Instruction Manual

READ THIS BEFORE RUNNING
Running a nitro kit is fun and easy, but to make this a safe rusting.
• Clear oil and dirt from chassis with a degreaser.
and good experience you must observe a few rules. This
kit is extremely fast, easily over 40MPH, and can seriously
Precautions
injure someone if you are not careful.
• This kit is not a toy. Always run car with a second
person as a spotter and pitman.
Where to run car?
• Any running area you choose must be dry. Do not run
• Hot Parts - The pipe, manifold, engine and head are very
car near any water or wet dirt.
hot and will cause burns.
• Do not run on public streets. It is very easy to have the
car run over or damaged by hitting the curb.
• Rotating Parts - Keep hands away from the drive train,
• Do not operate car in tight confined places. The car is
wheels, and engine when engine is running.
very fast and will easily hit something.
• Do not run near people or animals.
• Radio - Check batteries life before running the car. If
radio does not have full control of the car with steering
• Due noise, you will want to consider the surrounding
and/or throttle/brake do not run until corrected. Failure to
area when operating the car.
correct this will result in possible injury and damage to the
• Do not operate the car at night. You will not be able to
car or property.
drive it without hitting something.
• Do not operate the car indoors. Engine exhaust is not
• Glow fuel - Do leave the glow fuel unattended with the lid
healthy.
off. Fuel contains Methanol and Nitro Methane and is
flammable and poisonous.
Glow Fuel
• Glow fuel is poisonous!
Store fuel in cool ventilated location. Refer the glow fuel
• Glow fuel is flammable!
• Do not leave in fuel bottle with lid off at any time. label for additional precautions.
• Don use any fuel other than glow fuel in this engine.
• Car Fuel tank - Never store fuel in car tank, it will ruin the
First Time Starting the Engine
engine if left in tank.
Caution! When starting engine make sure the following is
observed.
• Set engine Master needle to 3 turns (rich setting)
• Do not do this alone, get an experienced friend to help at
first.
IF YOU DO NOT BREAK-IN ENGINE
• Fill fuel tank, try not to spill fuel. Do not spill fuel on
CORRECTLY, MAINLY AT LOW RPM,
receiver
• Hold car off the ground, so it will not runaway when first
YOU WILL BREAK THE CONNECTING
starts
ROD!
• Turn on Radio and check the linkage before starting
engine.
• Turn on car receiver battery switch.
IF RTR KIT, FAILURE TO NOT
• Always have an air filter on the carburetor to keep dirt
out.
READ AND FOLLOW BREAK-
Engine Break-in
IN ENGINE INSTRUCTIONS
• See Engine Page.
Emergency Stopping Engine When Running
WILL VOID WARRANTY!
• Remove air filter and cover carb. intake.
• Squeeze fuel line and hold until engine stops.
• With a rag, cover exhaust outlet.
Storing Car After Running
• Remove fuel from tank and fuel lines
• Turn off radio in car
• Put a few drops of after run in engine to keep it from
The car is very fast
and will too easily hit someone.
REQUIRED FOR NON-RTR KIT OPERATION
THINGS NEEDED
AA Batteries ( 12 pcs )
Glow Fuel
20%
TOOLS NOT INCLUDED IN KIT
Phillips Type Screw Drivers ( L )
Phillips Type Screw Drivers ( S )
Needle Nose Pliers
Cutter
Curved Scissors
Knife
Instant Cemment
Cross Wrench
#17109 $3.95
Body Reamer $25.95
#10803 - Black
#10804 - Blue
#10805 - Purple
Masking Tape
Paints
Brush
Recommendation:
You may want to upgrade the car battery pack to a Ni-MIH 5 cell type(1000). This will
give more run time.
You will need to buy a few items to start the engine and run the
car.
• Use 20% nitro CAR fuel. Do not use airplane fuels, they will
over heat engine.
• Buy long glow plugs, like OFNA/PICCO Plug 51007 or MC-9
plug. Use plugs without idle bar.
Radio System
.21 Rear Exhaust Engine
#53211 - Hyper .21p4 w/ Pull Start
#52210 - Force .21 p4 w/o Pull Start
#52211 - Force .21 p4 w/ Pull Start
#51210 - OFNA/Picco w/o Pull Start
#51211 - OFNA/Picco w/ Pull Start
#51215 - OFNA/Picco .21 Comp
#53218 - Hyper .21 p8 w/ Pull Start
#52213 - Force .25 p4 w/o Pull Start
#52214 - Force .25 p4 w/ Pull Start
#51216 - OFNA/Picco .21 O-1 av
#51217 - OFNA/Picco .21 O-1bp
Optional:
#10212 - 6v Hump Pack, NiMH Battery $29.95
#10214 - NiMH Battery Pack Charger $7.95