Installation Guide

FORD F150
2004 - 2014
1-800-992-1949
!
!
!
While!temperature!does!not!affect!your!DualLiner,!it!is!easier!to!install!when!
the!bedliner!is!above!50!degrees!Fahrenheit.!If!working!in!colder!temperatures,!
it!is!helpful!to!warm!the!bedliner!indoors!prior!to!installation.!The!mat!may!
take!a!“set”!while!rolled.!!If!possible,!unroll!the!mat!and!let!it!“relax”!in!the!sun!
to!make!it!easier!to!work!with.!If!installing!in!cold!weather!it!may!take!several!
weeks!for!the!mat!to!fully!relax.!
!
First,!remove!the!four!bed!tie!downs!and!
bed!extender!if!so!equipped.!Then!snap!
the!loadguard,!or!front!panel,!over!the!
rail!at!the!cab!end!of!the!bed.!Install!the!sidewalls!by!tucking!them!
under!the!bed!rail.!!If!your!truck!has!bed!rail!caps,!tuck!the!liner!under!
the!caps.!!Align!the!holes!in!the!sidewalls!with!the!holes!in!the!
loadguard.!!You!may!use!a!Phillips!screwdriver!or!punch!as!an!alignment!
tool.!Press!the!Christmas!tree!pushJpins!into!the!holes.!!
!
Reinstall!the!tie!downs!leaving!them!loose!until!both!are!installed!and!then!tighten!evenly.!!
!
If!your!truck!is!equipped!with!a!bed!extender,!you!will!see!three!pin!marks!at!the!back!edge!of!the!side!panel!
that!aligns!with!the!holes!for!your!bed!extender.!!Open!these!up!to!the!correct!size!with!a!drill!bit!and!reinstall!
your!bed!extender.!!
!
With!ribbed!side!up!and!with!the!mat!part!number!visible!on!the!lower!right!
side!of!the!truck!bed,!lift!the!mat!into!the!truck!bed.!!Begin!tucking!the!mat!
into!the!channel!on!one!side!of!the!bed!and!repeat!for!the!opposite!side.!
Make!sure!the!mat!is!pulled!tightly!to!the!front!of!the!truck.!!
!
The!next!step!is!installing!the!tailgate!panel.!!If#your#truck#is#equipped#with#a#
tailgate#step,#you#will#not#use#the#tailgate#
panel.##
!
!
!
Install!the!tailgate!panel!using!the!latch!access!screws.!!Note!that!two!are!not!
removed!to!simplify!the!installation.!!Align!the!panel!and!reinstall!the!screws.!
Drill!¼Jinch!holes!in!the!center!of!the!slots!of!the!panel.!Lift!the!panel!to!clear!
away!any!chips!from!drilling.!!Apply!rust!preventative!to!each!hole!and!to!the!
Christmas!tree!pin.!!Insert!one!pin!in!each!hole,!twisting!the!pin!to!evenly!
distribute!the!rust!preventative.!
!
*The!2010!FJ150!tailgate!protector!rests!above!the!recesses!of!the!tailgate!whereas!earlier!models!will!rest!into!the!
recesses!of!the!tailga te.!!
!
Installation
Instructions