Owner's Manual
03
Aer Assembly:
Finish the door: please follow the wood stain/paint instructions.
(1)visually check the door surface;
(2) use wood filler to fill any unwanted holes or cracks;
(3) sand the door surface to remove dirt, grease, glue and handling marks;
(4) apply pre-stain conditioner before the stain helps the wood absorb the stain evenly;
(5) apply more than one coat of stain. Let the stain dry completely and sand lightly between coats;
(6) apply at least two coats of finishes or sealers such as polyurethane to protect the surface. (Additional coats
of sealers are especially important for door use at bathroom or kitchen areas.) It is important to apply sealers
on all six surfaces of the door slab.
Install the door: please follow barn door hardware installation instructions from the manufacturer.
The bottom of the door is NOT mortised and we recommend to use a wall-mounted floor guide.
LUBANN KNOTTY ALDER WOOD BARN DOOR Limited Warranty
Valley BLVD Trading and Investment Co.,LTD (Valley BLVD) warranties its products against manufacturing
defects in materials or workmanship for a period of One (1) year from date of shipment from Valley BLVD
according to hanging and maintenance/care requirements subject to specified exclusions as stated below. Valley
BLVD will, at our option, repair, replace or refund the purchase price of the product to the original owner.
Handling and Care Upon receipt of door, carefully inspect product for any visible defects including warp PRIOR
to installation. Notice must be given to dealer immediately. Unfinished/primed doors MUST be finished with a
good quality water base stain/top coat applied 6 sides within 48 hours of installation. Prior to installation doors: •
MUST NOT be stored prior in damp or direct sunlight conditions or where excessive heat is present • MUST
NOT be stored or installed until all sheetrock is painted and dry. • SHOULD be stored in dry, moderate heat
(50-70º) prior to installation.
Excluded from Warranty The following are not considered defects and therefore are not covered by warranty:
1. Cosmetic defects not reported upon receipt of product.
2. Damage, misuse or abuse caused by others beyond control of Valley BLVD.
3. Warp for doors 3’x7’ or smaller not exceeding 1/4” in the plane of the door itself. Doors larger than
3’x7’ are covered as such only if properly installed with 3-point locking hardware.
4. Natural variations in color, finish or texture of door.
5. Failures or defects not covered include broken glass, hardware not provided by Valley BLVD,
improper installation, lack of maintenance or normal aging.
6. Panel shrinkage. Panels are free-floating and allowed to move as wood stabilizes according to
climate conditions.
Maintenance Follow paint manufacturer’s procedures when applying new top coat or wax polish. It is important
to note that wood continues to be a living entity constantly adjusting to climate conditions. As your door ages
over time, it may naturally shrink and swell slightly which may produce small hairline cracks. Proper mainte-
nance will help minimize this condition and prolong the life of your door.