Operating instructions

ManualsBrandsElectrolux ManualsCooktop318201475 (0710)

GAS COOKTOP INSTALLATION INSTRUCTIONS

INSTALLATION AND SERVICE MUST BE PERFORMED BY

A QUALIFIED INSTALLER.

IMPORTANT: SAVE FOR LOCAL ELECTRICAL INSPECTOR'S USE.

READ AND SAVE THESE INSTRUCTIONS FOR FUTURE REFERENCE.

318201475 (0710) Rev. D

English - pages 1-8

Español - páginas 9-16

Français - pages 17-23

Wiring Diagram page - 24

If the information in this manual is not followed exactly, a fire or explosion may result causing

property damage, personal injury or death.

FOR YOUR SAFETY:

— Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other

appliance.

— WHAT TO DO IF YOU SMELL GAS:

• Do not try to light any appliance.

• Do not touch any electrical switch; do not use any phone in your building.

• Immediately call your gas supplier from a neighbor's phone. Follow the gas supplier's instructions.

• If you cannot reach your gas supplier, call the fire department.

— Installation and service must be performed by a qualified installer, service agency or the gas supplier.

NOTE: Wiring diagrams for this cooktop are enclosed in this booklet

Figure 1

Gas Cooktop Dimensions

Gas Cooktop Cutout

Dimensions

30"(76.2 cm)

Min.*

4" X 4" (10.2 cm x 10.2

cm) opening to route gas

supply.

2"(5.1 cm) Dia.

Opening to route

power cable

For Standard

Installation:

1" (2.5 cm)

2"(5.1 cm)

(18.4 cm)

3"(7.6 cm)

(6.4 cm)

All dimensions are stated in inches and (cm).

CUTOUT DIMENSIONS J. DEPTH BELOW

MODEL A. LENGTH B. WIDTH C. DEPTH LENGTH WIDTH COOKTOP

D** E** F G H

36 (91.4) 35

(91.1) 25 (63.5) 7¾ (19.7) 35

(91.3) 35

(89.4) 35

/8 (89.2) 22 (55.9) 1

(2.9) Max. 7

(19.1)

30 (76.2) 29

(75.9) 25 (63.5) 7¾ (19.7) 29

(76) 29

(74.1) 29

/8 (74) 22 (55.9) 1

(2.9) Max. 7

(19.1)

* 30" (76.2 cm) min. for

unprotected cabinet and

24" (61 cm) min. for cabinet

with protected bottom surface.

**Note: D & E are critical to the proper

installation of the cooktop. D reflects the

finished dimension. Due to the variation in

countertop materials, it is recommended to first

undercut this dimension, and then adjust it

upon installation of the cooktop.

Summary of content (8 pages)

PAGE 1
GAS COOKTOP INSTALLATION INSTRUCTIONS INSTALLATION AND SERVICE MUST BE PERFORMED BY A QUALIFIED INSTALLER. IMPORTANT: SAVE FOR LOCAL ELECTRICAL INSPECTOR'S USE. READ AND SAVE THESE INSTRUCTIONS FOR FUTURE REFERENCE. If the information in this manual is not followed exactly, a fire or explosion may result causing property damage, personal injury or death. FOR YOUR SAFETY: — Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance.
PAGE 2
GAS COOKTOP INSTALLATION INSTRUCTIONS * 30" (76.2 cm) min. for unprotected cabinet and 24" (61 cm) min. for cabinet with protected bottom surface. For Installation with the optional Stainless Steel Backsplash. 30"(76.2 cm) Min.* Gas Cooktop Dimensions A 2"(5.1 cm) B 9" (22.9 cm) Optional Stainless Steel Backsplash C ***Note: Applies only in case of countertop backwall. 4"X 4" (10.2 cm x 10.2 cm) opening to route gas supply. K*** 3"(7.6 cm) 2 1/2" (6.4 cm) 2" (5.1 cm) Dia.
PAGE 3
GAS COOKTOP INSTALLATION INSTRUCTIONS Important Notes to the Installer This cooktop has been design certified by CSA International. As with any appliance using gas and generating heat, there are certain safety precautions you should follow. You will find them in the Use and Care Guide, read it carefully. 1. Read all instructions contained in these installation instructions before installing the cooktop. 2. Remove all packing material before connecting the electrical supply to the cooktop. 3.
PAGE 4
GAS COOKTOP INSTALLATION INSTRUCTIONS 13" (33 cm) max. depth for cabinet installed above cooktop A 30" (76.2 cm) Min. Clearance Between the Top of the Cooking Platform and the Bottom of an Unprotected Wood or Metal Cabinet 24" (61 cm) Min. when Bottom of Wood or Metal Cabinet is Protected by Not Less Than 1/8" Flame Retardant Millboard Covered With Not Less Than No. 28 MGS Sheet Steel, 0.015" (0.4 mm) Stainless Steel, 0.024" (0.6 mm) Aluminum or 0.020" (0.5 mm) Copper 2" (5.1 cm) min.
PAGE 5
GAS COOKTOP INSTALLATION INSTRUCTIONS The conversion must be performed by a qualified service technician in accordance with the kit instructions and all local codes and requirements. Failure to follow instructions could result in serious injury or property damage. The qualified agency performing this work assumes responsibility for the conversion. Wall Outlet Location 4" (10.2 cm) Failure to make the appropriate conversion can result in serious personal injury and property damage. 5" (12.
PAGE 6
GAS COOKTOP INSTALLATION INSTRUCTIONS The supply line should be equipped with an approved shutoff valve. This valve should be located in the same room as the cooktop and should be in a location that allows ease of opening and closing. Do not block access to the shutoff valve. The valve is for turning on or shutting off gas to the appliance. Grounding Instructions IMPORTANT Please read carefully. For personal safety, this appliance must be properly grounded.
PAGE 7
GAS COOKTOP INSTALLATION INSTRUCTIONS Check Operation 4. Adjust the "LOW" Setting of Regular Burner (see figure 8) on the Surface Burner Valves (Figure 9): a. Push in and turn control to LITE until burner ignites. b. Quickly turn knob to LOWEST POSITION. c. If burner goes out, reset control to OFF. d. Remove the surface burner control knob and decorative ring. e. Insert a thin-bladed screwdriver into the hollow valve stem and engage the slotted screw inside.
PAGE 8
GAS COOKTOP INSTALLATION INSTRUCTIONS 5. Adjust the "LOW" Setting of the Dual Burner (see Figure 8) on the Surface Burner Valve (Figure 10): Note: On the dual valve the low setting of each portion (rear portion of bridge burner and the center portion of bridge burner) should be adjusted individually. a. Push in and turn control to LITE until the rear portion of the bridge burner ignites only. b. Quickly turn knob to LOWEST POSITION. c. If burner goes out, reset control to OFF. d.