STACKABLE LCC/LCD OVEN OWNER’S MANUAL C-244 P/N 320207 VERSION 1.
Stackable LCC/LCD Oven Owner’s Manual Version 1.1 PREFACE 2 Revision History Revision 1 Date 3/2012 Author K. Livingston 1.1 8/2012 K. Livingston Description Revise for Protocol 3. Revised images for LCC-4. Miscellaneous revisions and additions including LCC/LCD1-52V & 1-51NV Oven Door update and HEPA filter installation update. Copyright © 2012 by Despatch Industries. All rights reserved.
Stackable LCC/LCD Oven Owner’s Manual Version 1.1 Table of Contents 1. 2. 3. 4. 5. About This Manual .............................................................................................................. 6 1.1. Important User Information ...................................................................................... 6 1.2. Manufacturer & Service ........................................................................................... 7 1.3. Organization of this Manual ................
Stackable LCC/LCD Oven Owner’s Manual Version 1.1 PREFACE 4 6. 7. 8. 5.1. Load Oven ............................................................................................................. 36 5.2. Pre-Startup Checklist ............................................................................................. 36 5.3. Operating Procedure ............................................................................................. 37 5.3.1. Start Oven ...............................................
Stackable LCC/LCD Oven Owner’s Manual Version 1.1 Figure 30. LCC1-51-4 (Drawing 313932-02). ................................................................................ 47 Figure 31. LCC1-51-4 (Drawing 313932-03). ................................................................................ 47 Figure 32. LCC1-51N-4 (Drawing 313933-01). ............................................................................. 47 Figure 33. LCC1-51N-4, Drawing 313933-02). ..........................................
Stackable LCC/LCD Oven Owner’s Manual Version 1.1 ABOUT THIS MANUAL 6 1. About This Manual 1.1. Important User Information Copyright © 2012 by Despatch Industries. All rights reserved.
Stackable LCC/LCD Oven Owner’s Manual Version 1.1 ABOUT THIS MANUAL 7 The information in this document is not intended to cover all possible conditions and situations that might occur. The end user must exercise caution and common sense when installing or maintaining Despatch Industries products. If any questions or problems arise, call Despatch Industries at 1-888-DESPATCH or 1-952-469-5424. 1.2. Manufacturer & Service The Stackable LCC/LCD Oven is manufactured by Despatch Industries.
Stackable LCC/LCD Oven Owner’s Manual Version 1.1 ABOUT THIS MANUAL 8 1.4. Conventions This icon signifies important information. This icon signifies information that describes an unsafe condition that may result in death, serious injury, or damage to the equipment. A condition that may result in death, serious injury, or damage to equipment. A condition that may result in serious injury or damage to equipment. A condition that may result in damage to equipment or product.
Stackable LCC/LCD Oven Owner’s Manual Version 1.1 ABOUT THIS MANUAL 9 1.5.2. Dimensions Models Chamber Size inches (cm) W D H LCC1-16-4 LCD1-16-4 LCC1-16N-4 LCD1-16N-4 LCC1-51-4 LCD1-51-4 LCC1-51N-4 LCD1-51N-4 Capacity 3 ft (liters) Overall Size inches (cm) W D H Maximum number of Shelves 15 (38) 14 (36) 14 (36) 1.6 (45) 32.5 (83) 35.5 (90) 20.75 (53) 5 23 (58) 20 (51) 20 (51) 5.1 (144) 40.5 (103) 42.5 (108) 27 (69) 8 *LLC & LLD models have same dimensions.
Stackable LCC/LCD Oven Owner’s Manual Version 1.1 ABOUT THIS MANUAL 10 If the line voltage is higher than the nameplate rating, motors may run hot and draw excessive amperage Model LCC1-16-4 LCD1-16-4 LCC1-16N-4 LCD1-16N-4 LCC1-51-4 LCD1-51-4 LCC1-51N-4 LCD1-51N-4 Volts * Amps Hertz Heater Phase KW Cord and Plug 240 14.8 50/60 1 3 None, hardwired 240 14.0 50/60 1 3 None, hardwired 240 27.7 50/60 1 6 None, hardwired 240 27.
Stackable LCC/LCD Oven Owner’s Manual Version 1.1 ABOUT THIS MANUAL 11 1.5.5. Temperature LCC1-16-4 LCD1-16-4 LCC1-16N-4 LCD1-16N-4 LCC1-51-4 LCD1-51-4 LCC1-51N-4 LCD1-51N-4 7 min. 7 min. 5 min. 5 min. 30 min. 30 min. 27 min. 27 min. 45 min. 45 min. 35 min. 35 min. 60 min. 60 min. 50 min. 50 min. 35 min. 30 min. 40 min. 25§ min. 65 min. 55§ min. 75 min. 40§ min. 75 min. 60§ min. 85 min. 45§ min. 130 min. 80§ min. 115 min. 50§ min.
Stackable LCC/LCD Oven Owner’s Manual Version 1.1 SAFETY 12 2. Safety 2.1. Safety Information Do not work on the Stackable LCC/LCD Oven without reading and understanding this section which contains important information and warnings. Ignoring these warnings can result in death, serious injury or damage to the machine and product. 2.1.1. Lockout Machine lockout places the Stackable LCC/LCD Oven into a zero energy state and prevents accidental machine start up.
Stackable LCC/LCD Oven Owner’s Manual Version 1.1 2.1.2. Door and Panel Danger! Electrical panels contain high voltage. Disconnect and lock out the power supply before working inside any electrical panels. Failure to lock out the power supply can result in death or injury. The door and rear panel on the Stackable LCC/LCD Oven protect against hazards. Power is required to open the door and the oven heater is OFF when the door is open.
Stackable LCC/LCD Oven Owner’s Manual Version 1.1 SAFETY 14 Danger! Always disconnect all power before extinguishing a fire. Attempting to extinguish a fire in a machine connected to electrical power can result in serious injury or death! 2.5. Equipment Lockout Requirements To prevent injury or equipment damage during inspection or repair, the Stackable LCC/LCD Oven must be locked out. 2.5.1.
Stackable LCC/LCD Oven Owner’s Manual Version 1.1 3. THEORY OF OPERATION 15 Theory of Operation 3.1. The Stackable LCC/LCD Series Oven The Stackable LCC/LCD Series Oven (Figure 1) offers HEPA (High Efficiency Particulate Air) filtration for processes where minimized contamination is essential. The removable HEPA filter is designed to provide a constant flow of 99.97% clean air to the product being heated. The HEPA filter with silicone seal provides 99.99% filtration.
Stackable LCC/LCD Oven Owner’s Manual Version 1.1 THEORY OF OPERATION 16 ductwork may be easily removed for cleaning. Heater frame, fan wheel and motor shaft are constructed of stainless steel. Two electropolished stainless steel wire shelves are provided. The shelves are removable and adjustable on two inch centers. The LCC/LCD series design offers a stackable oven body. Multiple oven systems of two or three oven stack options are available.
Stackable LCC/LCD Oven Owner’s Manual Version 1.1 THEORY OF OPERATION 17 3.3. HEPA Filters The Stackable LCC/LCD Ovens use HEPA (High Efficiency Particulate Air) filters limit particulate size in the work chamber to 0.3 microns or less. Two different types of filters are typically used.
Stackable LCC/LCD Oven Owner’s Manual Version 1.1 THEORY OF OPERATION 18 Ship, handle, store and install HEPA filters with pleats positioned vertically. Horizontally-positioned pleats risk breaking at the adhesive line of the filter medium. Horizontally-positioned pleats also collect entrapped material on “shelves.” The accumulated weight of the entrapped material may cause sag and lead to early failure of the filter unit.
Stackable LCC/LCD Oven Owner’s Manual Version 1.1 THEORY OF OPERATION 19 Class 100 testing may be performed before or after a proper filter burn-in procedure has been performed. Despatch guarantees Class 100 condition measurements based on two methods of test. The direct method employs an extraction-type particulate analyzer. The indirect method involves particle settling over a specified period of time onto a clean disk. 3.3.2.3.
Stackable LCC/LCD Oven Owner’s Manual Version 1.1 THEORY OF OPERATION 20 recommends changing the filter when the pressure is 1” w.c. greater than when the filter was first installed (Refer to section 4.3 for filter replacement). Since pressure can be affected by many factors involved in the installation, it is important to record the pressure of a new filter as a baseline. Recorded pressure readings allow for new readings to be periodically checked against this baseline.
Stackable LCC/LCD Oven Owner’s Manual Version 1.1 4. ASSEMBLY & SETUP 21 Assembly & Setup Assembly and Setup provides directions for unpacking and installing your LCC/LCD. 4.1. Unpack & Inspect The LCC/LCD Oven Remove all packing materials and thoroughly inspect the oven for any damage that might have occurred during shipment.
Stackable LCC/LCD Oven Owner’s Manual Version 1.1 ASSEMBLY & SETUP 22 4.1.1. If Damaged During Shipping If damage occurred during shipping: 1. Contact the shipper immediately and file a written damage claim. 2. Contact Despatch Industries (1-800-473-7373 or 1-952-469-8230 or service@despatch.com) to report your findings and to order replacement parts for those damaged or missing.
Stackable LCC/LCD Oven Owner’s Manual Version 1.1 ASSEMBLY & SETUP 23 For the LCC1-51 oven model, only two ovens may be stacked vertically. Supporting surface must be capable of holding three ovens (750 Lbs or 340.2 Kg) or the weight of two LCC1-51 oven models. Use the holes in the rear oven feet to bolt the ovens together by removing the hole plugs in the top of the mating oven beneath. 4.2.2. Oven Utility Connections Utility connections vary slightly on different LCC/LCD models.
Stackable LCC/LCD Oven Owner’s Manual Version 1.1 ASSEMBLY & SETUP 24 Nitrogen pressure supplied should be greater the 70 psi (4.83 bar) but not more than 80 psi (5.52 bar). 2. Install water connection for cooling coils to WATER INLET (Figure 6). Verify the valve on the flowmeter is turned OFF, that is, fully clockwise. Nitrogen inlet Flow-meter valve Water drain Water inlet Water outlet Figure 6. LCC/LCD Connections Panel. Water pressure supplied to the oven must not exceed 100 psi (6.89 bar).
Stackable LCC/LCD Oven Owner’s Manual Version 1.1 ASSEMBLY & SETUP 25 4. Adjust the flowmeter to the recommended 3 gpm (11.4 lpm). 5. Complete the drain connection on oven side by connecting WATER OUTLET to the closed loop system (Figure 6). WATER DRAIN must be left open-to-atmosphere. Make closedloop connections using WATER OUTLET (Figure 6). Warning! Never allow WATER DRAIN to be plugged. A hot oven generates a small amount of steam when the water is first turned on. Steam can burn skin.
Stackable LCC/LCD Oven Owner’s Manual Version 1.1 ASSEMBLY & SETUP 26 Caution! Failure to allow air to bleed from the flowmeter may damage the flowmeter. Bleed air from the flowmeter after every instance of shutting off the water supply. 4. Adjust the flowmeter to the recommended 3 gpm (11.4 lpm). 5. Complete the drain connection on oven side by connecting WATER OUTLET to the closed loop system (Figure 6). WATER DRAIN must be left open-to-atmosphere.
Stackable LCC/LCD Oven Owner’s Manual Version 1.1 ASSEMBLY & SETUP 27 Figure 7. Exhaust Port on the Left Side of the LCC/LCD Oven. Table 4. Exhaust Connection Requirements. LCC/LCD1-16 Models LCC/LCD1-51Models Size 1.88” x 2.88” (4.8 cm x 7.3 cm) Flow 35 cfm (991.5 lpm) 73 CFM (2067 lpm) Temperature LCC and LLC series: LCC and LLC series: 500 °F (260°C) 500 °F (260°C) LCD and LLD series: LCD and LLD series: 662 °F (350°C) 662 °F (350°C) 4.2.4.
Stackable LCC/LCD Oven Owner’s Manual Version 1.1 ASSEMBLY & SETUP 28 Figure 8. Open the front panel for access. Connect the line voltage power to the disconnect switch labeled LINE CONNECTION (Figure 9). Conduit on rear of oven Connect line voltage power to Disconnect Switch labeled LINE CONNECTION. Line voltage power emerges from conduit on front of oven here. Route line voltage power through conduit Figure 9. Conduit entrance at rear of oven and open front panel.
Stackable LCC/LCD Oven Owner’s Manual Version 1.1 ASSEMBLY & SETUP 29 4.3. HEPA Filter Installation Not all LCC/LCD ovens come equipped with a HEPA filter. This HEPA filter installation section applies only to ovens designed for ISO Class 5 (Class 100) use, which are equipped with a HEPA filter. For a complete explanation of model numbers, refer to Section 1.5.1. Two different types of filters are typically used.
Stackable LCC/LCD Oven Owner’s Manual Version 1.1 ASSEMBLY & SETUP 30 Sweep floor clear of nuts, bolts and other protrusions which may damage the unit. Do not drop or jar the filter carton. 1. Remove new filter from carton Notice Do not attempt to repair a damaged filter unit—particularly the medium. Any unit so repaired must be retested to assure that hidden damage does not exist which might reduce filtering efficiency. Repair and retest is not economical for most users. a. b. c. d.
Stackable LCC/LCD Oven Owner’s Manual Version 1.1 3. ASSEMBLY & SETUP 31 Opened pleats in the filter media are normal and result from the tempering process. Pull shelves from the oven and set aside (Figure 11). Danger! Make certain power is disconnected from the oven before removing or replacing the HEPA filter. 4. Loosen the three screws at the upper and lower corners of the right rear of the chamber (Figure 11). a. Pull out the shelf support/duct as a single unit and set it aside. 5.
Stackable LCC/LCD Oven Owner’s Manual Version 1.1 ASSEMBLY & SETUP 32 6. 7. LCC1-16 only: remove the filter frame, which will be reinstalled after filter installation. For all LCC/LCD Ovens: Install HEPA filter: a. For the High-temperature HEPA filter: i. Place the filter with the triangular gasket set against the oven wall and the glass braid set against the clamping plate (Figure 12). ii. Tighten the nuts until the triangular gasket is compressed to a thickness of 0.16 inch (0.4 cm). b.
Stackable LCC/LCD Oven Owner’s Manual Version 1.1 ASSEMBLY & SETUP 33 4.3.1. HEPA Filter Burn-Off 4.3.1.1. HEPA Filter Burn-Off Process The burn-off process takes place in any equipment where a new HEPA filter is used at temperatures above 180°C / 356°F. Expect smoke, possibly a pungent odor and a light residue on interior surfaces. This results from oxidation of the binder. Most of the binder will leave the filter after running at a temperature of 260°C/500°F for 48 hours.
Stackable LCC/LCD Oven Owner’s Manual Version 1.1 ASSEMBLY & SETUP 34 24 48hours hours Option 1 Temperature Ramp 1.7°C/min up to 5°C/Min 48hours hours 24 Process Temperature Option 2 Temperature Ramp 1.7°C/ min Figure 14. Options for starting high-temperature HEPA Filters 3. Start the fan after making the electrical power connections. 4. Energize the equipment heater. a. Use enough fresh air (or N2) to remove the smoke, while still being able to achieve and maintain the necessary temperature. b.
Stackable LCC/LCD Oven Owner’s Manual Version 1.1 ASSEMBLY & SETUP 35 4.4. MRC5000 Setup (Optional) Refer to instructions provided recorder manufacturer for more specific installation notes. Temperature is retransmitted to the MRC5000 recorder from the controller. Set up the recorder by: 1. Ensure hardware jumper JU1 is in place for the 5 VDC setting (Refer to MRC5000 Manual included). 2. Move Mode to PROG/TEST/CAL to display Prog. 3. Press ▼ twice to display Inps.
OPERATION 36 5. Stackable LCC/LCD Oven Owner’s Manual Version 1.1 Operation Users and operators of this oven must comply with operating procedures and training of operating personnel as required by the Occupational Safety and Health Act (OSHA) of 1970, Section 5 and relevant safety standards, and other safety rules and regulations of state and local governments. Refer to the relevant safety standards in OSHA and National Fire Protection Association (NFPA), Section 86 of 1990. 5.1.
Stackable LCC/LCD Oven Owner’s Manual Version 1.1 • • OPERATION 37 Check line voltage. Voltage must correspond to nameplate requirements of motors and controls. A wrong voltage can result in serious damage. Refer to Section 1.5.4 for more information. Check fresh air and exhaust openings. Do not be careless about restrictions in and around the fresh air and exhaust openings and stacks. Under no condition can they be permitted to become so filled with dirt that they reduce airflow.
OPERATION 38 Stackable LCC/LCD Oven Owner’s Manual Version 1.1 5.3.2. Working with Protocol 3 Operating Modes Refer to the Protocol 3 Controller Owner’s Manual for specific information for working with the controller. 5.3.3. Operation Sequence when Equipped with Optional Beacon Light 1. After starting the oven (refer to Section 5.3.1), the Protocol 3 controller initializes. a. The oven should be idle, empty, with the door closed and awaiting the next lot for processing. b.
Stackable LCC/LCD Oven Owner’s Manual Version 1.1 OPERATION 39 5.3.4. Sequence of Operation for Ovens Equipped for Inert Atmosphere Oven 1. After starting the oven (Section 5.3.1), the Protocol 3 controller initializes. Refer to the Protocol 3™ Controller Owner’s Manual for more information on programming event outputs. a. The oven should be idle, empty, with the door closed and awaiting the next lot for processing. b. The Protocol 3 Controller should not be running a profile. c.
OPERATION 40 Stackable LCC/LCD Oven Owner’s Manual Version 1.1 Figure 17. Adjust Nitrogen Maintain Needle Valve. 8. The third and final segment is the COOLDOWN MODE. In Cooldown mode, water valves are energized to bring the chamber to a safe unloading temperature (Figure 18). Figure 18. Water and Nitrogen Piping Schematic. Copyright © 2012 by Despatch Industries. All rights reserved.
Stackable LCC/LCD Oven Owner’s Manual Version 1.1 OPERATION 41 5.3.5. Manual Unlock and Main Disconnect 5.3.5.1. Manual Unlock If a power failure occurs insert a torx tip tool (provided) and rotate 90 degrees counterclockwise to allow the chamber door to open. The tool must be turned back to the locked position to allow electrical operation again. 5.3.5.2.
OPERATION 42 Stackable LCC/LCD Oven Owner’s Manual Version 1.1 2. Lift handle while holding DOOR RELEASE (Figure 20). Figure 20. Pull handle out away from door. 3. Open door and release DOOR RELEASE (Figure 21). Figure 21. Oven door latch and door fully open (latch perpendicular to oven door). 5.4.2. To Close the LCC/LCD1-52V & 1-51NV Oven Door 1. The door latch should be perpendicular to the oven door while in the open position (Figure 21). 2.
Stackable LCC/LCD Oven Owner’s Manual Version 1.1 6. MAINTENANCE 43 Maintenance Do not attempt any service on this oven before opening the main power disconnect switch. 6.1. Checklist Keep equipment clean. Gradual dirt accumulation retards airflow. A dirty oven can result in unsatisfactory operation such as unbalanced temperature in the work chamber, reduced heating capacity, reduced production, overheated components, and the like.
TROUBLESHOOTING 44 7. Stackable LCC/LCD Oven Owner’s Manual Version 1.1 Troubleshooting: Error Messages and Alarm Table 7 lists the more common error messages, the possible problems and remedies. Table 7. Error Messages and Next Steps. Alarm Status Possible Problem Hi-Limit LED flashing Problem with thermocouple Hi-limit setpoint has been exceeded.
Stackable LCC/LCD Oven Owner’s Manual Version 1.1 8. APPENDICES 45 Appendices 8.1. HEPA Filter Pressure Reading Worksheet A Date B Comments C Pressure (inches of 10 water) Typical Values Filter first installed 2-3” D Pressure with: 150 SCFH (LCC116); 200 SCFH (LCC1-51) nitrogen 11 purge 1.5-2” above value in Column C E Pressure with: 75 SCFH (LCC116); 150 SCFH (LCC1-51) nitrogen maintain9 0.
APPENDICES 46 Stackable LCC/LCD Oven Owner’s Manual Version 1.1 8.2. Standard Products Warranty 8.3. Electrical Schematics The following pages contain electrical schematics for the LCC1-16, LCC1-16N-4, LCC1-51-4 and LCC1-51N-4 ovens. Copyright © 2012 by Despatch Industries. All rights reserved.
Stackable LCC/LCD Oven Owner’s Manual Version 1.1 APPENDICES 47 Copyright © 2012 by Despatch Industries. All rights reserved. No part of the contents of this manual may be reproduced, copied or transmitted in any form or by any means including graphic, electronic, or mechanical methods Figureor23. LCC1-16-4 (Drawing 313930-01). photocopying, recording, or information storage and retrieval systems without the written permission of Despatch Industries, unless for purchaser's personal use.
APPENDICES 48 Stackable LCC/LCD Oven Owner’s Manual Version 1.1 Figure 24. LCC1-16-4 (Drawing 313930-02). Copyright © 2012 by Despatch Industries. All rights reserved. No part of the contents of this manual may be reproduced, copied or transmitted in any form or by any means including graphic, electronic, or mechanical methods or photocopying, recording, or information storage and retrieval systems without the written permission of Despatch Industries, unless for purchaser's personal use.
Stackable LCC/LCD Oven Owner’s Manual Version 1.1 APPENDICES 49 Figure 25. LCC1-16-4 (Drawing 313930-03). Copyright © 2012 by Despatch Industries. All rights reserved. No part of the contents of this manual may be reproduced, copied or transmitted in any form or by any means including graphic, electronic, or mechanical methods or photocopying, recording, or information storage and retrieval systems without the written permission of Despatch Industries, unless for purchaser's personal use.
APPENDICES 50 Stackable LCC/LCD Oven Owner’s Manual Version 1.1 Figure 26. LCC1-16N-4 (Drawing 313931-01). Copyright © 2012 by Despatch Industries. All rights reserved. No part of the contents of this manual may be reproduced, copied or transmitted in any form or by any means including graphic, electronic, or mechanical methods or photocopying, recording, or information storage and retrieval systems without the written permission of Despatch Industries, unless for purchaser's personal use.
Stackable LCC/LCD Oven Owner’s Manual Version 1.1 APPENDICES 51 Figure 27. LCC1-16N-4 (Drawing 313931-02). Copyright © 2012 by Despatch Industries. All rights reserved. No part of the contents of this manual may be reproduced, copied or transmitted in any form or by any means including graphic, electronic, or mechanical methods or photocopying, recording, or information storage and retrieval systems without the written permission of Despatch Industries, unless for purchaser's personal use.
APPENDICES 52 Stackable LCC/LCD Oven Owner’s Manual Version 1.1 Figure 28. LCC1-16N-4 (Drawing 313931-03). Copyright © 2012 by Despatch Industries. All rights reserved. No part of the contents of this manual may be reproduced, copied or transmitted in any form or by any means including graphic, electronic, or mechanical methods or photocopying, recording, or information storage and retrieval systems without the written permission of Despatch Industries, unless for purchaser's personal use.
Stackable LCC/LCD Oven Owner’s Manual Version 1.1 APPENDICES 53 Figure 29. LCC1-51-4 (Drawing 313932-01). Copyright © 2012 by Despatch Industries. All rights reserved. No part of the contents of this manual may be reproduced, copied or transmitted in any form or by any means including graphic, electronic, or mechanical methods or photocopying, recording, or information storage and retrieval systems without the written permission of Despatch Industries, unless for purchaser's personal use.
APPENDICES 54 Stackable LCC/LCD Oven Owner’s Manual Version 1.1 Figure 30. LCC1-51-4 (Drawing 313932-02). Copyright © 2012 by Despatch Industries. All rights reserved. No part of the contents of this manual may be reproduced, copied or transmitted in any form or by any means including graphic, electronic, or mechanical methods or photocopying, recording, or information storage and retrieval systems without the written permission of Despatch Industries, unless for purchaser's personal use.
Stackable LCC/LCD Oven Owner’s Manual Version 1.1 APPENDICES 55 Figure 31. LCC1-51-4 (Drawing 313932-03). Copyright © 2012 by Despatch Industries. All rights reserved. No part of the contents of this manual may be reproduced, copied or transmitted in any form or by any means including graphic, electronic, or mechanical methods or photocopying, recording, or information storage and retrieval systems without the written permission of Despatch Industries, unless for purchaser's personal use.
APPENDICES 56 Stackable LCC/LCD Oven Owner’s Manual Version 1.1 Figure 32. LCC1-51N-4 (Drawing 313933-01). Copyright © 2012 by Despatch Industries. All rights reserved. No part of the contents of this manual may be reproduced, copied or transmitted in any form or by any means including graphic, electronic, or mechanical methods or photocopying, recording, or information storage and retrieval systems without the written permission of Despatch Industries, unless for purchaser's personal use.
Stackable LCC/LCD Oven Owner’s Manual Version 1.1 APPENDICES 57 Figure 33. LCC1-51N-4, Drawing 313933-02). Copyright © 2012 by Despatch Industries. All rights reserved. No part of the contents of this manual may be reproduced, copied or transmitted in any form or by any means including graphic, electronic, or mechanical methods or photocopying, recording, or information storage and retrieval systems without the written permission of Despatch Industries, unless for purchaser's personal use.
APPENDICES 58 Stackable LCC/LCD Oven Owner’s Manual Version 1.1 Figure 34. LCC1-51N-4 (Drawing 313933-03). Copyright © 2012 by Despatch Industries. All rights reserved. No part of the contents of this manual may be reproduced, copied or transmitted in any form or by any means including graphic, electronic, or mechanical methods or photocopying, recording, or information storage and retrieval systems without the written permission of Despatch Industries, unless for purchaser's personal use.
Stackable LCC/LCD Oven Owner’s Manual Version 1.1 APPENDICES 59 Figure 35. LCC1-51N-4 (Drawing 313933-04). Copyright © 2012 by Despatch Industries. All rights reserved. No part of the contents of this manual may be reproduced, copied or transmitted in any form or by any means including graphic, electronic, or mechanical methods or photocopying, recording, or information storage and retrieval systems without the written permission of Despatch Industries, unless for purchaser's personal use.
APPENDICES 60 Stackable LCC/LCD Oven Owner’s Manual Version 1.1 Figure 36. LCC1-51-4 (Drawing 313934-01). Copyright © 2012 by Despatch Industries. All rights reserved. No part of the contents of this manual may be reproduced, copied or transmitted in any form or by any means including graphic, electronic, or mechanical methods or photocopying, recording, or information storage and retrieval systems without the written permission of Despatch Industries, unless for purchaser's personal use.
Stackable LCC/LCD Oven Owner’s Manual Version 1.1 APPENDICES 61 Figure 37. LCC1-51-4 (Drawing 313934-02). Copyright © 2012 by Despatch Industries. All rights reserved. No part of the contents of this manual may be reproduced, copied or transmitted in any form or by any means including graphic, electronic, or mechanical methods or photocopying, recording, or information storage and retrieval systems without the written permission of Despatch Industries, unless for purchaser's personal use.
APPENDICES 62 Stackable LCC/LCD Oven Owner’s Manual Version 1.1 Figure 38. LCC1-51-4 (Drawing 313934-03). Copyright © 2012 by Despatch Industries. All rights reserved. No part of the contents of this manual may be reproduced, copied or transmitted in any form or by any means including graphic, electronic, or mechanical methods or photocopying, recording, or information storage and retrieval systems without the written permission of Despatch Industries, unless for purchaser's personal use.
Stackable LCC/LCD Oven Owner’s Manual Version 1.1 APPENDICES 63 Figure 39. LCC1-51N-4 (Drawing 313935-01). Copyright © 2012 by Despatch Industries. All rights reserved. No part of the contents of this manual may be reproduced, copied or transmitted in any form or by any means including graphic, electronic, or mechanical methods or photocopying, recording, or information storage and retrieval systems without the written permission of Despatch Industries, unless for purchaser's personal use.
APPENDICES 64 Stackable LCC/LCD Oven Owner’s Manual Version 1.1 Figure 40. LCC1-51N-4 (Drawing 313935-02). Copyright © 2012 by Despatch Industries. All rights reserved. No part of the contents of this manual may be reproduced, copied or transmitted in any form or by any means including graphic, electronic, or mechanical methods or photocopying, recording, or information storage and retrieval systems without the written permission of Despatch Industries, unless for purchaser's personal use.
Stackable LCC/LCD Oven Owner’s Manual Version 1.1 APPENDICES 65 Copyright © 2012 by Despatch Industries. All rights No part(Drawing of the contents of this manual may be reproduced, copied or transmitted in any form or by any means including graphic, electronic, or mechanical methods Figure 41.reserved. LCC1-51N-4 313935-03). or photocopying, recording, or information storage and retrieval systems without the written permission of Despatch Industries, unless for purchaser's personal use.
APPENDICES 66 Stackable LCC/LCD Oven Owner’s Manual Version 1.1 Figure 42. LCC1-51N-4 (Drawing 313935-04). Copyright © 2012 by Despatch Industries. All rights reserved. No part of the contents of this manual may be reproduced, copied or transmitted in any form or by any means including graphic, electronic, or mechanical methods or photocopying, recording, or information storage and retrieval systems without the written permission of Despatch Industries, unless for purchaser's personal use.
Stackable LCC/LCD Oven Owner’s Manual Version 1.1 67 3rdDraft— Copyright © 2012 by Despatch Industries. All rights reserved. No part of the contents of this manual may be reproduced, copied or transmitted in any form or by any means including graphic, electronic, or mechanical methods or photocopying, recording, or information storage and retrieval systems without the written permission of Despatch Industries, unless for purchaser's personal use.