User's Manual

Catalog No.: 6000.37 Effective: 9-15-08 Replaces: NEW
Job:
Engineer:
Contractor:
Prepared By: Date:
Model: Indoor/Outdoor:
97% Thermal Efficiency at Full Rate; Up to 99% at Part Load
100% Factory Fire Tested
Maximum Outlet Water Temperature: 160°F
Minimum Acceptable Inlet Water Temperature: 50°F
Full Safety Diagnostics with History
Footprint: Less Than 10.8 ft
2
Limited Twenty-Five-Year Thermal Shock Warranty
Limited Ten-Year Primary Heat Exchanger Warranty
Limited Five-Year Secondary Heat Exchanger Warranty
Full Electronic Modulation, Constant Ratio 4:1 Turndown
Digital Controller with LCD Display
Status Display Lights
Heat Exchanger
 Bronze Headers
 ASME HLW Stamped; 160 PSIG
MAWP
 National Board Listed
 Cupro Nickel Fin Tubing
 ASME Powder-Coated Tube Sheet
 Silicone High Temp O-Rings
 ASME Pressure Relief Valve
125 PSIG – Standard (Loose)
 150 PSI Air Vent, Auto
 T&P Gauge (Loose)
 Stainless Steel Secondary Heat
Exchanger
 Stainless Steel Evaporator Plate
 Boiler Pump: Bronze,
HP,
120V, 1∅, 60Hz
Control
 120V, 60Hz, 1Ø, Power Supply
 120/24V 60Hz Transformer
 Ignition Module
3-Try – Standard
Single-Try – Option C-6
 Hot Surface Ignition (HSI)
 Remote Flame Sensor
 High Limit Control, Auto Reset
 On/Off Power Switch
 Flow Switch
 Blocked Vent Pressure Switch
 Combustion Air Proving Switch
 Freeze Protection
 Pump Switch
 Pump Time Delay
 Blocked Condensate Switch
Control (cont.)
 Diagnostics Panel with LCD Display,
2 lines, 20 characters
 Digital Temperature Control
 Water Temperature Sensors (3)
 Cold Water Protection
Burner
 Ultra-Low NOx: Less than 20 PPM
(Natural Gas Only)
Gas Train
 Fuel
Natural Gas
Propane
 Zero Governor Regulator
 Dual-Seat Combination Valve
 Electronic Firing Mode (WHP)
Construction
 Indoor/Outdoor Construction
 Front Controls Enclosed
 PolyTuf Powder Coat Finish
 Rear Connections (Water, Gas, Vent,
Electrical, Comb. Air, Cond. Drain)
 Combustion Air Filter
 Design Certified ANSI Z21.10.3/CSA 4.3
Venting
 Vent Termination
Outdoor or Indoor, Vertical –
Option D-11
Indoor, Horizontal – Option D-15
 Extractor - Optional
By others
Not required
Multi-Boiler Digital Temp Controllers
B-36 TempTracker Mod+,
2-4 Water Heaters
B-37 TempTracker Mod+,
5-10 Water Heaters
B-38 TempTracker Mod+,
11-16 Water Heaters
Options
F-10 Low Water Cut-Off, Remote
Probe
I-5 High Limit, Manual Reset,
Adj., 100-200°F
S-1 Low Gas Pressure Switch,
Manual Reset
S-2 High Gas Pressure Switch,
Manual Reset
Z-12 Condensate Neutralizer Kit
Regulatory Agency Requirements
XTherm
™
- Type WHP
Water Heaters
Models 1005-2005