THANKLESS WATER HEATER USE AND CARE M;} DAL With Installation Instructions for the installer Non condensing 199,900 Brewer, 180,000 Biw/ hr, and 150,000 Niebuhr Models
IMPORTANT SAFETY INFORMATION DANGERS: * WATER TEMPERATURE SETTINGS Safely and energy conservation are factors to be considered when selecting the water temperature setting of a water heater's remote control. Water temperatures above 125°F {52°C} can cause death ar severe burns from scalding. Be sure to read and follow the warnings outlined on the pictured label. There s a hot water scald potential if the water temperatures Is set too high.
IMPORTANT SAFETY INFORMATION ~ (Natural Gas and Liquefied Petroleum Safely DANGERS: + Haber attempt to convert the water heater rom natural gas to LB The water heater should only use the fus! types In accordance with listing on data plate—natural gas for natural gas unite and LP for LP units. Any other fue! usage will result in death or serious personal injury from fire and/ or explosion. This water heater Is not certified for any other fuel type.
IMPORTANT SAFETY INFORMATION Before operating this water haler, be sirs to read and follow the instructions on the label pictured below and alf other labels on the water heater, as well as the warnings printed in this manual. Failure io do so can result in unsafe operation of the water heater, resulting in death, personal injury, or property damages. Should you have any problems reading or following the instructions in this manual, STOP and get help from a qualified service technician.
IMPORTANT SAFETY INFORMATION ( Electrical Safety H.DANGER: + Shock Hazers Make sure the electrical power to the water heater Is off to avoid electric shock iii result In death or serous personal injury. WARNINGS: s For your safety, ths information in this manual must bs followed to minimize the risk of fire, explosion, or semicircle shock that can result In death, personal Injury, and/or property damage.
e IMPORTANT SAFETY INFORMATION WARNINGS: * This water heater must be Installed in accordance with these Instructions, local codes, utility company requirements and/or in the absence of local codes, use the test sedition of the American National Standard/ National Fuel Qas Code (NFGC], ANSI Z223.1 and National Fire Protection Association, PAN 54, or in Canada, CANCAN B149.
e PRODUCT INFORMATION K Specifications The following product information English Rating Label can be found from the rating label on this water heater. Moon N & A Model Number serial Umber oy ¢. Data Bar Cods D. Heater Gyps E£. Installation Gyps E Type of Gas 8. Max. Inlet Gas Pressure H. Min. Inst Gas Surpass J. Recovery Rating K. #ax. BTU Input Rating L. Min. BTU Input Rating M. Manifold Gas Pressure N. Certification Stamp P Alternate Approval Stamp Q.
Safety Precautions USING YOUR WATER HEATER VARNISHING: * Flammable vapors can be drawn by air currents from surrounding areas to the water heater. Vapors can lignite causing death, personal in fury, or product damage. + DO NOT stirs or use flammable or combustible materials {gasoline, paint thinner, adhesives, newspapers, rags, mops, sto} in the vicinity of the water heater or any other gas appliance.
S USING YOUR WATER HEATER 14 Setting the Water Temperature (cont.) Maximum water temperatures scours while the Walter heater burner is on. To determine the water temperature: Turn on the hot water faucet and place a thermometer in the water stream. NOTICE: Water temperatures at the faucet may vary depending on the season and ths length of pips from the water heater.
CARING FOR YOUR WATER HEATER Water Heater Inspections Venting System (Direct Cont Only} The venting system should be inspect annually by a qualified service technician to ensure afl of the vent sections are secure and airtight. RAVING: DO NOT operate the warts header if the vent system shows signs of slaking exhaust. Les king exhaust could lead to death, personal In fury, andiron product failure. Outdoor models Hack the air intake and vent outlet for blockage and/or debris.
CARING FOR YOUR WATER HEATER Care and Cleaning H.DANGER: NOTICE: Shack Hazard Make certain power to the wale heater The air intake requires 2 minima OFF before removing protective roves for any reason. of clearance between the air intake opening and any Metric shook will cause death or serious personal abstraction. jury.
e 13 CARING FOR YOUR WATER HEATER ‘) Care and Cleaning {cont.) CAUTION: D0 NOT tap or force the filter during removal. This CAUTION: 00 NOT overflight the wale filter. Overweening can deform and/or damage the filler. can deform and/or damage the filter. u B Unshorn the water filter from the base of the cold water inlet line and carefully slide &t cut of the line. Clean the water fitter under running water.
CARING FOR YOUR WATER HEATER ‘) Preventive Maintenance VARNISHING: Allure {o perform routine preventive maintenance can prevent the warts healer from operating properly. Improper operation can cause carbon monoxide dangers, excessive water temperatures, and other potentially hazardous conditions resulting in death, personal injury, and/or product damage. Properly maintaining your water heater will ensure dependable, trouble-free service.
e CARING FOR YOUR WATER HEATER 20 ‘) Draining the Water Healer VARNISHING: Allure to follow these draining Instructions can cuss serious personal injury from scalding andiron product damage. Turn off the water sailfish by pressing the POWER ON/OFF button on the control panel. | At least 10 seconds after Sep 1, unplug the wale heater or disconnect the power supply at the circuit breaker box. C Open all hot water faucets. Run the water until ft is COLD; then shut off the faucet.
CARING FOR YOUR WATER HEATER ‘) Draining the Water Heater {cont.} CAUTION: Even when drained properly, 2 small amount of warts will remain in the water heater. In cold weather conditions, this warts can freeze. if this happens, allow the defrost protection on the water heater at least 30 minutes to melt the frozen water. The water heater will not work properly lint this water is thawed.
e CARING FOR YOUR WATER HEATER 22 ‘) Draining the Water Heater {cont.} Prof erred Drain Method Isolation valve kits may be purchased from the manufacture, distributor, or place of purchase. The kits include two full port isolation valves fo be sad in the inst and outlast water lines. It is highly recommended 1o install isolation valve kits because theses kits provide ?i for full diagnostic feting and case of system using.
CARING FOR YOUR WATER HEATER Service Error Code Chart Your water heater has an electronic diagnostic system built info #. Wuhan the water heater finds a problem, it displays an error code in the LED display on the remote control, Ths following chart lists the error codes along with their possible problem and solution. Using this chart may help you diagnoses and/or fix a problem you may be experiencing. Please reform to this chart before calling for service assistance.