Use and Care Manual

TROUBLESHOOTING
1. Unitwillnotlight. 1. Valveonpropanecylindernotopen. 1. Opencylindervalvebyturningcounterclockwise.
2. Propanecylinderempty 2. Havecylinderrefilled.
3. Regulatornotin"High"position 3. Turnregulatorto"High"position.
4. Excessflowdevicetriggered. 4. Closecylidervalve,wait5minutesandreopenslowly.
5. DefectiveRegulator. 5. ReplaceRegulatorassembly.
2. Burnerwillnotstaylitwhen 1. Tiltswitchopen 1. Correctalignmentofunittoensureitisvertical.
gasvalveplungerreleased. 2. Wiringofthermocouple 2. Checkwiringconnectionsareproperlyengaged.
3. Defectivethermocouple 3. Replacethermocouple.
4. Defectivetiltswitch 4. Replacetiltswitch.
5. Defectivegasvalve 5. Replacegasvalveassembly.
3. Excessiveflamescomingout 1. Debrisorspiderwebsinmixingtube 1. Cleanburnertubewithbottlebrush,rinseinwater
ofburner,notglowingred. orburner. anddrainthoroughlybeforereintsalling.
2. Cloggedorifice 2. Removeandcleanusingcompressedair.
4. Piezowon'tspark. 1. Defectivepiezo 1. ReplacePiezo
(Somemodelsonly) 2. IgnitormisalignedwithThermocoupleshield 2. Realignignitorwiththermocoupleshield.
3. Wirefrayedordamaged. 3. Replacewire.
5. Flamesflashback/burninside 1. Debrisorspiderwebsinmixingtube. 1. Cleanburnertubewithbottlebrush,rinseinwater
themixingtube anddrainthoroughlybeforereintsalling.
2. Cloggedorifice 2. Removeandcleanusingcompressedair.
PROBLEM
POSSIBLECAUSE
CORRECTIVEACTION
REPLACEMENT PARTS LIST
14
PROPANE TANK TOP HEATER
TT15CSA TT30CSA
1 RegulatorAssembly GR121 GR121
2 BurnerAssembly TT150001 TT150001
3 ThermocoupleAssembly TT15C11 TT15C11
4 GuardAssembly TT15C03 TT15C03
5 RearGuardAssembly TT15C04 TT15C04
6 SafetyShutoffValve GS13 GS13
7 Manifold  K80DA502
8 PiezoAssembly  
9 TankCollarBracket  TT30C02
10 MountingBoltKnob  TT30C3
11 GasHose  GDH1
12 Handwheel QG01001 QG01001
13 Electrode  
14 TipOverSwitch
KW-16B KW-16B
15 SupportLeg TT15C02 
ITEM DESCRIPTION
PartNumber
NEVER LEAVE THE HEATER
UNATTENDED WHILE BURNING!