNITOR, RL BURNER Single Point Spark Module IGNITOR, FL BURNER w—Kt—Kt FL LED HARNESS 0}. B 0 Single Point Spark Module 0 B 0 WIRING DIAGRAM EG366/EG486 ALL WIRES PRIOR TO DISCONNECTION CAUTION: LABEL WHEN SERVICING CONTROLS. WIRING ERRORS CAN RR LED HARNESS CAUSE IMPROPER AND DANGEROUS OPERATION.
dacor 15
16 cdacor.
cdacor The Life of the Kitchen® Dacor e 600 Anton Bivd. Suite 1000 Costa Mesa, CA 92626 « Phone: (800) 793-0093 American Made* Family Owned e Fax: (626) 403-3130 « www.Dacor.