User Manual

®
STANDBY 450 ekW 563 kVA
60 Hz 1800 rpm 480 Volts
FACTORY INSTALLED STANDARD & OPTIONAL EQUIPMENT
System Standard Optional
Air Inlet • Light Duty Air filter • Canister Style Air Cleaners
• Air Cleaner - single stage
• Dual element
• Heavy duty
Cooling • Radiator package mounted(50ºC)
• Coolant drain line with valve terminated at edge of
base
• Fan and belt guards
• Coolant level sight gauge
• Caterpillar Extended Life Coolant
• Radiator removal
• Radiator duct flange & guard
Exhaust • Dry exhaust manifold
• Flanged faced outlets
• Stainless Steel Flex with split-cuff connection
• Mufflers
• Manifold & Turbocharger guards
• Elbows
Fuel • Primary fuel filter with integral water separator
• Secondary fuel filters
• Fuel priming pump
• Engine fuel transfer pump
• Flex fuel lines
• Fuel cooler*
*Not included with packages without radiators
• Integral UL listed fuel tank base
• Manual transfer pump
• Fuel level switch
Generator • Class H insulation
• R448 voltage regulator with load adjustment module
• IP23 Protection
• CDVR with KVAR/PF control
• Oversize and premium generators
• Bearing/Stator temperature detection (premium
generator)
• 3 phase sensing
• Anti-condensation space heaters
• Cable access box
• Reactive droop
Power Termination • Power Terminator Strips Mounted inside Power
Center
• Segregated low voltage wiring panel
• Circuit breakers, UL listed, 3 pole
• Circuit breakers, IEC compliant, 3 pole
• Circuit breaker Shunt trip
• Circuit breaker Auxillary contact
• Top & bottom power cable entry
• Floor standing UL breakers
Governor • ADEM™A4 • Load share module
Control Panels • EMCP 3.1 (rear mounted)
• Speed adjust
• Emergency stop pushbutton
• Voltage adjust
• EMCP 3.2 & EMCP 3.3 (can be RH mounted)
• Local annuniciator modules (NFPA 99/110)
• Remote annunicator modules (NFPA 99/110)
• Discrete I/O module
Lube • Lubricating oil and filter
• Oil drain line with valves
• Fumes disposal
• Gear type lube oil pump
• Manual sump pump
Starting/Charging • 24 volt starting motor
• Battery with rack and cables (dry)
• 45 amp charging alternator
• Jacket water heater with shut off valves
• Block heater
• Ether starting aids
• Battery disconnect switch
• Battery chargers ( 5 & 10 amp)
• Oversized batteries
General • Paint - Caterpillar yellow except rails and radiators
gloss black
• Flywheel and flywheel housing - SAE No.1
May 04 2009 13:42 PM
2