Instructions / Assembly

6
Evo, Inc., 20560 SW 115th Ave., Tualatin, OR 97062 USA
Phone [phone] | Fax [phone] | www.evoamerica.com | [e-mail]
SAFETY PRECAUTIONS
• Installation of grill must conform with local codes, or in ab-
sence of local codes, with National Fuel Gas Code, NFPA
54 / ANSI Z223.1-latest edition. Handling of LP tanks
must conform to NFPA / ANSI 58-latest edition.
• Do not install or use grill within 36” of combustible materi-
als from back and sides of grill. Grill shall not be located
under unprotected overhead (enclosed carport, garage,
porch, patio) made of combustible construction.
• Grill must not have any obstructions in the venturi-orifi ce
air inlet area.
• Visually inspect hose before each use of grill. If there is
excessive abrasion or wear, or if the hose is cut, it must
be replaced prior to grill operation.
• Only use valve/hose/regulator that was supplied by Evo
with the purchase of your grill.
• Follow lighting and control instructions as described in the
Use & Care section of this manual.
• VERY IMPORTANT: Never attempt to place any other
cooking utensils (skillets, pots, pans) directly on the burn-
ers. Only the Evo cooking grill surface is to be placed
over the burners. Only use grill with the supplied grill
cooking surface. Buildup of non-ignited gas under other
utensils is very dangerous.
• Grill cooking area should be kept clear and free from
combustible materials, gasoline and other fl ammable
vapors and liquids. Do not obstruct fl ow of combustion
and ventilation air. Keep ventilation openings of LP gas
tank enclosure free and clear from debris. Visually check
burner fl ames on regular basis.
• Grill is for outdoor use only. Grill should be operated
in a well-ventilated space. Never operate in enclosed
space, garage or building. Your grill is not intended to be
installed in or on recreational vehicles and/or boats.
• Valve/hose/regulator supplied with grill must be used.
Replacement valve/hose/regulator must be those supplied
by Evo.
• Carefully follow instructions in assembly manual for at-
taching regulator to LP tank.
• Purging: Do not release liquid propane (LP) fuel into
atmosphere. This is a dangerous practice. If it is neces-
sary to remove fuel from LP gas tank, please call local fi re
department for assistance.
• If you have questions or comments concerning the care
and use of your grill, or if you need warranty parts, call
1-866-626-1802 or send a fax to 503-213-5869. To order
non-warranty replacement parts or accessories, call
1-800-626-1802 or send a fax to 503-213-5869.
Please know your Grill Serial Number and Date of
Purchase before calling.
Safety Reminders
Consumer Service
Before Beginning Assembly
 Read all assembly instructions. The installation diagrams
are for reference only; they do not contain all information
needed to correctly assemble your grill.
 Metal edges can be sharp. Use caution during assembly
and use. Wear protective gloves as necessary.
 Lay cardboard on the ground when unpacking.
Assemble grill parts on the cardboard to avoid scratching
surfaces.
 Necessary tools: Your grill is supplied with a socket and
“L” handle, and one 7/16” open-end box wrench. Other
tools you will need to supply are a Phillips screwdriver,
a hammer and a small wooden
block.
 You may fi ll an LP gas tank pur-
chased from a local supplier prior
to assembly. The tank must also
have the Safety Cap installed (see
diagram) on the tank valve when
not in use. Also see your Use &
Care Manual.
 If your grill is to be used with a Natural Gas Connection,
you must use the Natural Gas Hose Assembly supplied
with your Evo grill, or an Evo approved Natural Gas Hose
Assembly as shown and described in this manual.
WARNING
Do not attempt to put other cooking utensils (skillets, pots,
pans) directly on the burners.
When grill is not in use, turn off both control knobs and turn
tank off.
WARNING
Carefully follow instruction in assembly manual and this
booklet for proper assembly and gas leak testing of your
grill. Do not use grill until leak checked. If leak is detected
at anytime, it must be stopped and corrected before using
grill further.
Safety Cap Installed