Use and Care Manual
15
ENGLISH
Blade Sharpening
KEEP BLADE SHARP FOR BEST MOWER PERFORMANCE. A
DULL BLADE DOES NOT CUT GRASSCLEANLY.
WARNING: Use gloves and proper eye protection while
removing, sharpening, and installing blade. Ensure that
safety key and battery pack are removed.
Sharpening the blade twice during a mowing season is
usually sufficient under normal circumstances. Sand causes
the blade to dull quickly. If your lawn has sandy soil, more
frequent sharpening may berequired. REPLACE BENT OR
DAMAGED BLADEIMMEDIATELY.
When Sharpening the Blade:
• Make sure blade remainsbalanced.
• Sharpen blade at the original cuttingangle.
Removing and Installing Blade (Fig. N, O)
DANGER: RISK OF INJURY. WHEN REASSEMBLING
THE BLADE SYSTEM, ENSURE EACH PART IS
REINSTALLED CORRECTLY, AS DESCRIBED BELOW.
IMPROPER ASSEMBLY OF THE BLADE OR OTHER PARTS
OF THE BLADE SYSTEM MAY CAUSE SERIOUSINJURY.
DANGER: To reduce the risk of serious personal
injury, turn unit off, remove safety key and
battery packs before making any adjustments or
removing/installing attachments or accessories.
An accidental start‑up can causeinjury.
Replacement blades are available from your nearest
authorized servicecenter.
This mower requires replacement
blade
DWO1DT233.
1. Cut a piece of 2" x 4" wood
30
(about 2feet long)
(610mm) to keep blade from turning when removing
the blade bolt
26
.
WARNING: Use gloves and proper eye protection.
Turn the mower on its side. Be careful of sharp edges
of blade.
2. Position wood and unscrew the blade bolt
26
counterclockwise with a 5/8" wrench
27
(not included)
as shownin Fig.O.
3. Remove blade bolt
26
, spring plate
28
and blade
29
as shown in Fig. N. Examine all pieces for damage and
replace ifnecessary.
4. Install sharpened or new bladeon shoulder of the blade
adapter
34
as shown in Fig.N. Blade has a winged cut
out which must match and engage the same shaped
projection on the blade adapter.
NOTE: When replacing sharpened or new blade on
shoulderof blade adapter
34
, make sure the bottom of the
blade as marked BOTTOM will be facing the ground when
the mower is returned to its normal uprightposition.
5. Install the spring plate
28
on the blade. Be sure to
align the bosses on the spring plate with the detents in
the blade, rotating the blade and spring plate together
asnecessary.
6. Position piece of wood to keep blade from turning as
shown in Fig. O. Install blade bolt
26
and securely
tighten the blade
29
with a 5/8" wrench
27
.
MAINTENANCE
DANGER: To reduce the risk of serious personal
injury, turn unit off and remove the safety key and
battery packs before making any adjustments or
removing/installing attachments or accessories.
An accidental start‑up can causeinjury.
Storage (Fig.A)
DANGER: Rotating blade can cause serious
injury. Release bail handle to turn mower off, remove
safety key, and remove battery packs before lifting,
transporting, or storing the mower. Store in a dryplace.
CAUTION: Pinch point. To avoid being pinched, keep
fingers away from area around handle brackets when
folding downhandles.
The handle of the mower can be easily folded down for quick
and convenientstorage.
1. On the lower handle, twist the handle lock knobs
7
a
quarterturn.
2. Rotate the handle towards the front of themower. Take
care to not pinch or stress thecord.
3. Twist the handle lock knobs
7
a quarter turn to lock the
handle into storage
position.
4. The mower can be stored standing up, with the
collection bag removed, or flat on itswheels.
• If mower should start to vibrate abnormally, release bail
handle to turn mower off, remove the safety key and
battery packs. Check immediately for cause. Vibration is a
warning of trouble. Do not operate mower until a service
check has beenmade.
• For best cutting results, keep blade sharpened
andbalanced.
• Inspect and thoroughly clean mower after each use as a
deck with caked grass will degradeperformance.
• Always release bail handle to turn mower off, remove
safety key and battery packs when leaving it unattended
even for a short period oftime.
The following suggestions will help you
to obtain optimum run time from your
cordless mower:
• Slow down in areas where the grass is especially long
orthick.
• Avoid mowing when the grass is wet from rain or
dew-soaked.
• Cut your lawn frequently, especially during high
growthperiods.
NOTE: It is recommended that your battery packs be
recharged after use to prolong the battery pack life. Frequent
charging will not harm your battery pack, and will ensure that
the battery pack is fully charged and ready for its next use.
Storing battery pack not fully charged will shorten itslife.