Spec Sheet

ManualsBrandsGillette ManualsIndustrial Equipment210/350kW 3 Phase Gas Standby Generator

Gillette Generators, Inc. •

••

•2921 Thorne Dr. •Elkhart, IN • 46514 • Ph: 574-264-9639 • Fax: 574-262-1840 • Web: www.gillettegenerators.com • spc4-180810

60 HZ MODEL

SP-3500

All generator sets are USA prototype built and thoroughly tested.

Production models are USA factory built and 100% load tested.

UL2200, UL1446, UL508, UL142, UL498

NFPA 110, 99, 70, 37

All generator sets meet NFPA-110 Level 1, when equipped with the

necessary accessories and installed per NFPA standards.

NEC 700, 701, 702, 708

NEMA ICS10, MG1, ICS6, AB1

ANSI C62.41, 27, 59, 32, 480, 40Q, 81U, 360-05

ASCE 7-05 & 7-10

All generator sets meet 180 MPH rating.

EPA 40CFR Part 60, 1048, 1054, 1065, 1068

RATINGS: All three phase gen-sets are 12 lead windings, rated at .8 power factor. 120

C “STANDBY RATINGS” are strictly for gen-sets that are used for back-up

emergency power to a failed normal utility power source. This standby rating allows varying loads, with no overload capability, for the entire duration of utility power

outage. All gen-set power ratings are based on temperature rise measured by resistance method as defined by MIL-STD 705C and IEEE STD 115, METHOD 6.4.4. All

generators have class H (180°C) insulation system on both rotor and stator windings. All factory tests and KW/KVA charts shown above are based on 120°C (standby) R/R

winding temperature, within a maximum 40°C ambient condition. Generators operated at standby power ratings must not exceed the temperature rise limitation for class H

insulation system, as specified in NEMA MG1-22.40. Specifications & ratings are subject to change without prior notice.

LIQUID COOLED NAT. GAS ENGINE GENERATOR SET

GENERATOR RATINGS

LIQUID PROPANE GAS FUEL NATURAL GAS FUEL

GENERATOR MODEL

VOLTAGE

PH HZ

120°

°°

°C RISE STANDBY RATING 120°

°°

°C RISE STANDBY RATING

L-N L-L KW/KVA AMP KW/KVA AMP

SP-3500-3-2

120 208 3 60 260/325 903 350/438 1216

SP-3500-3-3

120 240 3 60 260/325 782 350/438 1054

SP-3500-3-4

277 480 3 60 260/325 391 350/438 527

SP-3500-3-5

127 220 3 60 260/325 854 350/438 1150

SP-3500-3-16

346 600 3 60 260/325 313 350/438 421

“OPEN” GEN-SET

There is no enclosure, so gen-set must be

placed within a weather protected area,

un-inhabited by humans or animals, with

proper ventilation. Silencer not supplied,

as installation requirements are not

known. However, this item is available as

optional equipment.

“LEVEL 2” HOUSED GEN-SET

Full aluminum weather protection and superior

sound attenuation for specific low noise

applications. Critical grade muffler is standard.

Model

STANDBY

120ºC RISE

HZ LPG N.G.

3500

60 HERTZ

60 260 350

Summary of content (4 pages)

PAGE 1
60 HZ MODEL SP-3500 LIQUID COOLED NAT. GAS ENGINE GENERATOR SET STANDBY Model 120ºC RISE SP-3500-60 HERTZ HZ LPG N.G. 60 260 350 All generator sets are USA prototype built and thoroughly tested. Production models are USA factory built and 100% load tested. “OPEN” GEN-SET UL2200, UL1446, UL508, UL142, UL498 NFPA 110, 99, 70, 37 All generator sets meet NFPA-110 Level 1, when equipped with the necessary accessories and installed per NFPA standards.
PAGE 2
APPLICATION AND ENGINEERING DATA FOR MODEL SP-3500-60 HZ GENERATOR SPECIFICATIONS GENERATOR FEATURES Manufacturer ................................... Stamford Electric Generators Model & Type .......... S4L1DF-311, 4 Pole, 12 Lead, Three Phase ...................... S4L1DE-311, 4 Pole, 12 Lead, 480V, Three Phase .........................HCI434E-17, 4 Pole, 6 Lead, 600V, Three Phase Exciter ..................................................... Brushless, shunt excited Voltage Regulator ....................
PAGE 3
APPLICATION AND ENGINEERING DATA FOR MODEL SP-3500-60 HZ COOLING SYSTEM Type of System ................................ Pressurized, closed recovery Coolant Pump .....................................Pre-lubricated, self-sealing Cooling Fan Type (no. of blades) ................................. Pusher (8) Fan Diameter inches (mm)........................................... 52" (1321) Ambient Capacity of Radiator °F (°C) .......................... 125 (51.6) Engine Jacket Coolant Capacity Gal (L) .............
PAGE 4
STANDARD FEATURES FOR MODEL SP-3500-60 HZ STANDARD FEATURES CONTROL PANEL: Deep Sea 7420 digital microprocessor with logic allows programming in the field.