Use and Care Manual

ManualsBrandsDuraHeat ManualsGas Heaters30,000 BTU Double Tank Top Propane Heater

USER’S MANUAL AND OPERATING INSTRUCTIONS

GENERAL HAZARD WARNING

FAILURE TO COMPLY WITH THE PRECAUTIONS AND INSTRUCTIONS PROVIDED WITH

THIS HEATER, CAN RESULT IN DEATH, SERIOUS BODILY INJURY AND PROPERTY LOSS,

OR DAMAGE FROM THE HAZARDS OF FIRE, EXPLOSION, BURN. ASPHYXIATION, CARBON

MONOXIDE POISONING, AND/OR ELECTRICAL SHOCK.

ONLY PERSONS WHO CAN UNDERSTAND AND FOLLOW THE INSTRUCTIONS SHOULD

USE OR SERVICE THIS HEATER.

IF YOU NEED ASSISTANCE OR HEATER INFORMATION SUCH AS AN INSTRUCTION

MANUAL, LABELS, ETCETERA, CONTACT THE MANUFACTURER.

CONSUMER: Retain this manual for future reference.

Printed in China

Made by

World Marketing of America, Inc.

PO Box 192, 12256 William Penn Hwy.

Mill Creek PA 17060-0192

(Tel) 1-800-776-9425

www.worldmkting.com

PROPANE

TANK TOP HEATER

MODELS: TT-15CSA, TT-30CSA

WARNING!

NOT FOR HOME OR

RECREATIONAL VEHICLE USE.

C US

ANS Z83.7-2011 CSA 2.14-2011

IMTTDHCSA-KCa

Summary of content (18 pages)

PAGE 1
PROPANE TANK TOP HEATER USER’S MANUAL AND OPERATING INSTRUCTIONS MODELS: C TT-15CSA, TT-30CSA US ANS Z83.7-2011 CSA 2.14-2011 WARNING! NOT FOR HOME OR RECREATIONAL VEHICLE USE. GENERAL HAZARD WARNING FAILURE TO COMPLY WITH THE PRECAUTIONS AND INSTRUCTIONS PROVIDED WITH THIS HEATER, CAN RESULT IN DEATH, SERIOUS BODILY INJURY AND PROPERTY LOSS, OR DAMAGE FROM THE HAZARDS OF FIRE, EXPLOSION, BURN. ASPHYXIATION, CARBON MONOXIDE POISONING, AND/OR ELECTRICAL SHOCK.
PAGE 2
PAGE 3
TABLE OF CONTENTS General Safety Information ............................................................................... 3 - 4 Specifications .............................................................................................................. 3 Product Features ...................................................................................................... 4 Heater Assembly .......................................................................................................
PAGE 4
PROPANE TANK TOP HEATER PROPANE TANK TOP CONSTRUCTION HEATERS The heater is designed and approved for use as a construction heater under ANSI Z83.7 CSA 2.14. It is hard to anticipate every use which may be made of this heater. CHECK WITH YOUR LOCAL FIRE SAFETY AUTHORITY IF YOU HAVE QUESTIONS ABOUT APPLICATIONS. Other standards govern the use of fuel gases and heat producing products in specific applications. Your local authority can advise you about these.
PAGE 5
PROPANE TANK TOP HEATER GENERAL SAFETY INSTRUCTIONS Accidents are always tragic especially because so many of them could have been prevented with little care and judgment. There are some basic good practices, we hope you will follow for safe use of your heater. IMPORTANT SAFETY INFORMATION • Children should be carefully supervised, when they are in the area. • Always maintain proper clearance from combustible materials. Minimum clearance from combustibles.
PAGE 6
PROPANE TANK TOP HEATER TT30 SERIES HEATER ASSEMBLY Tools Required: Estimated Assembly Time: Contents: Phillips head screwdriver 5 minutes Tank Top Heater (1) Tank Collar Bracket (1) M4x12 Machine Screws (2) DUAL BURNER MODEL The tank collar bracket must be assembled before the heaters can be attached to the propane tank. 1. Align bolt holes in tank collar bracket and piezo bracket with bolt holes in center plate on manifold. 2.
PAGE 7
PROPANE TANK TOP HEATER PROPANE SUPPLY This heater requires a 20 lb propane cylinder for operation. (Not included). The propane (LP) gas tank must also be equipped with the following: • A collar to protect the propane gas valve. • A shutoff valve terminating a Propane gas cylinder valve outlet as specified in the American National Standard for Compressed Gas Cylinder Valve Outlet and Inlet Connections. • A safety relief valve having direct communications with the vapor space of the tank.
PAGE 8
PROPANE TANK TOP HEATER CONNECTING HEATER TO PROPANE TANK Read and understand all safety information before connecting heater to propane tank. 1. (Applies to dual burner models only). Place heater onto tank with tank collar bracket over tank collar (Fig. 1) Mounting bolt knob should be positioned to the outside of tank collar and be positioned as closely as possible directly opposite to the cylinder valve outlet. See Figures 1 and 2. 2. (Applies to dual burner models only).
PAGE 9
PROPANE PROPANETANK TANKTOP TOPHEATER HEATER CONNECTING CONNECTINGHEATER HEATERTO TOPROPANE PROPANETANK TANK FIGURE 2 Electrode Spark Plug TT30 SERIES Tip over OverSwitch Switch Inlet Connector Piezo only) Piezo(NOTE: (NOTE:some some models models only) Propane Tank Valve Heat Regulator Knob Mounting MountingBolt BoltKnob knob Handwheel Fuel Connecting Bolt ( Handle) FIGURE 3 Electrode Spark Plug TT15 SERIES Ignition Hole Piezo (NOTE: some models only) Wing Bolt Safety Shut-off valve Valve Heat Reglua
PAGE 10
PROPANE TANK TOP HEATER CHECKING FOR LEAKS Check all gas connections with a 50/50 soap and water solution to be sure they are tight and leak proof. The formation of bubbles indicate a gas leak. Correct all leaks before using the heater. • The installation of your heater must meet all local codes and/or gas utility requirements or, in the absence of local codes, with the Storage and Handling of Liquefied Petroleum Gases, ANSI/NFPA 58 and the Natural and Propane Installation Code, CSA B149.1.
PAGE 11
PROPANE TANK TOP HEATER LIGHTING INSTRUCTIONS WHEN USING MATCH (CONTINUED) 1. Open Cylinder valve by turning . counterclockwise FIGURE 4 Burner Front 2. Turn heater regulator knob to the clockwise “High” ( ) position. (Fig. 4) Electrode WARNING: Stand to the side of unit while lighting. Do not stand or have any part of your body over or in front of heater while lighting. Ignition Hole Piezo 3. Do not attempt to light one burner off of the other. Use one match per burner.
PAGE 12
PROPANE TANK TOP HEATER TURNING OFF THE HEATER 1. Tightly close propane tank valve by turning fully clockwise 2. Turn the heater regulator knob to the “OFF” ( before handling heater. . ) position. Wait at least 30 minutes for the heater to cool 3. Always remove the heater from the propane tank after each use and store indoors. Do not store heater while attached to propane tank. Do not store propane cylinders in a building, garage or any other enclosed area.
PAGE 13
PROPANE TANK TOP HEATER LIGHTING INSTRUCTIONS FOR PIEZO IGNITION MODELS (CONTINUED) 1. Stop! Read all safety information first. 2. Open cylinder valve by turning counterclockwise . WARNING: Stand to the side of unit while lighting. Do not stand or have any part of your body over or in front of heater while lighting. 3. Turn heater regulator knob counterclockwise to “OFF” ( ) position. 4. Wait five (5) minutes to clear out any gas. Then smell for gas, including near the floor.
PAGE 14
PROPANE TANK TOP HEATER LIGHTING UNDER WIND CONDITIONS When using this heater outdoors on a windy day, it will be necessary to use a match or long stem butane lighter to ignite the burner. It may be difficult to keep the match lit long enough under windy conditions. Follow the “Lighting instructions when Using a Match” procedure after doing the following: 1. Position the heater and cylinder such that the burner faces away from the wind. 2.
PAGE 15
PROPANE TANK TOP HEATER TROUBLESHOOTING PROBLEM POSSIBLE CAUSE 1. Unit will not light. 2. Burner will not stay lit when gas valve plunger released. 3. Excessive flames coming out of burner, not glowing red. CORRECTIVE ACTION 1. Valve on propane cylinder not open. 1. Open cylinder valve by turning counterclockwise. 2. Propane cylinder empty 2. Have cylinder refilled. 3. Regulator not in "High" position 3. Turn regulator to "High" position. 4. Excess flow device triggered. 4.
PAGE 16
PROPANE TANK TOP HEATER REPLACEMENT PARTS PARTS ILLUSTRATION ILLUSTRATION REPLACEMENT TT15 SERIES SERIES TT15 TT30 SERIES SERIES TT30 NEVER LEAVE THE HEATER UNATTENDED WHILE BURNING! 16 15
PAGE 17
LIMITED WARRANTY: This limited warranty is extended to the original retail purchaser of this Duraheat Forced Air/Convection/Radiant Heater and warrants against any defect in materials and workmanship for a period of one (1) year from the date of retail sale. World Marketing of America, Inc.
PAGE 18
WARRANTY REGISTRATION IMPORTANT: We urge you to fill out your warranty registration card within fourteen (14) days of date of purchase. You can also register your warranty on the internet at www.worldmkting.com. Complete the entire serial number. Retain this portion of the card for your records. World Marketing of America, Inc. World Marketing of America, Inc. Route 22 West PO Box 192, 12256 Penn Hwy. PO BoxWilliam 192 Creek, 17060 MillMill Creek PAPA 17060-0192 Tel: (800) 776-9425 Tel) 1-800-776-9425 www.