Specifications

MEV™ Mini HUMMER HX™ OWNERS MANUAL
19
Scheduled Maintenance Procedures
Daily Inspection By Owner
Accelerator Pedal
Check for normal operation
Battery Pack
Check the batteries as per page 15 of this manual and fill
them to the proper levels as described on page 15 of this
manual
Brake System
Check for normal operation – have your dealer service if
required
Parking Brake
Check for normal operation – have your dealer service if
required
Reverse
Check for normal operation – have your dealer service if
required
Key Switch &
Drive Selection
Check for normal operation – have your dealer service if
required
Tires/Tyres
Check the tire/tyre pressures and look for any damage or
wear – replace if required
Weekly Inspection By Owner
Battery Pack
Check the batteries as per page 15 of this manual
Wiring
Check all wiring is secure and consult a technician to
replace any damaged wires
Entire Cart
Check for any damaged, loose or missing parts
Check all items included in the above mentioned daily checks
Monthly Inspection By The
Owner or a Qualified
Technician
Battery Pack
Clean the top areas of the battery pack with soda water
(WARNING - do not allow this into the battery)
Service the Brake
System
Check the brake fluid level, if required use DOT 3 rated
fluid to replenish
Check the brake lines and park brake lines for any
damage – have your dealer service if required
Check all the items included in the above mentioned daily/weekly checks
Quarterly Inspection
Items By The Owner or a
Qualified Technician
Rear Axle
Check and fill if required with hypoid gear oil
Entire Cart
Lubricate as per the chart on page 20 of this manual
Check all the items included in the above mentioned daily, weekly and
monthly checks
Semi – Annual Inspection
Items To Be Carried Out By a
Qualified Technician Only
Battery Pack
Check the specific gravity level, the electrolyte level and
general state of the battery pack after performing an
equalization charge
Service Brake
System
Inspect the fluid reservoir as required (DOT 3)
Check the brake pads, discs, shoes and drums – replace
them if necessary
Wires
Inspect all wiring and connections
Switches
Inspect all switches for full operation
Front Wheel
Alignment
Check and adjust if needed
Entire Cart
Lubricate as per the chart on page 17 of this manual
Check all the items included in the above mentioned daily, weekly, monthly
and quarterly checks
Annual Inspection Items to
be Carried Out By a Qualified
Technician Only
Battery Pack
Carry out discharge, test and full recharge
Motor
Check the motor brushes and replace if necessary
Front Wheel
Bearings
Adjust and repack bearings if required
Driving Axles
Check the driving axle and fill
Entire Cart
Lubricate as per the chart on page 17 of this manual
Check all the items included in the above mentioned daily, weekly, monthly,
quarterly and semi - annual checks