Owner`s manual

ManualsBrandsMendota ManualsLawn and GardenFV-41

FULLVIEW RECTANGLE DIRECT VENT GAS FIREPLACE HEATER

Model FV-41

OWNER’S MANUAL

DOCUMENT NO. FV41-OM-0509

In the Commonwealth of Massachusetts:

• Installation must be performed by a licensed plumber or

gas fitter;

• A CO detector shall be installed in the room where the

appliance is installed.

WARNING: Improper installation, adjustment, altera-

tion, service or maintenance can cause injury or prop-

erty damage. Refer to this manual. For assistance or

additional information consult a qualified installer, ser-

vice agency or the gas supplier.

CAUTION

THESE INSTRUCTIONS ARE TO REMAIN WITH

THE HOMEOWNER.

WARNING

If the information in this manual is not followed exactly, a

fire or explosion may result causing property damage,

personal injury or loss of life.

Do not store or use gasoline or other flammable

vapors and liquids in the vicinity of this or any

other appliance.

WHAT TO DO IF YOU SMELL GAS

• Open windows.

• Do not touch electrical switches.

• Do not try to light any appliance.

• Extinguish any open flame.

• Do not use the phone in your building.

• Immediately call your gas supplier from a neighbor's

phone. Follow the gas supplier’s instructions.

• If you cannot reach your gas supplier, call the fire

department.

FOR YOUR SAFETY

A qualified installer, service agency, or the gas suppli-

er must perform installation and service.

Do not store or use gasoline or other flammable va-

pors and liquids in the vicinity of this or any other ap-

pliance.

WARNING

Do not operate this appliance with the glass removed,

cracked or broken. A licensed or qualified person

should do replacement of glass.

WARNING

Mendota gas fireplaces are heat producing appliances.

Do not burn wood, paper or other materials in this fire-

place. This fireplace is designed as a supplement

heat source. It is advisable to have an alternative pri-

mary heat supply.

WARNING

Do NOT use this appliance if any part has been under water.

Immediately call a qualified service technician to inspect the

appliance and to replace any part of the control system and

any gas control, which has been under water.

The installation must conform with local codes or, in

the absence of local codes, with the current National

Fuel Gas Code, ANSI Z223.1, or the current Natural

Gas and Propane Installation Code, CSA B149.1

Summary of content (26 pages)

PAGE 1
FULLVIEW RECTANGLE DIRECT VENT GAS FIREPLACE HEATER Model FV-41 OWNER’S MANUAL DOCUMENT NO. FV41-OM-0509 Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance. WHAT TO DO IF YOU SMELL GAS • Open windows. • Do not touch electrical switches. • Do not try to light any appliance. • Extinguish any open flame. • Do not use the phone in your building. • Immediately call your gas supplier from a neighbor's phone. Follow the gas supplier’s instructions.
PAGE 2
Table of Contents SAFETY AND WARNING INFORMATION .......................................................................................... 3 SPECIFICATIONS ................................................................................................................................ 4 CONGRATULATIONS.......................................................................................................................... 5 BUILDING PERMIT AND INSTALLATION INSPECTION APPROVAL REQUIREMENTS .................
PAGE 3
SAFETY AND WARNING INFORMATION READ and UNDERSTAND all instructions carefully before starting the appliance. FAILURE TO FOLLOW these instructions may result in a possible fire hazard and will void the warranty. Any safety screen or guard removed for servicing must be replaced before operating this appliance. DO NOT USE this appliance if any part has been under water.
PAGE 4
SPECIFICATIONS MODEL FV41 BTUH. (MODEL FV-41) BTUH. (MODEL FV-41) High Fire - Adjustable to - Low Fire NAT. GAS LP GAS 40,000 40,000 13,000 15,000 NOTE: LPG CONVERSION KIT, #New #, MUST BE PURCHASED SEPARATELY TO CONVERT TO BURN LPG IN THIS FIREPLACE. MAIN ORIFICE [0-2000ft (610 m)]: REAR BURNER: #42 NAT. GAS [#54 L.P. GAS] – FRONT BURNER: #42 NAT. [#54 LP] OVERALL EFFICIENCY: ..................... EXCEEDS D.O.E. EFFICIENCY REQUIREMENTS (A.F.U.E.) FOR DIRECT VENT WALL HEATERS.
PAGE 5
CONGRATULATIONS You are the owner of a world-class heat producing gas direct vent sealed combustion fireplace. This elegant, highly efficient Fireplace will be a constant source of comfort and fascination. It will be the focal point of beauty and interest in your home. The Mendota Gas Fireplace is a true heating appliance incorporating the traditional aesthetics of fireplace fire viewing with the controllability and fuel efficiency of a home gas furnace.
PAGE 6
BEFORE YOU BEGIN Read this entire manual before you use your new fireplace (especially the section “Safety Precautions” on page 2). Failure to follow the instructions may result in property damage, bodily injury, or even death. Remote Control Transmitter Functions NOTE: The Wall Receiver will “beep” once every time a Remote Transmitter Key is pressed, signaling that the command has been received. Identify the four function buttons on the Remote Transmitter: 1.
PAGE 7
REMOTE TRANSMITTER OPERATING INSTRUCTIONS TO TURN ON THE APPLIANCE: 1. Press the ON/OFF button. The transmitter display will show all active icons on the screen. 2. Select the Thermostat Mode by pressing the Thermostat Key: OFF (meaning Manual Mode), ON (meaning normal Thermostat) or Smart (meaning Smart Mode). a. In OFF (Manual Mode), the appliance will ignite and start on HI. b. In ON (Normal Thermostat Mode), the appliance will only ignite if the Set Temperature is greater than the Room Temperature. c.
PAGE 8
MANUAL BYPASS OF THE REMOTE SYSTEM If the remote transmitter is misplaced or lost, the appliance can be turned on manually by sliding the three position slider switch on the wall receiver to the ON position. This will bypass the remote control feature of the system and the appliance’s main burner will turn on. The fan will run at its maximum speed and the Accent Light may turn on.
PAGE 9
“FIRST TIME” PILOT LIGHTING INSTRUCTIONS IMPORTANT: Be sure all items on "INSTALLATION CHECK OFF LIST" in the Installation Manual have been completed! CAUTION: If the pilot goes out, be sure to wait a minimum of five minutes before attempting to relight the pilot. 1. Make certain that any manual gas supply shut-off valves located upstream of fireplace are open and the wall receiver and the remote control transmitter are in the "OFF" position.
PAGE 10
IPI/STANDING PILOT SYSTEM INFORMATION Supply voltage Ambient temperature ratings Radio Frequency REMOTE CONTROL 4.5V (three 1.5V AAA batteries) 32 – 122 oF (0 – 50 oC) 315 MHz WALL RECEIVER 6.0V (four 1.5V AA batteries) 32 – 140 oF (0 – 60 oC) 315 MHz ATTENTION! The transmitter and receiver are RADIO FREQUENCY DEVICES. Placing the receiver in or near metal may severely reduce the signal range. • • • • Turn off the main gas supply of the appliance during installation or maintenance of the receiver.
PAGE 11
FV-41 DOOR REMOVAL AND INSTALLATION TO REMOVE DOOR 1. Use the glass latch tool to disconnect the spring latches from the glass frame. Insert tool into hole in latch, pull towards you and Rotate 90 degrees to disengage top latches. Remove tool. There are two spring latches on top of this gas fireplace. 2. With both hands, rotate top edge of glass frame away from unit 12 inches. 3. Lift glass frame up 1 inch, at an angle, and move away from unit. 4. Door is now free from unit. TO REPLACE DOOR 1. 2. 3. 4.
PAGE 12
FV-41 LOG SET INSTALLATION INSTRUCTIONS FOLLOW EACH STEP DEPICTED IN THE DIAGRAMS, BELOW, TO INSTALL THE LOG SET. CAUTION: LOGS ARE FRAGILE, HANDLE LOG PIECES WITH CARE.
PAGE 13
| P a g e
PAGE 14
| P a g e
PAGE 15
| P a g e
PAGE 16
| P a g e
PAGE 17
| P a g e
PAGE 18
| P a g e
PAGE 19
| P a g e
PAGE 20
PLACE SMALL COALS ON TOP OF FLOOR BRICK PANELS AND CLOSE TO GRATE BOTTOM TO SIMULATE A COAL BED.
PAGE 21
BLOWER SYSTEM INFORMATION WARNING: Label all wires prior to disconnection when servicing controls. Wiring errors can cause improper and dangerous operation. Verify proper operation after servicing. Dual blowers are provided as standard equipment with this FV-41 fireplace. The dual blowers have an air output rating of 210 CFM (in free air). This fireplace is designed to operate with the blowers turned OFF or ON.
PAGE 22
MENDOTA WARRANTY QUALIFICATION & SERVICE REFERENCE FORM As a part of Mendota's on-going program of customer satisfaction, this Form verifies proper installation and operation. It is important as a reference for future service. It insures long life and trouble-free operation of Mendota fireplaces & stoves and qualifies the owner for Mendota's lifetime limited warranty. Owner should sign Form when completed and mail a copy along with Warranty Registration to Mendota.
PAGE 23
TAPE SHUT -------------------------------------------------------------------------------------------------------------------------------------------------------- POSTAGE NEEDED JOHNSON GAS APPLIANCE COMPANY 520 E AVENUE N.W.
PAGE 24
MENDOTA EXTENDED LIFETIME PROTECTION AND LIMITED WARRANTY MENDOTA FV-41 DIRECT VENT FIREPLACE Mendota Division of Johnson Gas Appliance Company, 520 E Avenue N.W. Cedar Rapids, Iowa 52405, extends this Extended Lifetime Protection and Limited Warranty to the original purchaser of a Mendota FV-41 Fireplace, which is limited and used under normal home conditions. STANDARD WARRANTY: JOHNSON GAS APPLIANCE CO.
PAGE 25
NOTES 25 | P a g e
PAGE 26
Johnson Gas Appliance Company 520 E Avenue N.W. - Cedar Rapids, IA 52405 Mendota Hearth Division WEBPAGE: www.johnsongas.com or www.mendotahearth.