Operating instructions

20 Masport I43 NEW YORK / ULTIMATE Gas Inbuilt Fireplace
MAINTENANCE
GLASS REPLACEMENT
Your Masport stove is supplied with high temperature, 5 mm
Neoceram ceramic glass that will withstand the highest heat
that your unit will produce. In the event that you break your
glass by impact, purchase your replacement from an author-
ised Masport dealer only, and follow our step-by-step instruc-
tions for replacement.
Removing Glass
Note: Wearing gloves will protect your hands while han-
dling glass.
1) Remove the safety screen (Australia only). Remove the
door from the unit and place on a soft surface to prevent
scratching.
2) Pull out the door gasket.
3) Remove the 24 nuts holding the glass retainers in place.
Do not remove the nuts underneath the retainers.
4) Remove the door catch plate.
5) Remove glass retainers on sides first (3 each side) then
remove two center retainers.
Note: Center glass retainers are glued to center glass.
6) Remove glass from extrusions. When removing center
glass, leave white insulation in place.
Note: Safety
screen in
Australia only.
LOG REPLACEMENT
The unit should never be used with broken logs. Turn off the
gas valve and allow the unit to cool before opening door to
carefully remove the logs. The pilot light generates enough
heat to burn someone. If for any reason a log should need
replacement, you must use the proper replacement log. The
position of these logs must be as shown in the diagram under
Log Installation.
NOTE: Improper positioning of logs may createNOTE: Improper positioning of logs may create
NOTE: Improper positioning of logs may createNOTE: Improper positioning of logs may create
NOTE: Improper positioning of logs may create
carbon build-up and will alter the unit’s perform-carbon build-up and will alter the unit’s perform-
carbon build-up and will alter the unit’s perform-carbon build-up and will alter the unit’s perform-
carbon build-up and will alter the unit’s perform-
ance which is not covered under warranty.ance which is not covered under warranty.
ance which is not covered under warranty.ance which is not covered under warranty.
ance which is not covered under warranty.
GOLD-PLATED DOORS
The 24 carat gold plated finish on the door requires little
maintenance, and need only be cleaned with a damp cloth.
DO NOT use abrasive materials or chemical cleaners, as they
may harm the finish and void the warranty. Clean any finger-
prints off before turning the unit on. If gasket seal is not tight
- door may discolour.
DOOR GASKET AND
GLASS GASKET
If the door gasket requires replacement use 7/8" diameter oval
door gasket . The glass requires 7/8" flat glass gasket. See
your Masport Dealer.
LATCH ADJUSTMENT
The door latch may require adjustment as the door gasket
material compresses after a few fires and after glass replace-
ment. Turn the adjustable latch to tighten or loosen the latch.