MINI CULTIVATOR & DETHATCHER INSTRUCTIONS Y4007 THANK YOU FOR PURCHASING YOUR GARDEN TRAX GARDEN TOOL! IT IS IMPORTANT THAT YOU READ ALL ASSEMBLY, USAGE AND SAFETY INSTRUCTIONS! PLEASE TAKE TIME TO READ THIS MANUAL AND FOLLOW ALL INSTRUCTIONS TO ENHANCE YOUR GARDENING EXPERIENCE! THEN PLEASE REGISTER YOUR PURCHASE AT WWW.THUNDERBAYPRODUCTS.COM OR BY FILLING OUT AND MAILING IN YOUR WARRANTY CARD.
MODEL Y4007 MINI CULTIVATOR AND DETHATHER CONGRATULATIONS... on purchasing your new GARDEN TRAX MINI CULTIVATOR & DETHATCHER and welcome to the world of Garden Trax Gardening. We know that you are anxious to get right to work and start working in your garden, but before you do, it is important that you take a few moments and familiarize yourself with your new unit and its a s s e m b l y a n d operating instructions. Please read your owner’ s manual and take time to save time.
MODEL Y4007 MINI CULTIVATOR AND DETHATHER REGISTRATION RECORD YOUR MODEL INFORMATION IN THE SPACE BELOW FOR EASY REFERENCE AND BE SURE AND FILL OUT AND MAIL IN YOUR REGISTRATION CARD FOUND IN YOUR PARTS PACKAGE MODEL NUMBER SERIAL NUMBER ENGINE SERIAL NUMBER DATE OF PURCHASE PLACE OF PURCHASE OWNER’S RESPONSIBILITY AND MODEL SPECIFICAIONS CORRECT, ACCURATE ASSEMBLY AND SAFE USE OF THIS UNIT IS YOUR RESPONSIBILITY!!!! ● ● ● ● ● READ AND FOLLOW ALL SAFETY INSTRUCTIONS PAY CLOSE ATTENTION AND FULLY UNDERSTA
MODEL Y4007 MINI CULTIVATOR AND DETHATHER IMPORTANT! AVOID DAMAGE! THIS TEXT IS USED TO TELL THE OPERATOR OF ACTIONS OR CONDITIONS THAT MIGHT RESULT IN DAMAGE TO THE UNIT! GENERAL SAFETY RULES CAUTION! AVOID INJURY! THIS SYMBOL AND TEXT HIGHLIGHT POTENTIAL HAZARDS OR STITUATIONS THAT COULD CAUSE DEATH TO THE OPERATOR OR BYSTANDERS THAT COULD OCCUR IF THE HAZARDS OR SAFETY PROCEEDURES ARE IGNORED! SPECIAL MESSAGES This manual contains special messages to highlight and bring a en on to poten al safety con
MODEL Y4007 MINI CULTIVATOR AND DETHATHER ENGINE SAFETY PRECAUTIONS CARBON MONOXIDE POISING WARNING All engines have carbon monoxide contained in their exhaust fumes. It is a deadly, colorless, odorless, tasteless gas which could be present even though you see or smell no engine exhaust. In an enclosed area with no ven la on, this gas can linger for days. If inhaled at any level, this gas can cause drowsiness, headaches, nausea, dizziness, confusion and even death.
MODEL Y4007 MINI CULTIVATOR AND DETHATHER BURNS AND FIRES Certain parts of this unit such as the muffler, muffler guard and engine parts become extremely hot during the opera on of this unit. These parts will remain extremely hot even a er the unit has been turned off and stopped running Preven on of Burns and Fires ● ● ● ● Never remove the muffler guard from the engine Never touch the muffler guard.
MODEL Y4007 MINI CULTIVATOR AND DETHATH ER SAFETY DECAL Garden Trax is a leading manufacturer of outdoor power equipment. This unit had been designed and manufactured with your safety in mind. It has been manufactured with all the reliability you expect from an industry leader. Please read this manual in order to gain the necessary knowledge to operate this unit safely and effec vely.
MODEL Y4007 MINI CULTIVATOR AND DETHATHER UNPACKING & ASSEMBLY Unpack your unit by carefully li ing it out of its container. Remove any packing material and cut any plas c es holding the handlebar pieces to the rest of the assembly Y4000.02.01 ASSEMBLY Stand the mini cul vator assembly upright with nes and wheels on a level surface. Wheels should be set in the lowest posi on. DO NOT place the mini cul vator on a high surface where it can fall and cause property damage or personal injury 2.
MODEL Y4007 MINI CULTIVATOR AND DETHATH ER OPERATION OF UNIT STEPS FOR WORKING ON ENGINE OR UNIT ● ● ● ● ● ● Turn off engine switch Disconnect the spark plug wire from spark plug Securely place the disconnected spark plug wire safely away from the spark plug and any metal parts.
MODEL Y4007 MINI CULTIVATOR AND DETHATHER OIL CHANGE After each 10 hours of use, please check the oil in the crankcase and add as needed； Drain the used oil while the engine is warm. Warm oil drains quickly and completely 1. Place a suitable container below the engine to catch the used oil 2. Remove the oil filler cap/dip 3. Tip the ller to drain the used oil through the oil filler opening.
MODEL Y4007 MINI CULTIVATOR AND DETHATHER IMPORTANT! FUEL AND FUEL VAPORS ARE HAZORDOUS AND HIGHLY FLAMMABLE.
MODEL Y4007 MINI CULTIVATOR AND DETHATHER WARM ENGINE STARTING 1. Move the Choke Lever to the Choke posi on NOTE: Choke position is defined as moving the lever to the farest Choke position possible 2. Con nue by repea ng Cold Engine Star ng beginning with Step 4 HOT ENGINE STARTING 1. Begin with Step 4 of Cold Engine Star ng 2.
MODEL Y4007 MINI CULTIVATOR AND DETHATHER MAINTENANCE STEPS FOR WORKING ON EQUIPMENT 1. Make sure engine switch is in the off posi on 2. Disconnect the Spark Plug wire from the Spark Plug 3. Secure the Spark Plug wire away from the Spark Plug itself and other metal parts. Make sure this is done to prevent wire from arching with Plug 4. Replace or repair parts on your unit 5.
MODEL Y4007 MINI CULTIVATOR AND DETHATHER KEEPING THE AIR FILTER CLEAN Never run engine without air cleaner properly installed. Added wear and engine failure may occur if air cleaner is not installed on engine Service air cleaner every 3 months or er 20 hours of oper n Clean filter daily in extremely dusty cond ons STEPS FOR CLEANING RING STYLE FOAM AIR FILTER 1. Wash in warm water with liquid detergent un irt and debris are removed. Press or squeeze filter when cleaning... DO NOT TWIST 2.
MODEL Y4007 MINI CULTIVATOR AND DETHATHER SPARK PLUG THE RECOMMENDED SPARK PLUG FOR THIS UNIT IS A5RTC NGK Equivalent plug number CR5HSA 1. Always check the Spark Plug at the beginning of each season 2. Disconnect Spark Plug Cap and clean any debris or dirt from around the Spark Plug area 3. Exam the Spark Plug and replace if any of the following have occurred: a. P ed Electrodes b. Burned Electrodes c. Cracked Porcelain d. Or Deposits around Spark Plug 4.
MODEL Y4007 MINI CULTIVATOR AND DETHATHER ADJUSTING WHEELS The wheels on the mini cul vator can be adjusted into two height po ons (SEE FIGURE 11) 1. To adjust the wheels, pull the detent pin out of the rear mounted plas parts mount hole 2.
MODEL Y4007 MINI CULTIVATOR AND DETHATHER TRANSPORTING YOUR UNIT 1. A er using your mini cul vator, always allow the unit to cool off before transpor ng. Never transport the unit in an enclosed space within a vehicle as fumes and vapors may build up. They could ignite and cause serious injury or death 2. If fuel is present in fuel tank, always transport in an open vehicle in an upright po on 3.
MODEL Y4007 MINI CULTIVATOR AND DETHATHER TROUBLE SHOOTING Here at Garden Trax,we strive to build the most durable and best quality designed products. However, all the hard work and best designs and all the careful maintenance on your part will never assure you that there will never be a problem. Even the small repair can be annoying. So we have prepared a troubleshooting guide to help you through most of these easily fixed repairs.
MODEL Y4007 MINI CULTIVATOR AND DETHATHER Y4007 HANDLEBAR STRUCTURE PARTS DRAWING & PARTS LIST 1 1 3 5 14 7 2 8 6 10 4 9 11 5 6 7 6 12 KEY PART # DESCRIPTION QTY. 1 Y4000.02-05 GRIP,HANDLEBAR 2 2 Y4000.02-04A HIS RIGHT HAND 1 BOLT,PHILLIPS TRUSS HD ZN 10-24x1-1/4 1 3 4 Y4000.02-03A HIS LEFT HAND 1 5 Y4000.02.01 NUT，T-HANDLE 6 6 WASHER 8 7 BOLT，HANDLE CLAMP 6 8 Y43.03A TRIGGER ASSEMBLY,LONG THROW W/O CABLE 1 9 Y4000.07 THROTTLE CABLE 1 10 Y4000.
MODEL Y4007 MINI CULTIVATOR AND DETHATHER HOOD AND TINES PARTS LIST AND DRAWING 1 5 22 3 6 2 7 4 8 13 9 20 10 14 16 5 21 9 11 12 20 10 4 3 22 16 15 16 17 17 15 19 20 19 18 KEY PART # DESCRIPTION QTY. KEY PART # DESCRIPTION QTY. 1 Y4000.01 140FA ENGINE 1 15 Y4000.06-01 TINE SHIELD 2 Y4000.03 TRANSMISSION ASSEMBLY 1 16 GB5787 BOLT M5 X 10mm FLANGED HEX HD 2 3 GB 97.1 WASHER 10 2 17 GB97.1 WASHER 5 2 4 Y4000.
MODEL Y4007 MINI CULTIVATOR AND DETHATHER TRANSMISSION PARTS DRAWING AND PARTS LIST 2 3 1 4 5 6 14 8 9 7 10 16 11 16 15 12 13 11 10 18 17 19 20 17 KEY PART # 18 21 5 DESCRIPTION 22 23 QTY. KEY PART # DESCRIPTION QTY. 1 Y4000.03 TRANSMISSION ASSEMBLY 1 14 Y4000.03-02 TRANSMISSION CASTING，RIGHT 1 2 GB/T6174 NUT，JAM M8 1 15 Y4000.03-01 TRANSMISSION CASTING，LEFT 1 3 Y4000.03.01 CLUTCH DRUM 1 16 GB5787 6 1 17 Y4000.
MODEL Y4007 MINI CULTIVATOR AND DETHATHER ENGINE PARTS DRAWING 1 3 2 5 6 7 8 4 15 1 10 9 11 14 17 16 13 18 20 21 22 12 24 36 30 31 1 33 32 34 1 23 35 25 26 27 5 32 28 40 30 30 37 38 19 29 1 28 39 40 42 41 TOLL FREE HELP LINE 1 855 691 5969 22
MODEL Y4007 MINI CULTIVATOR AND DETHATHER ENGINE PARTS LIST KEY PART # DESCRIPTION QTY. KEY PART # DESCRIPTION QTY.
MODEL Y4007 MINI CULTIVATOR AND DETHATHER PLEASE TAKE THE NEXT STEP TO REGISTER YOUR PURCHASE BY COMPLETING THE ENCLOSED WARRANTY CARD AND MAILING THE CARD TO THE FOLLOWING ADDRESS: PO BOX 145，115 N. Prentice Street, Clayton WI 54004 OR BY GOING TO WWW.THUNDERBAYPROCUCTS.COM WEBSITE AND FINDING THE WARRANTY ICON. CLICK ON THE WARRANTY ICON TO REGISTER YOUR PURCHASE. EC DECLARATION OF CONFORMITY MANUFACTURERS BUSINESS NAME: SOURCE ONE INTERNATIONAL LIMITED MANUFACTURERS ADDRESS: NO.
