Specifications
•
Sky blue/orange cable (cable harness
side): 0V voltage if engine kill in STOP;
12V if engine kill in RUN.
•
Red/black cable (cable harness side):
always 12 V voltage
CAUTION
BEFORE CARRYING OUT ANY TROUBLESHOOTING, CAREFULLY READ THE GENERAL CON-
CEPTS OF ELECTRICAL TROUBLESHOOTING FOUND AT THE BEGINNING OF THE CHECKS
AND CONTROLS SECTION IN THE ELECTRICAL SYSTEM CHAPTER.
AXONE: PARAMETERS
-
AXONE: STATUSES
Run / stop switch
Example value:Run/Stop
DIAGNOSIS
•
Indication on Axone always STOP: disconnect the connector and, with the switch set to
RUN, check if there is continuity between the blue/green (PIN 1) cable and the grey/sky blue
(PIN 4) cable (sensor side): if there is not continuity, replace the sensor; if there is, check
the connector. If it is not OK, restore the cable harness; if it is OK, with the key set to ON,
check if there is voltage on the red/black cable (cable harness side). If there is no voltage,
restore the cable harness; if there is, check the ground insulation of the sky blue/orange
cable (cable harness side). if there is continuity to ground, restore the cable harness; if it is
OK, take the key to OFF and check that the BLUE connector is in good conditions and if
there is continuity of the sky blue/orange cable between the connector in question and PIN
27 of the BLUE connector: if not OK, restore the cable harness; if OK, replace the Marelli
control unit.
•
Indication on Axone always RUN: disconnect the connector and, with the switch set to
STOP, check if there is continuity between the two cables of the switch, PIN 1 and PIN 4
(sensor side). If there is continuity, replace the switch; if there is not, it means that, with the
key set to KEY ON, the sky blue/orange cable is shorted to positive: restore the cable har-
ness.
Connectors
Dashboard
The pin configuration of the grey-bodied connector is as follows:
PIN USE
1 + KEY
2 RIGHT TURN INDICATOR CONTROL
GRISO 8V - 1200 Electrical system
ELE SYS - 77
Revente Interdite - Revendita Vietata - Resaling Forbiden - Wiederverkauf Verboten