SOURCE LISTING SOURCE LISTING Source listing for water heater technical questions. FOR USE BY SEARS PERSONNEL ONLY. SOURCE UMBER SOURCE PHONE EMAIL ID 153 STATE INDUSTRIES, INC. 1-800-285-8170 500 LINDA PARKWAY ASH LAND CITY, TN 37018 William Cassidy National Merchandise Manager ext. 8338 boassidy@hotwater com Steve Maxes National Technical Sales Manager ext. 6215 intercommunicate dir Footlocker YP Retail Sales ext.
GUIDE TC INFORMATION GUIDE TO INFORMATION GENERAL WATER HEATER KNOWLEDGE Guide To Information | Discover The Costume Sizing Guide ELECTRIC WATER HEATERS Electric Water Heater Features Electric Water Heater Sizes and Dimensions Kenmore" Specialty Compact Electric Water Heaters Kenmore” Specialty Table Top Electric Water Heater Power Miser & Electric Water Healers Power Miser 9 Electric Water Heat Power Miser 12 Electric Water Heaters Duabwait™ Convertible Elements Water Heater Typical Installation Electric W
DISCOVERY QUESTIONS DISCOVER THE WATER HEATER CUSTOMER'S NEEDS CORRECT TANK SIZE AND INPUT TO PROVIDE ENOUGH USABLE HOT WATER TO FIT THE CUSTOMERS’ NEEDS CAN BE QUICKLY DETERMINED BY ASKING A FEW SIMPLE QUESTIONS. B TYPE OF FUEL? ELECTRIC: VOLTS/WATTS? 120V (1700 « = {Over 2000 Watts) = Residential Tall & Shorts GAS: NATURAL or PROPANE(LP)? MOBILE HOME? NATURAL = Residential All Series.
SIMPLIFIED SIZING GUIDE SELL ENOUGH HOT WATER! CAPACITY IS NOT THE ONLY ANSWER! HEAT INPUT COUNTS! SIMPLIFIED SIZING GUIDE IMPORTANT: When sizing a new water heater for your customer, it is important to remember that all water heaters of the same capacity are nol created equally and do not perform equally. The Simplified Sizing Guide recommends the minimum tank capacity and input of the water heater necessary to satisfy a typical family's hot Walter requirements.
ELECTRIC FEATURES ELECTRIC WATER HEATER COMMON FEATURES A. FACTORY INSTALLED TEMPERATURE AND PRESSURE RELIEF VALVE. LONG-LIFE BAKED ENAMEL FINISH. GLASS LINED STEEL TANK. ANODE ROD IN GLASS-LINED TANKS helps prevent corrosion caused by electrolytic action. THERMOSTAT WITH AUTOMATIC SAFETY cut-off shuts power of thermostat falls. F. REPLACEABLE SCREW-IN IMMERSION TYPE HEATING ELEMENTS. Available in single and dual element models, NON-CORROSIVE HIGH TEMPERATURE COLD WATER INLET TUBE.
ELECTRIC SIZES AND DIMENSIONS ELECTRIC WATER HEATER SIZES AVAILABLE DUALWATT™ 31803 22633 GALWATT™ 31812 EEE 52558 at DUAL WATT elements can be easily converted from 3800W to S3500W operation using parts and instructions included; if the customers wiring and fusing permit. NOTE: IN MOST OLDER WATER HEATERS THE “HOT” SETTING WAS APPROXIMATELY 140°, TODAY'S HOT” SETTING 18 APPROXIMATELY 1207. IF THE NEW WATER HEATER IS OPERATED AT 120°, A LARGER 1ZE Will BE NEEDED.
ELECTRIC COMPACTS KENMORE SPECIALTY COMPACT ELECTRIC WATER HEATER # 6 YEAR LIMITED TANK WARRANTY 1 YEAR PARTS WARRANTY 1 YEAR EXCLUSIVE KENMORE LABOR WARRANTY #& Cobalt Blue Lira Coat™ Glass Lined tank with a single anode rod for tank protection. 2" of ENERGY EFFICIENT FOAM INSULATION (R-Value 16.
ELECTRIC TABLE TOPS ~t KENMORE TABLE TOP ELECTRIC WATER HEATER # 6 YEAR LIMITED TANK WARRANTY 1 YEAR PARTS WARRANTY 1 YEAR EXCLUSIVE KENMORE" LABOR WARRANTY ® Co ball Blue Ultra Coat™ Glass Lined tank with a single anode rod for tank protection #2 of ENERGY EFFICIENT FOAM INSULATION (R-Value 16.00) + LIMEGUARD™ ELEMENT low watt density, Zinc coated copper; resists lime build-up. Lasts longer than dad elements # DUALWATT™ ELEMENT: EASILY CONVERTS from 3800 watt to S500 watt.
ELECTRIC POWER MISER & KENMORE POWER MISER 6 ELECTRIC WATER HEATER ® & YEAR LIMITED TANK AND PARTS WARRANTY 1 YEAR EXCLUSIVE KENMORE" LABOR WARRANTY ® Cobalt Blue Ultra Coat" Glass Lined tank with a single anode rod for internal tank protection, ® of ENERGY EFFICIENT FOAM INSULATION {R-Value 16.00) ® TWO ELEMENTS... lower handles normal needs while the upper element responds 10 heavy demands. ® LIFEGUARD" ELEMENTS... low watt density, zinc coated copper; resist lime build-up.
ELECTRIC POWER MISER 9 Factory set for 3800 watt operation, require: per hour of recovery at a 90° temperature ri KENMORE POWER MISER 9 ELECTRIC WATER HEATER @ 9 YEAR LIMITED TANK AND PARTS WARRANTY 1 YEAR EXCLUSIVE KENMORE LABOR WARRANTY @ Cobalt Blue Ultra Coat™ Glass Lined tank with one large anode rod for increased internal tank protection. © 21/2" of ENERGY EFFICIENT FOAM INSULATION (R-Value 20.0) ® TWO ELEMENTS... lower handles normal needs while the upper element responds to heavy demands.
ELECTRIC POWER MISER 12 KENMORE POWER MISER 12 ELECTRIC WATER HEATER @ 12 YEAR LIMITED TANK AND PARTS WARRANTY 1 YEAR EXCLUSIVE KENMORE LABOR WARRANTY @ Cobalt Blue Ultra Coat™ Glass Lined tank with two large anode rods for superior internet tank protection. © 3 of ENERGY EFFICIENT FOAM INSULATION (R-Value 24.0) £30 Gallon, 2 1/27 of Foam insulation, B-Value 20.0} e TWO ELEMENTS... lower handles normal needs while the upper element responds 10 heavy demands & SUPER DISGRUNTLEMENT: last longer...
SEARS DUALWATT™ CONVERTIBLE ELEMENTS i SEARS DUALWATT™ CONVERTIBLE ELEMENTS Sears DUALWATT™ convertible tower heating elements are standard on all Power Miser 6. Power Miser 9 and Power Miser 12 electric water heaters In the lower element position and on the Kenmore® 6 Table Top models.
12 LYRICAL ELECTRIC WATER HEATER INSTALLATION TYPICAL ELECTRIC WATER HEATER INSTALLATION VACUUM WATER COLD WATER RELIEF VALVE PRESSURE SUPPLY LINE {Required By Some Local Codes) GAUGE THERMAL EXPANSION TANK (Required By Many Lora! Codes) PRESSURE REDUCING VALVE {Used Where Incoming Water Pressure Exceeds 80 Psi.
ELECTRIC TROUBLE SHOOTING ELECTRIC TROUBLESHOOTING CUSTOMER SAYS: ELECTRIC WATER HEATERS HEATER LEAKS WATER CHECK FOR CONDENSATION: Condensate heater arid give the appearance of a lak.
SELF CLEANING ROTO-8WIRL™ The Self Cleaning Bears” Self Cleaning Root-Swirl cold water inlet tube features multiple water outlet jets that automatically create a self cleaning turbulence in the bottom of the wale heater tank every time a hot water faucet is opened. Minerals will normally precipitate out of a water supply when it is heated.
COBALT BLUE ULTRA COAT” Cobalt Blue Trait Coat” Glass Lining Provides 58% Better internal Tank Protection Than Standard | | Glass Lining! | Ee i Cobalt Bue Ultra Coat™ Glass Lining & Self-Cleaning Electric Water Heater Self-Cleaning Gas Water Healer
16 C3 TECHNCLOGY™ GAS WATER HEATERS KENMORE" FLAMMABLE VAPOR IGNITION RESISTANT C3 TECHNOLOGY" GAS WATER METERS INT, The Cordite Combustion Containment {C3) design meets American National Standards ES institute standards (ANS 221.10.) that deal with the accidental or unintended ignition of flammable vapors, such as those emitted by gasoline. Covered by four U.S.
GAS FEATURES ~t GAS WATER HEATER COMMON FEATURES FACTORY INSTALLED TEMPERATURE AND PRESSURE RELIEF VALVE DRAFT DIVERTED helps insure proper venting of combustion gases LONG-LIFE BAKED ENAMEL FINISH. GLASS LINED TANK. ANODE HOD IN GLASS-LINED TANKS helps prevent corrosion caused by electrolytic action. THERMOSTAT WITH AUTOMATIC SAFETY cut-off shuts power off i thermostat fails, or if pilot fame goes out. EASY ADJUSTMENT KNOB H. NON-CORROSIVE HIGH TEMPERATURE COLD WATER INLET TUBE. I.
GAS SIZES AND DIMENSIONS 30 Hart 30 Gallon 441 Short 43 Gallon 40 Gallon Power Vent 50 Short 50 Gallon 48 Gallon 50 Ga lion Power vent; 65 Gallon 75 Gallon High Secy, GAS WATER HEATER SIZES AVAILABLE Standard Standard High AIL Mobile Hume Standard High Alt Standard High Alt, Mobile Hume Standard High AlL Standard High Alt Standard High AlL High Feces, Standard High Alt, Standard High Alt, High Hay, Standard h Alt # Tha ONLY f gas motels 33384 # 33384 4 33620 33676 EE ir S640 33686 33680 33996 3144 33141 332
GAS POWER MISER 6 @ (3 {R-Value 8 # Root § 00) KENMORE POWER MISER & GAS WATER HEATER # © YEAR LIMITED TANK AND PARTS WARRANTY 1 YEAR EXCLUSIVE KENMORE" LABOR WARRANTY ® 35.500 Btu Hour Input, 35.
GAS POWER MISER 8 KENMORE POWER MISER 9 GAS WATER HEATER & 0 YEAR LIMITED TANK AND PARTS WARRANTY 1 YEAR EXCLUSIVE KENMORE" LABOR WARRANTY & 40,000 Houri Input, 39.8 GPH Recovery Hale {40 Gallon) 12.7% faster heating of water than our Power Miser 8 Series ® (38 Technology” Sealed Combustion Chamber & Cobalt Lee Ultra Coal” Glass Lined tank with one large anode rod for superior internal tank protection & "of ENERGY EFFICIENT FOAM INSULATION HF-Value 8.
GAS POWER MISER 12 21 KENMORE POWER MISER 12 HIGH PERFORMANCE GAS WATER HEATER & 12 YEAR LIMITED TANK AND PARTS WARRANTY 1 YEAR EXCLUSIVE KENMORE" LABOR WARRANTY # 40,000 Birdhouse Input, 48.0 GPH Recovery Rate [40 Gallon} 16% faster heating of water than ow Powers Miser § Series # (03 Technology™ Sealed Combustion Bernbach # Cobalt Blue Ultra Coat™ Glass Lined tank with two large anode rads for superior internal tank protection. ® 27of ENERGY EFFICIENT FOAM INSULATION {R-Value 16.
GAS MOBILE HOME KENMORE MOBILE HOME GAS WATER HEATER @ 6 YEAR LIMITED TANK WARRANTY 1 YEAR PARTS WARRANTY 1 YEAR EXCLUSIVE KENMORE" LABOR WARRANTY % Cobalt Blue Ultra Coat™ Glass Lined tank with two large anode rods for superior internal tank p cation. @ 2 of ENERGY EFFICIENT FOAM INSULATION (R-Value 16.00} CONVERTS FROM NATURAL TO PROPANE (LP) GAS... all necessary parts and instructions Included.
POWER VENT KENMORE POWER VENT GAS WATER HEATER REQUIRES NO CHIMNEY. ., VENTS THROUGH THE WALL! Parfait for conversion from electric to gas water healing and where highly energy efficient fum aces are used. Energy saving, Hot Surface Ignition System... No standing pilot! No chimney required... Vents through outside wall or roof. nets up to 115 feet using 37 PVC, CFC or ABS Schedule 40 pipe feet using 27 vent pipe option. Equipped with draft hood, hi-limit cut-off with manual reset and positive draft sensor.
24 POWER VENT KENMORE POWER VENT GAS WATER HEATER The Power Venn is designed to use Schedule 40 PVC, PVC or ABS pipe installation with 7 clearance from combustible materials. This permits many venting options when the following requirements are observed... VENTING SYSTEM REQUIREMENTS # The water heater must have an independent vent system from the water heater to the exterior of the building. # Ranting CANNOT be connected to existing vent pips or chimney.
COMMERCIAL GAS WATER HEATERS 83 © KENMORE COMMERCIAL GAS WATER HEATERS #3 YEAR LIMITED TANK WARRANTY 1 YEAH LIMITED PARTS WARRANTY © Glass lined steal tank... for protection against corrosion ® Anode rod... provides electrolytic protection for longer tank fife ® Energy Efficient Foam Insulation... helps keep the water hot # 1B0°F Thermostat... for applications where higher water temperatures may be required # Non-Electric control system...
26 TYPICAL GAS WATER HEATER INSTALLATION TYPICAL GAS WATER HEATER INSTALLATION VACUUM WATER COLD WATER RELIEF VALVE PRESSURE SUPPLY LINE EXPANSION TANK (Required By Many Lora Odes) PRESSURE REDUCING VALVE {Nude Whore incoming Water Bros sure Exceeds 80 Phil} {(Herodotus By Many Loos Codes) DRAIN PAN > ware Heaven stein {as Water Heaters May Be Required Yo So Waterbed 18” Above Flo er Level To Comply With Local Or National Fuel tia Code.
83 ~i GAS TROUBLESHOOTING GAS TROUBLESHOOTING GAS WATER HEATERS CUSTOMER BAYS: HEATER LEAKS WATER CHECK FOR CONDENSATION: When large amounts of cold water are in the tank (such as at installation} condensation may farm on 1 tank and fn fo the bottom pan or floor. This normally stops wit 2 of tare is probably undersized.
28 ELEMENT TYPES TYPE OF ELEMENTS High watt density; zine coated copper, USED ON: THE ECONOMIZER 6 TALL, SHORT AND COMPACTS. LIMEGUARD™ ELEMENT... 8 Low watt density, 3 Zinc coated copper, resists time buildup for longer fife and maintained efficiency. USED OM: POWER MISER 6 SERIES IN THE UPPER ELEMENT Position AND FOR REPLACE LIMEGUARD™ WATT" ELEMENT... Low watt density; zine coated copper, resists lire buildup for finger life and maintained efficiency.
ACCESSORIES o UNIVERSAL REPLACEMENT PARTS Fit Kenmore and most other brands. 1901 9000139 ETHEL 0260 31508 GODOT 31606 00048 31908 GORGE UMEGUARD™ SUPER-LIMEGUARD™ SUPBR-LIMEGUARD i™ 42605 5 3800 watts? ELEMENT ELEMENT ELEMENT pr {1 Threads) {1 Threats) {4 3/8 Threads} 3500 wa lie fie 21917 jo) necklaces 31911 318 U1 Tower Thermostat 4 {Used on men water | Replaces 3113 ® lead models) 030 swat Boa 910) or love when strength st end WATER HEATER STAND, EE EE SR0425 (2 142) DRAIN BAN...
ACCESSORIES 31924 Electric.
THERMAL EXPANSION 31 THERMAL EXPANSION AND WEEPING TEMPERATURE AND PRESSURE RELIEF VALVES As water is heated it expands, if this expansion takes place within a confined space pressure creases. in the past several years, certain things have occurred which have effectively “closed” the water systems in many homes leaving little or no room for the water to expand when heated by the water heater. ® New water maters contain a check valve to prevent back flow of water rio the mai.
GLOSSARY AND SEARS WARRANTIES WATER HEATER WARRANTIES Sears warranties are different... parts tank and installation are covered for the first year. most competitive warranties cover only parts and tank... not the installation costs of replacing a leaking tank during the first year. For example, The Power Miser 3 warranty is shown below. The actual warranty can be found on the back of the owner's manual.
COMMONLY ASKED QUES 33 ANSWERS TO SOME COMMONLY ASKED QUESTIONS Where can § find answers to questions concerning water heaters? BE Water Heater ML Book BO 1-800-877-8420 Water Heater Sales Center B E-Learning Where can need a merchandise list book or water heater tear pad? B POW ML Book 3442 Tear Pad 3443 Where can § find answers fo questions concerning merchandise protection agreements? B 1-800-767-2000 Where can | find information about choosing the resonator water heater for my customer? BE ML Book What