Battery - Safety Data Sheet

ManualsBrandsGenerac ManualsSkid mounted140kW (Prime) / 155kW (Standby) Skid-Mount Diesel Generator (John Deere Engine) w/ Single-Axle Trailer

PS-HTR-ST-43-E_PS-HTR-ST-43-E_Lead Acid Battery SDS Standard SDS US

Version #: 08 Issue Date: 04/01/2015 Revision Date: 08/13/2019 1 of 10

Safety Data Sheet

1. IDENTIFICATION

Product Name: Lead Acid Battery

Synonyms: SLI Battery

Product Use: Vehicle Electrical System

Manufacturer/Supplier: Clarios

Address: Florist Tower

5757 N. Green Bay Avenue

Milwaukee, WI 53209 US

General Information Number: (800)-333-2222 ext. 2267

Contact Person: Industrial Hygiene & Safety Department

Emergency number: CHEMTREC: 800-424-9300 (For US &

Canada use only)

NOTE: The Clarios sealed cell/battery is considered an article as defined by 29 CFR 1910.1200 (OSHA Hazard

Communication Standard). The information contained in this SDS is supplied at the customer’s request for

information only.

2. HAZARD(S) IDENTIFICATION

Health

Environmental

Physical

Acute Toxicity (Oral, dermal,

inhalation)

Category 4

Aquatic Chronic 1

Aquatic Acute 1

Explosive Chemical, Division 1.3

Skin corrosion/irritation

Category 1A

Eye Damage

Category 1

Reproductive

Category 1A

Carcinogenicity (lead)

Category 1B

Carcinogenicity (acid mist)

Category 1A

Specific target organ toxicity

(repeated exposure)

Category 2

Label Elements:

Health

Environmental

Physical

Hazard Statements

DANGER!

Causes severe skin burns and eye damage. Causes

serious eye damage.

May damage fertility or the unborn child if

ingested or inhaled.

May cause cancer if ingested or inhaled.

Causes damage to central nervous system, blood

and kidneys through prolonged or repeated

exposure.

May form explosive air/gas mixture during

charging.

Precautionary Statements

Wash thoroughly after handling.

Do not eat, drink or smoke when using this product.

Wear protective gloves/protective clothing, eye protection/face protection.

Avoid breathing dust/fume/gas/mist/vapors/spray.

Use only outdoors or in a well-ventilated area.

Causes skin irritation, serious eye damage.

Contact with internal components may cause irritation or severe burns. Avoid

contact with internal acid.

Irritating to eyes, respiratory system, and skin.

Summary of content (10 pages)

PAGE 1
Safety Data Sheet 1. IDENTIFICATION Product Name: Lead Acid Battery Synonyms: SLI Battery General Information Number: (800)-333-2222 ext. 2267 Contact Person: Industrial Hygiene & Safety Department Product Use: Vehicle Electrical System Manufacturer/Supplier: Clarios Address: Florist Tower 5757 N. Green Bay Avenue Milwaukee, WI 53209 US Emergency number: CHEMTREC: 800-424-9300 (For US & Canada use only) NOTE: The Clarios sealed cell/battery is considered an article as defined by 29 CFR 1910.
PAGE 2
Extremely flammable gas (hydrogen). Explosive, fire, blast or projection hazard. 3. COMPOSITION / INFORMATION ON INGREDIENTS INGREDIENTS (Chemical/Common Names): Lead Lead Oxide Sulfuric Acid Lead Sulfate Composition Comments CAS No.: 7439-92-1 1309-60-0 7664-93-9 7446-14-2 % by Wt: 34 31 34 <1 All concentrations are in percent by weight. 4. FIRST AID MEASURES Note: Under normal conditions of battery use, internal components will not present a health hazard.
PAGE 3
Protective Measures to be Taken if Material is Released or Spilled Waste Disposal Method Stop flow of material, contain/absorb small spills with dry sand, earth, and vermiculite. Do not use combustible materials. If possible, carefully neutralize spilled electrolyte with soda ash, sodium bicarbonate, lime, etc. Wear acid-resistant clothing, boots, gloves, and face shield. Do not allow discharge of un-neutralized acid to sewer.
PAGE 4
Lead Oxide Sulfuric Acid 1309-60-0 7664-93-9 TWA TWA International Exposure Limits (mg/m3) *Chemical & Common Name Quebec PEV Lead and Lead Compounds (inorganic) 0.05 Electrolyte (H2SO4/H2O) 1 (a) As inhalable aerosol (b) Thoracic fraction Biological limit values ACGIH Biological Exposure Indices Ingredient Lead Lead Oxide Lead Sulfate Value 300 µg/l 300 µg/l 300 µg/l 0.05 mg/m³ 1 mg/m³ Ontario OEL 0.05 0.2 Determinant Lead Lead Lead EU OEL 0.15 (a) 0.
PAGE 5
Evaporation Rate (Butyl Acetate = 1) Vapor Pressure (mm Hg @ 20 ° C) Flammability Upper/lower flammability or explosive limits <1 Vapor Pressure Vapor Density Relative Density Solubility Not applicable. 3.4 (Air = 1) Battery Electrolyte (Acid) 1.21 - 1.3 Battery Electrolyte (Acid) Lead and Lead dioxide are not soluble. 100 % Battery Electrolyte (Acid). Not applicable unless individual components exposed.
PAGE 6
Sulfuric Acid: Severe irritation, burns and ulceration. Lead Compounds: Not absorbed through the skin. Skin Absorption EXPOSURE IS NOT EXPECTED FOR PRODUCT UNDER NORMAL CONDITIONS OF USE. In the event of overcharging or damage to the unit, exposure to organic electrolyte solution/mist is possible. Extreme exposures to the organic electrolyte can be absorbed through the skin. Eye Contact EXPOSURE IS NOT EXPECTED FOR PRODUCT UNDER NORMAL CONDITIONS OF USE.
PAGE 7
Lead Compounds: Lead is listed as a Group 2A- carcinogen, likely in animals at extreme doses. Per the guidance found in OSHA 29 CFR 1910.1200 Appendix F, this is approximately equivalent to GHS Category 1A. Proof of carcinogenicity in humans is lacking at present. IARC Monographs. Overall Evaluation of Carcinogenicity Lead (CAS 7439-92-1) 2A Probably carcinogenic to humans. Lead oxide (CAS 1309-60-0) 2A Probably carcinogenic to humans. Lead sulfate (CAS 7446-14-2) 2A Probably carcinogenic to humans.
PAGE 8
49 CFR 173.
PAGE 9
Lead Sulfate (CAS 7446-14-2) Acute toxicity Reproductive toxicity Central nervous system Kidney Blood Acute toxicity EPA SARA Title III Section 302 EPCRA Extremely Hazardous Substances (EHS): Sulfuric acid is a listed "Extremely Hazardous Substance" under EPCRA, with a Threshold Planning Quantity (TPQ) of 1,000 lbs. EPCRA Section 302 notification is required if 500 lbs. or more of sulfuric acid is present at one site (40 CFR 370.10). For more information consult 40 CFR Part 355.
PAGE 10
Lead Oxide (CAS 1309-60-0) Lead Sulfate (CAS 7446-14-2) Sulfuric acid (CAS 7664-93-9) US Pennsylvania Worker and Community Right-to-know Law Lead ( CAS 7439-92-1) Sulfuric acid (CAS 7664-93-9) US Rhode Island RTK Lead ( CAS 7439-92-1) Lead Oxide (CAS 1309-60-0) Lead Sulfate (CAS 7446-14-2) Sulfuric acid (CAS 7664-93-9) US. California Proposition 65 WARNING: This product contains chemicals known to the State of California to cause cancer.