Use and Care Manual

Pre‐OperationLeakTesting

DANGER

1. Donotinsertanytoolintothevalveoutletorsafetyreliefvalve.Youmaydamagethevalveandcausea

leak.Leakingpropanemayresultinexplosion,fire,severepersonalinjury,ordeath.

2. Ifaleakisdetectedatanytimeoryoucannotstopagasleak,

immediatelyclosepipelinevalveandcallLP

gassupplieroryoufiredepartment!

3. Checkallgassupplyfittingsbeforeeachuseandeachtimethegassupplycylinderisconnectedtothe

regulator.Haveaqualifiedservicetechnicianleaktestthegrillanytimeapartofthegas

systemis

replaced.

WARNING

Neverattempttoattachthisgrilltotheself‐containedLPgassystem.Donotusegrilluntilleak testing.

BeforeTesting

DO NOT smoke while leak testing. Extinguish all open flames. Never leak test with an open flame. Mix a 

solutionofequalpartsmilddetergentorliquidsoapandwater.



LeakTestingValves,HoseandRegulator

1.TurnallgrillcontrolknobstoOFF.

2.BesurehoseistightlyconnectedtoLPtank.

3.CompletelyopenLPtankvalvebyturningcylindervalve

knobcounterclockwise(righttoleft).Ifyouheararushing

sound, turn gas off immediately. There is a major leak at

the connection.

 Correct before proceeding by calling

franchiserforreplacementparts.

4.Brush soapy solution onto areas where bubbles are

showninLPtank(seepicture).

5.If“growing” bubblesappear,thereisaleak.CloseLP

tankvalveimmediatelyandretightenconnections.Ifleads

cannotbestoppeddonottryto

repair.Callfranchiserfor

replacement.

6.AlwayscloseLPtankvalveafterperformingleaktestbyturningcylindervalveknobclockwise.



NOTE:Whenleaktestingthisappliance,makesuretotestandtightenalllooseconnections,includingtheside

burner.Aslightleakinthesystemcanresultinalowflame,orahazardouscondition.

LPGasSupplyCylinderDisconne ctio n

1. Turntheburnervalvesoff.

2. Turnthetankvalveoff.(Turnclockwisetostop).

3. Detachtheregulatorassemblyfromthetankvalvebyturningthequickcouplingnutcounterclockwise.

