user manual

ManualsBrandsDuraflame Manualsfire pitFire Pit bio-ethanol fire pit with log set

-1-

Bio-ethanol Fire Pit with Log Set

Model # 62000

Distributed by:

Duraame, Inc., Stockton, CA 95201

Made in China

For questions about Assembly and Operating instructions or Warranty Claims

contact Duraame, Inc. Consumer Aairs

info@duraame.com

1 (866) 552-3015

www.duraame.com/illuma

Patents Pending

WARNING: If the information in this manual is not followed exactly, a ﬁre or explosion may

result, causing property damage, personal injury, or loss of life.

Do not store or use gasoline or other ﬂammable vapors and liquids in the vicinity of this or any

other appliance.

WHAT TO DO IN THE EVENT OF AN ALCOHOL SPILL: DO NOT light the burner. Extinguish

any open ﬂame near the spill. Wipe up the spill, and wait several minutes for the residue to

evaporate.

WARNING: Improper installation, adjustment, alteration, service, or maintenance can cause

injury or property damage. Refer to this manual for correct installation and operational

procedures.

This appliance is for use only with the type of fuel indicated on the rating plate. This appliance

is not convertible for use with other fuels.

Make sure that all packaging materials, including anything made from plastic, paper or

cardboard is removed before assembling and using the appliance.

Save this manual for future reference.

Summary of content (16 pages)

PAGE 1
Bio-ethanol Fire Pit with Log Set Model # 62000 Distributed by: Duraflame, Inc., Stockton, CA 95201 Made in China For questions about Assembly and Operating instructions or Warranty Claims contact Duraflame, Inc. Consumer Affairs info@duraflame.com 1 (866) 552-3015 www.duraflame.com/illuma Patents Pending WARNING: If the information in this manual is not followed exactly, a fire or explosion may result, causing property damage, personal injury, or loss of life.
PAGE 2
TABLE OF CONTENTS page I. Safety Information......................................................................... 3 II. Setup............................................................................................. 6 III. Minimum Clearances..................................................................... 6 IV. Installation..................................................................................... 7 V. Installing the Fuel Canister.................................
PAGE 3
I. SAFETY INFORMATION IMPORTANT: Read this owner’s manual carefully and completely before trying to assemble, operate, or service this appliance. Improper use of this appliance or failure to comply with the safety rules can cause serious injury or death from burns, fire, explosion, or carbon monoxide poisoning. Keep this manual. It should be read by all users of the appliance. This appliance is designed for outdoor use. Do not use indoors.
PAGE 4
This appliance is designed to be smokeless. If the logs begin to smoke, extinguish the appliance by using the snuffer (see Section VI Operation), and check the positioning of the logs. Note: During initial operation, slight smoking may occur due to log curing and the burning off of manufacturing residues. This is a normal condition. Do not run this appliance where flammable liquids or vapors are used or stored, or in a dusty environment. Do not place any flammable material close to the appliance.
PAGE 5
Figure 1 Parts of the Appliance -5-
PAGE 6
II. SETUP CAUTION: Do not remove the metal data plate that is attached to the underside of the door to the fuel compartment of the appliance. It contains important product information. WARNING: Never install this appliance • indoors • in a recreational vehicle, boat, or tent • where furniture, clothing, or other flammable objects are less than 42 inches (3.5 feet) from the front, top, or sides of the appliance • in high traffic areas Use this appliance in compliance with all local ordinances. III.
PAGE 7
IV. INSTALLATION 1. Carefully remove the contents of the carton. You should find (See Figure 1): • • • • • • • • • • Table Table Legs Hardware needed (screws and nuts) Fire Pit Burner Assembly Log Plate Five logs Flame Snuffer One set of three flame adjustment rings (packaged inside the burners) Water Proof Cover If components are missing, contact Duraflame. Figure 3 How to attach the legs 2. Remove all these components from their packing. When handling the logs, take care not to damage them.
PAGE 8
Step #1: Table Step #2: Adding Fire Pit Step #3: Adding Burner Assembly Step #4: Adding Log Plate Figure 4 Steps for Assembling Fire Pit 9. Remove flame adjustment rings from inside the burners. 10. Carefully position the logs on the log plate according to the illustrations provided below (see Figures 6-10). The pins that protrude upward from the log plate and fuel compartment door will help you to position the logs correctly. Log #1 will fit on a pin that protrudes from the door.
PAGE 9
Figure 5 Logs Figure 6 Installing Log 1 Figure 7 Installing Log 2 Figure 8 Installing Log 3 Figure 9 Installing Log 4 Figure 10 Installing Log 5 -9-
PAGE 10
V. INSTALLING THE FUEL CANISTER NOTE: Use only 1 L duraflame illuma-fuel bio-ethanol fuel canisters with this appliance. The canisters are NOT refillable. 1. Remove the log that covers the door of the canister compartment. Set the log in a safe place where it will not be damaged. (see Figure 11). Do not touch the log in any area other than the one shown when flames are present or the appliance is still hot. Figure 11 Removing Log #1 Figure 12 Opening Compartment door 2.
PAGE 11
might hear a soft gurgling noise as the fuel from the canister begins to fill the burner—this is normal. Make sure the left side is tipped down during installation. 5. After the canister has been installed, close the door of the fuel compartment using the hook on either side of the door, and replace the log that was removed in step 1. (see Figure 14). The appliance is now ready for use. Make sure you use the hook on either side of the door to close the door when the appliance is hot.
PAGE 12
1. Remove the log that covers the fuel compartment door. Be very careful about where you touch the log. See Figure 11. Make sure you handle the log on the branch that is farther from the flames. CAUTION: THE AREAS OF THE LOG THAT ARE CLOSEST TO THE FLAME ARE VERY HOT AND WILL BURN YOUR HAND. Set the log in a safe place where it will not be: damaged, come into contact with anything combustible, or be touched by somebody else. 2. Open the door of the fuel canister compartment using the hole in the door.
PAGE 13
X. MAINTENANCE WARNING: Turn off the appliance and let it cool before cleaning. CAUTION: Periodic cleaning is necessary to ensure proper functioning of this appliance. The only maintenance needed for the continued proper performance of this appliance is periodic cleaning. To clean the appliance: 1. Allow the flames to die out naturally by consuming all the fuel. This will ensure that there is only residual alcohol in the tubes between the fuel tray area and the burners.
PAGE 14
XI. TROUBLESHOOTING Use the following guide to solve any problems you might encounter in operating this appliance. PROBLEM 1. You see fuel on the ground near the appliance. SOLUTION • DO NOT light the burner. Extinguish any open flame near the spill. Wipe up the spill, and wait several minutes for the residue to evaporate. If you see no additional fuel on the ground, you may light the burner. If you see additional fuel on the ground, you might have a leak. DO NOT use this appliance if it leaks fuel. 2.
PAGE 15
If the canister is difficult to insert or the canister binds to the piercer when being removed, it means that the bracket on the left side of the reservoir is bent too far to the right. Carefully bend the bracket on the left side of the reservoir slightly to the left to allow a little more space for the canister when it is being installed or removed. XII. PARTS LIST PART NO.
PAGE 16
WARRANTY INFORMATION KEEP THIS WARRANTY Model:_____________________________________ Serial No.:__________________________________ Date Purchased:_____________________________ Always specify model and serial numbers when communicating with Duraflame, Inc. We reserve the right to amend the specifications of this product at any time without notice. The only warranty applicable is our standard written warranty. We make no other warranty, expressed or implied.