Homeowners Guide Bath Whirlpool K-870, K-872 1019486-5-A
Operating Instructions INSTRUCTIONS PERTAINING TO A RISK OF FIRE, ELECTRIC SHOCK, OR INJURY TO PERSONS READ AND FOLLOW ALL INSTRUCTIONS Use this whirlpool only for its intended purpose as described in this manual. Do not use attachments not recommended by the manufacturer. WARNING: When using electrical products, basic precautions should always be followed, including the following: DANGER: Risk of personal injury.
Table of Contents Thank You . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Your Kohler Whirlpool . . . . . . . . . . . . . . . . . . . . . . . . . User Keypad & Whirlpool Modes/Features . . . . . . . . Optional Remote Control . . . . . . . . . . . . . . . . . . . . . . . Operating Your Whirlpool . . . . . . . . . . . . . . . . . . . . . . Care and Cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . . . Warranties -- U.S.A. and Canada . . . . . . . . . . . . . . . .
The bath provides a reservoir for the hydro-massage action The user keypad allows you to turn the whirlpool and heater on and off and regulate the water flow Adjustable jets allow you to adjust the air and water flow and direction NOTE: Bath shown for illustrative purposes. Your bath model may vary.
Heater On/Off Heater Indicator Light Turn the jet trim ring clockwise to decrease the flow Increases Flow Indicator Bar-Shows water flow volume Power On/Off Decreases Flow Turn the jet trim ring counterclockwise to increase the flow Lighted User Keypad User Keypad and Whirlpool Modes/Features S S S S Power- Turns the whirlpool pump on and off. S Indicator Bar- Shows the water flow volume. Up Arrow- Increases the water flow. Down Arrow- Decreases the water flow.
Care and Cleaning Instructions Cleaning Your Kohler Cast Iron Whirlpool - Rinse the whirlpool thoroughly after each use and use a soft cloth to wipe it dry. If the surface becomes dirty, use a general purpose cleaner such as Scrub FreeR Mildew Stain Remover, Clorox Clean-UpR, Glass PlusR, WindexR Original, FantasticR All Purpose, Mr. Clean Top Job, Formula 409R All Purpose, LysolR Basin, Tub & Tile Cleaner or Scrubbing BubblesR Bathroom Cleaner.
Limited One-Year Warranty -- USA and Canada KOHLERR plumbing fixtures, faucets and fittings are warranted to be free of defects in material and workmanship for one year from date of installation. Kohler Co. will, at its election, repair, replace or make appropriate adjustment where Kohler Co. inspection discloses any such defects occurring in normal usage within one year after installation. Kohler Co. is not responsible for removal or installation costs. To obtain warranty service, contact Kohler Co.
Lifetime Limited Warranty -- USA and Canada Kohler warrants the cast iron components of this product manufactured after February 10, 2000, to be free of defects in material and workmanship during normal residential use for as long as the original consumer purchaser owns his/her home. Gloss reduction, scratching, staining and alkaline etching, of the finish over time due to use, cleaning practices or water or atmospheric conditions are not manufacturing defects but are indicative of normal wear and tear.
One-Year Warranty -- For Mexico KOHLER CO. It is recommended that at the time of purchase, you verify that all accessories and components are complete in this package. This Kohler product is warranted to be free of defects in material and workmanship for one (1) year from the date of purchase as shown on the invoice or receipt. 1. Kohler Co. will only service its commercialized products through its authorized distributors. 2. To obtain warranty service, please present the invoice and corresponding warranty.
Troubleshooting Procedures This troubleshooting guide is for general aid only. A Kohler Authorized Service Representative or qualified electrician should correct all electrical problems. For warranty service, contact your dealer or wholesale distributor. Troubleshooting the Whirlpool System Symptoms 1. User keypad does not illuminate p when power button i pressed is d or outer t ring is rotated. 2. Motor starts, but all jets are not functioning. 3.
Troubleshooting continued 7. Pump stops before 18 minutes. A. GFCI or ELCB tripped. A. Identify source of fault, and correct. Reset GFCI or ELCB. B. Suction is blocked. B. Remove obstruction. C. Jets are blocked. C. Remove blockage. D. Motor overheated and protection device activated. D. Check for blockage at suction and/or jets. Remove blockage and allow motor to cool. 8. Pump does not automatically stop after 22 minutes. A. 20-minute timer inadvertently disabled. A. See service manual. 9.
94496 (Curved) 94497 (Flat) Pillow Kit 1019439 Sensor 93931 Screw 93823 Nut 93511** Cover 93590-A Manifold 94377 (Curved) 94495 (Flat) Pillow Cast Iron Shell Neck Valve Hardware 93542 Gasket 94387-A Plate 1000054 Screw 93848 Elbow 90153 Nut 63270 Washer 64212 Washer 60170 Nut 93948-A1 (8-3/8”/21.3cm) 93948-B1 (9-7/8”/25.1cm) 93948-C1 (6-7/8”/17.5cm) 93948-D1 (6”/15.2cm) 93948-E1 (4-5/8”/11.
1003065 Suction Flange Removal Tool 73518 Plug 93685 Housing 96708 Flange 65886 (Acrylic and FRP) 60050 (Cast Iron) Gasket 65054** Screw 65226** Suction Cover Plug 96895** (Colored Finishes) 65061** (Metal Finishes) Cover 93836 (1/2”) 93838 (1”) 93839 (1-1/4”) 94853 (1-1/2”) Tube (w/Couplings) 91967 Check Valve 67665 Plug 94469 Flange Removal Tool 67429 Flange 34353 O-Ring 67889 Jet Housing 65885 (Acrylic and FRP) 67668 (Cast Iron) Gasket Single Jet For Whirlpools With 5 or Less Jets 60394-P Sili
60320 Screw 67065 Ground Lug 1018964 Bracket 60320 Screw 90153 Locknut 67065 Ground Lug 93892 Electrical Box 61845-K Copper Grounding Wire 60320 Screw 1019432 Carriage Bolt 93003 Strain Relief 90154 Nut 93893 Cover 1016957 2 HP Pump 1016958 Motor 1010673 Seal 1010548 Volute 1010676 Cover 1010677 Screw 1016960 Impeller 1010675 O-Ring 1019719 Connector 94821 O-Ring 1005363 Nut 1019444-A (3/4”/1.9cm) 1019444-B (1-3/4”/4.4cm) 1019444-C (2”/5.1cm) 1019444-D (1-1/2”/3.8cm) 1019444-E (1”/2.
60320 Screw 67065 Ground Lug 1018964 Bracket 1001794 Locknut 60320 Screw 67065 Ground Lug 93892 Electrical Box 61845-K Copper Grounding Wire 60320 Screw 1019433 Carriage Bolt 93003 Strain Relief 93893 Cover 1016953 1.5 HP Pump 90153 Nut 1016954 Motor 1010673 Seal 1010548 Volute 1010676 Cover 1010677 Screw 1013755 Impeller 1010675 O-Ring 1019719 Connector 94821 O-Ring 1005363 Nut 1019444-A (3/4”/1.9cm) 1019444-B (1-3/4”/4.4cm) 1019444-C (2”/5.1cm) 1019444-D (1-1/2”/3.8cm) 1019444-E (1”/2.
1018709 Heater 1011679 Gasket 1012916 Nut w/Screws 1012653 Adapter 94821 O-Ring 1012977 Adapter 1018710 Heater 94821 O-Ring 1012916 Nut w/Screws 1012977 Adapter 94821 O-Ring 1011679 Gasket **Finish/color code must be specified when ordering. 1019486-5-A 16 Kohler Co.
1020677 Gasket 1023381 Wrench 65157 Nut 1013453 Spring Carefully study decal and cover detail below for proper service part identification 1013452** Dial Trim 1013499 Housing 91639 O-Ring 1020678--A Cover/Circuit Board (w/Wrench) 1020678-B Cover/Circuit Board (w/Wrench) 1013497-A Decal 1020678-C Cover/Circuit Board (w/Wrench) 1013497-B Decal 1020678-D Cover/Circuit Board (w/Wrench) 1013497-D Decal 1013497-C Decal 1020678-E Cover/Circuit Board (w/Wrench) 1013497-E Decal **Finish/color code must b
1013460 Housing 1020679-A Cover/Circuit Board 59588 Screw 94110 O-Ring 1013459-A Decal 1013469** Trim Ring **Finish/color code must be specified when ordering. 1019486-5-A 18 Kohler Co.
1013464-A Decal 1013822-A Remote w/Stand 1023091** Cap 1020679-A Remote 1013471** Stand 1013822-B Remote w/Stand 1013464-B Decal 1020679-B Remote **Finish/color code must be specified when ordering. Kohler Co.
USA: 1-800-4-KOHLER Canada: 1-800-964-5590 Mexico: 001-877-680-1310 kohler.com E2003 Kohler Co. 1019486-5-A 20 A 1019486-5- Kohler Co.