I N S T A L L A T I O N DVR5100 Series Hybrid Video Recorder Hard Disk Drive Replacement Kit C2647M-B (10/09)
Contents Introduction. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 Models . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 Parts and Tools . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Introduction This manual describes how to install a replacement hard disk drive or upgrade to a higher capacity hard disk drive in a DVR5100 Series hybrid video recorder (HVR). MODELS The following models are available for DVR5100 Series hard disk drive replacements or upgrades: Replacement Kits DVR5KRP-250 DVR5KRP-500 DVR5KRP-1000 DVR5KRP-1500 DVR5KRP-2000 Contents One 250 GB hard disk drive One 500 GB hard disk drive One 1 TB hard disk drive One 1.
Installing the Hard Disk Drive Replacement Kit GETTING STARTED 1. Familiarize yourself with the instructions in this document. 2. Verify that you have all the necessary parts and tools (refer to Parts and Tools on page 3). 3. If possible, export all essential video before you install a new hard disk drive. If your unit contains two hard disk drives, export all essential video on both drives. Follow the instructions for exporting video in the DVR5100 Hybrid Video Recorder Operation manual.
6. Use a Phillips screwdriver to remove the chassis cover (refer to Figure 1). a. Remove all 10 screws from the DVR (four screws on each side and two on the back). Set aside the screws. Figure 1. Removing the Screws b. Slide the chassis cover back and up (refer to Figure 2). Set aside the cover. Figure 2.
INSTALLING A HARD DISK DRIVE WARNING: • Install only hard disk drives received from the Pelco factory. • Any video on the hard disk drive will be lost when the drive is replaced. If possible, export important video recordings before you replace a hard disk drive. Follow the instructions for exporting video in the DVR5100 Hybrid Video Recorder Operation manual. 1. Locate the hard disk drive cage near the front of the unit. Figure 3. Locating the Hard Disk Drive Cage 2. To remove a hard disk drive: a.
b. Lift up and slide the cage out from under the retainer bracket. Two tabs along the bottom of the cage secure the cage to the bottom of the chassis. Figure 5. Removing the Hard Disk Drive Cage c. Remove the power and data cables from both drives in the cage. Figure 6.
d. Using a Phillips screwdriver, remove and set aside the four screws that secure the drive to the sides of the cage. Figure 7. Removing the Screws from the Hard Disk Drive in the Cage e. Slide the drive out of the cage. Avoid scratching the bottom of the drive against the metal sides or the bottom of the cage. Figure 8. Removing the Hard Disk Drive from the Cage f. Repeat steps d and e for the second drive, if needed.
4. To reinstall the hard disk drive cage in the chassis: a. Attach the power and data cables to both drives. b. Place the cage in the chassis and guide the tabs under the retainer bracket. Figure 9. Inserting the Hard Disk Drive Cage into the Chassis c. Fasten the two screws to the chassis. Do not overtighten the screws. Figure 10.
REASSEMBLING THE UNIT 1. Replace the chassis cover using the screws you removed from the sides and rear of the unit (refer to Figure 1 on page 5). 2. Reinstall the unit in a rack enclosure, if necessary, and then reconnect all cables and peripheral equipment you removed earlier. 3. Reconnect the power cord to the unit. 4. If the blue Pelco badge does not illuminate after the power cord is reconnected, turn on the unit by pressing the power button on the front panel.
PRODUCT WARRANTY AND RETURN INFORMATION WARRANTY Pelco will repair or replace, without charge, any merchandise proved defective in material or workmanship for a period of one year after the date of shipment.
www.pelco.com Pelco, Inc.