NEONIX Co., Ltd. Date: Feb 22, 2022 MODEL VCA-RBT95 / DJ96-00234A Safety Data Sheet Regulation : In accordance with Regulation (EU) 2015/830 (REACH), Annex II, and OSHA 29 CFR 1910.1200 Section I – IDENTIFICATION OF THE SUBSTANCE/MIXTURE AND OF THE COMPANY/UNDERTAKING Important Note: As a solid, manufactured article, exposure to hazardous ingredients is not expected with normal use. This battery is an article pursuant to 29 CFR 1910.
NEONIX Co., Ltd. Date: Feb 22, 2022 MODEL VCA-RBT95 / DJ96-00234A Remark: The information and recommendations set forth are made in good faith and believed to be accurate as of the date of preparation. NEONIX CO.,Ltd. makes no warranty, expressed or implied, with respect to this information and disclaims all liabilities from reliance on it.
NEONIX Co., Ltd. Date: Feb 22, 2022 MODEL VCA-RBT95 / DJ96-00234A 2.3 Other hazards: Appearance, Color and Odor : Solid object with no odor. Primary Routes(s) of Exposure : These chemicals are contained in a sealed enclosure. Risk of exposure occurs only if the cell or pack is mechanically, thermally, electrically or physically abused to the point of compromising the enclosure.
NEONIX Co., Ltd. Date: Feb 22, 2022 MODEL VCA-RBT95 / DJ96-00234A 12190-79-3 235-362-0 - 1~5 cobalt lithium dioxide 554-12-1 209-060-4 - 1~5 Methyl propanoate 7429-90-5 231-072-3 - 1~5 Aluminium 21324-40-3 244-334-7 - 1~3 114435-02-8 Not available - 1~3 616-38-6 210-478-4 - 1~3 lithium hexafluorophosphate(1-) 4-Fluoro-1,3-dioxolan-2one dimethyl carbonate Polyethylene 9002-88-4 Not available - 1~3 1309-37-1 1318-23-6 215-168-2 215-284-3 - 0.1~1 0.
NEONIX Co., Ltd. Date: Feb 22, 2022 MODEL VCA-RBT95 / DJ96-00234A - In case of inhalation of organic electrolyte mist, remove from exposure to fresh air. - If necessary give oxygen. Get medical attention. Following ingestion : - In case of ingestion of electrolyte don’t induce vomiting. - If patient is conscious and alert give 2~4 cupfuls of milk or water. - Never give anything by mouth to an unconscious person. - Get medical attention immediately.
NEONIX Co., Ltd. Date: Feb 22, 2022 MODEL VCA-RBT95 / DJ96-00234A Section VI – ACCIDENTAL RELEASE MEASURES 6.1 Personal precautions, protective equipment and emergency procedures For non-emergency personnel Protective equipment : Use personal protective equipment, see Section 8 Emergency procedures : - In case of cell damage, possible release of dangerous substances and a flammable gas mixture. - Eliminate all ignition sources. - Please note that materials and conditions to avoid.
NEONIX Co., Ltd. Date: Feb 22, 2022 MODEL VCA-RBT95 / DJ96-00234A 7.2 Conditions for safe storage, including any incompatibilities Technical measures and storage conditions : Not available Packaging materials : Not available Requirements for storage rooms and vessels : - Storage at room temperature (approx. 20℃) at approx. 40% of the nominal capacity - Keep in closed original container. 7.
NEONIX Co., Ltd. Date: Feb 22, 2022 MODEL VCA-RBT95 / DJ96-00234A 4-Fluoro-1,3-dioxolan-2one dimethyl carbonate Polyethylene Not applicable Not applicable Not applicable Not available Not applicable Not applicable Not available Not applicable Not applicable Not available Not applicable Not applicable TWA = 5 mg/m³ Not available TWA = 10 mg/m³ (fume) Boehmite (Al(OH)O) Not applicable Not available Not applicable TWA = 3mg/m³ (inhalable particulate matter) Not available TWA = 3.
NEONIX Co., Ltd. Date: Feb 22, 2022 MODEL VCA-RBT95 / DJ96-00234A lithium carbonate Not applicable ethylbenzene Not available TWA = 20 ppm Not available Not applicable TWA = 100 ppm TWA = 435 mg/m3 Not applicable Not applicable TWA = 100 ppm (ST) 125 ppm TWA = 442 mg/m³, TWA= 100 ppm, STEL = 884 mg/m³, STEL = 200 ppm 8.2 Exposure controls 8.2.
NEONIX Co., Ltd. Date: Feb 22, 2022 MODEL VCA-RBT95 / DJ96-00234A Respiratoryprotection : - None required during normal use. - Wear NIOSH or European Standard EN 149 approved full or half face piece (with goggles) respiratory protective equipment when necessary. - In lack of oxygen(< 19.5%), wear the supplied-air respirator or self-contained oxygen breathing apparatus.
NEONIX Co., Ltd. Date: Feb 22, 2022 MODEL VCA-RBT95 / DJ96-00234A 9.2 Other information Not available Section X – STABILITY AND REACTIVITY 10.1 Reactivity - Stable at ambient temperature. 10.2 Chemical stability - There is no hazard when the measures for handling and storage are followed. - Stable under normal temperatures and pressures. 10.3 Possibility of hazardous reactions - Will not occur under normal conditions.
NEONIX Co., Ltd. Date: Feb 22, 2022 MODEL VCA-RBT95 / DJ96-00234A Section XI – TOXICOLOGICAL INFORMATION ※ This is a product that fulfills a certain function in solid state with specific shape without discharging any chemical substance in its use and has no obligation to write (M)SDS. Since this document contains the precautions for safe handling related to its materials or chemical substances consisting of this product, please note that these overall information is irrelevant to this product. 11.
NEONIX Co., Ltd. Date: Feb 22, 2022 MODEL VCA-RBT95 / DJ96-00234A Skin corrosion/ irritation : - Graphite : In the skin irritation test using rabbits, the test material was not irritating. (OECD Guideline 404, GLP) - Fe : In test on skin irritation with rabbits, skin irritations were not observed.(Read across; Fe3O4)(OECD TG 404, GLP) - Copper : In test on skin irritation with rabbits, skin irritations were not observed.
NEONIX Co., Ltd. Date: Feb 22, 2022 MODEL VCA-RBT95 / DJ96-00234A - 1-Methyl-2-pyrrolidinone : In the eye irritation test using rabbit, the test material was moderately irritating. (OECD Guideline 405, GLP) Respiratorysensitization : - Aluminum : Al2O3 was the least inflammatory material tested and led to only weak effects on the mouse lung. (Read across; Aluminium oxide) - Carbon black : In respiratory sensitization test with mice, it did not induce respiratory sensitization.
NEONIX Co., Ltd. Date: Feb 22, 2022 MODEL VCA-RBT95 / DJ96-00234A ACGIH - Nickel : A5 - Cobalt and cobalt compounds : A3 - Aluminum : A4 - Carbon black : A3 KOREA-ISHL - Cobalt and inorganic compounds : 2 - Carbon black : 2 - Nickel : 1A EU - Lithium nickelate : Carc.1A - Nickel : Carc.2 - Copper : EPA IRIS: D In carcinogenicity study with rat, tumor was not observed. - Polyethylene : Fifty rats were implanted with polyethylene.
NEONIX Co., Ltd. Date: Feb 22, 2022 MODEL VCA-RBT95 / DJ96-00234A Reproductive toxicity : - Copper : In reproductive toxicity with rats, there were no effects considered (up to 1500 ppm). (OECD TG 416, GLP) - Aluminum : No reproduction, breeding and early post-natal developmental toxicity was observed in rats at 1000 mg/kg bw for males and females.
NEONIX Co., Ltd. Date: Feb 22, 2022 MODEL VCA-RBT95 / DJ96-00234A formation in their bones.(Information on major hydrolysis product of the registered substance (released rapidly on contact with water/moisture))(OECD Guideline 412) - Carbon black : Mice were continuously fed various types of carbon black in massive quantities (10% in diet) for 12 to 18 months. This led to no detectable changes from the normal in the organs and tissues of the mice fed.
NEONIX Co., Ltd. Date: Feb 22, 2022 MODEL VCA-RBT95 / DJ96-00234A - Carbon black : 24hr-EC50 > 5600 mg/L (OECD TG 202, GLP) - Lithium carbonate;Lithane : 48hr-EC50 = 33.2 mg/L (OECD Guideline 202, GLP), 21d-NOEC (Daphnia magna) = 9 mg/L (Read across; lithium)(OECD Guideline 211, GLP) - 1-Methyl-2-pyrrolidinone : 24hr-EC50 > 1000 mg/L German Industrial Standard DIN 38 412 Part 11 Algae - Graphite : 72hr-EC50 (Selenastrum capricornutum) > 100 mg/L - cobalt lithium dioxide : 96hr-EC50 = 71.
NEONIX Co., Ltd.
NEONIX Co., Ltd. Date: Feb 22, 2022 MODEL VCA-RBT95 / DJ96-00234A Section XIV – TRANSPORTATION INFORMATION ※ If those lithium-ion batteries are packed with or contained in an equipment, then it is the responsibility of the shipper to ensure that the consignment are packed in compliance to the latest edition of the IATA Dangerous Goods Regulations section Ⅱ of either Packing Instruction 966 or 967 in order for that consignment to be declared as NOT RESTRICTED (non-hazardous/non-Dangerous).
NEONIX Co., Ltd. Date: Feb 22, 2022 MODEL VCA-RBT95 / DJ96-00234A 14.3 UN Number : 3480 14.4 UN Proper shipping name : LITHIUM ION BATTERIES 14.5 Transport Hazard class : 9 14.6 Packing group : II 14.7 Special provisions : 188, 230, 384 14.8 Packing instructions : P903 14.9 Environmentalhazards : No 14.10 Specialprecautions for user in case of fire : F-A in case of leakage : S-I 14.11 Transport in bulk according to Annex II of MARPOL 73/78 and the IBC Code : Not Available 14.
NEONIX Co., Ltd. Date: Feb 22, 2022 MODEL VCA-RBT95 / DJ96-00234A - Copper : Regulated - Aluminium : Regulated - Nickel : Regulated - lithium carbonate : Regulated - 1-Methyl-2-pyrrolidinone : Regulated - Cobalt, Co : Regulated Substance of Roterdame Protocol : Not regulated Substance of Stockholme Protocol : - lithium hexafluorophosphate(1-) : Regulated Substance of Montreal Protocol : Not regulated 15.
NEONIX Co., Ltd. Date: Feb 22, 2022 MODEL VCA-RBT95 / DJ96-00234A CERCLA = Comprehensive Environmental Response, Compensation & Liability Act (US) EPCRA = Emergency Planning and Community Right-to-Know Act (US) EINECS = European Inventory of Existing Commercial chemical Substances ELINCS = European List of Notified Chemical Substances 16.3 Key literature reference and sources for data : U.S. National library of Medicine (NLM) Hazardous Substances Data Bank (HSDB) LookChem; http://www.lookchem.
NEONIX Co., Ltd. Date: Feb 22, 2022 MODEL VCA-RBT95 / DJ96-00234A Safety Data Sheet Réglementation : Conformément au Règlement (UE) 2015/830 (REACH), Annexe II, et OSHA 29 CFR 1910.1200 Réglementation : Conformément au Règlement (UE) 2015/830 (REACH), Annexe II, et OSHA 29 CFR 1910.1200 Remarque importante : En tant qu'article manufacturé solide, l'exposition à des ingrédients dangereux n'est pas prévue dans le cadre d'une utilisation normale. Cette batterie est un article conforme à la norme 29 CFR 1910.
NEONIX Co., Ltd. Date: Feb 22, 2022 MODEL VCA-RBT95 / DJ96-00234A Remarque: Les informations et recommandations présentées sont faites de bonne foi et considérées comme exactes à la date de préparation. NEONIX CO., Ltd. n'offre aucune garantie, expresse ou implicite, concernant ces informations et décline toute responsabilité en cas de confiance.
NEONIX Co., Ltd. Date: Feb 22, 2022 MODEL VCA-RBT95 / DJ96-00234A Apparence, couleur et odeur : Objet solide sans odeur. Voie(s) principale(s) d'exposition : Ces produits chimiques sont contenus dans une enceinte scellée. Le risque d'exposition ne se produit que si la cellule ou le pack est mécaniquement, thermiquement, électriquement ou physiquement abusé au point de compromettre l'enceinte.
NEONIX Co., Ltd. Date: Feb 22, 2022 MODEL VCA-RBT95 / DJ96-00234A 12190-79-3 235-362-0 - 1~5 cobalt lithium dioxide 554-12-1 209-060-4 - 1~5 Methyl propanoate 7429-90-5 231-072-3 - 1~5 Aluminium 21324-40-3 244-334-7 - 1~3 114435-02-8 Not available - 1~3 616-38-6 210-478-4 - 1~3 lithium hexafluorophosphate(1-) 4-Fluoro-1,3-dioxolan-2one dimethyl carbonate Polyethylene 9002-88-4 Not available - 1~3 1309-37-1 1318-23-6 215-168-2 215-284-3 - 0.1~1 0.
NEONIX Co., Ltd. Date: Feb 22, 2022 MODEL VCA-RBT95 / DJ96-00234A - En cas d'inhalation de brouillard d'électrolyte organique, éloignez-vous de l'exposition à l'air frais. - Si nécessaire donner de l'oxygène. Obtenez des soins médicaux. Suite à l'ingestion : - En cas d'ingestion d'électrolyte, ne pas faire vomir. - Si le patient est conscient et alerte, lui donner 2 à 4 tasses de lait ou d'eau. - Ne portez rien à la bouche d'une personne inconsciente. Consulter immédiatement un médecin.
NEONIX Co., Ltd. Date: Feb 22, 2022 MODEL VCA-RBT95 / DJ96-00234A Section VI – MESURES DE REJET ACCIDENTEL 6.1 Précautions individuelles, équipement de protection et procédures d'urgence Pour les non-secouristes quipement de protection : Utiliser un équipement de protection individuelle, voir Section 8 Procédures d'urgence : - En cas de cellule endommagée, dégagement possible de substances dangereuses et d'un mélange gazeux inflammable. - É liminer toutes les sources d'inflammation.
NEONIX Co., Ltd. Date: Feb 22, 2022 MODEL VCA-RBT95 / DJ96-00234A 7.2 Conditions d'un stockage sû r, y compris d'éventuelles incompatibilités Mesures techniques et conditions de stockage : Non disponible Matériaux d'emballage : Non disponible Exigences pour les salles de stockage et les récipients : - Stockage à température ambiante (env. 20℃) à env. 40% de la capacité nominale - Conserver dans l'emballage d'origine fermé. 7.
NEONIX Co., Ltd. Date: Feb 22, 2022 MODEL VCA-RBT95 / DJ96-00234A 4-Fluoro-1,3-dioxolan-2-one dimethyl carbonate Polyethylene Not applicable Not applicable Not applicable Not available Not applicable Not applicable Not available Not applicable Not applicable Not available diiron trioxide TWA = 5 mg/m³ Not available Boehmite (Al(OH)O) Not applicable Not available TWA = 3mg/m³ (inhalable particulate matter) Not available Nickel TWA = 1.
NEONIX Co., Ltd. Date: Feb 22, 2022 MODEL VCA-RBT95 / DJ96-00234A lithium carbonate Not applicable ethylbenzene TWA = 20 ppm Not available Not available Not applicable Not applicable Not applicable TWA = 100 ppm TWA = 100 ppm TWA = 435 mg/m3 (ST) 125 ppm TWA = 442 mg/m³, TWA= 100 ppm, STEL = 884 mg/m³, STEL = 200 ppm 8.2 Contrô les d'exposition 8.2.
NEONIX Co., Ltd. Date: Feb 22, 2022 MODEL VCA-RBT95 / DJ96-00234A Protection respiratoire : - Aucun requis lors d'une utilisation normale. - Porter un équipement de protection respiratoire complet ou demi-masque (avec lunettes) approuvé par le NIOSH ou la norme européenne EN 149 si nécessaire. - En cas de manque d'oxygène (< 19,5%), porter un appareil respiratoire à adduction d'air ou un appareil respiratoire autonome à oxygène.
NEONIX Co., Ltd. Date: Feb 22, 2022 MODEL VCA-RBT95 / DJ96-00234A 9.2 Autres informations Indisponible Section X – STABILITÉ ET RÉ ACTIVITÉ 10.1 Réactivité - Stable à température ambiante. 10.2 Stabilité chimique - Il n'y a aucun danger lorsque les mesures de manipulation et de stockage sont respectées. - Stable à des températures et pressions normales. 10.3 Possibilité de réactions dangereuses - Ne se produira pas dans des conditions normales.
NEONIX Co., Ltd. Date: Feb 22, 2022 MODEL VCA-RBT95 / DJ96-00234A Section XI – INFORMATIONS TOXICOLOGIQUES ※ Il s'agit d'un produit qui remplit une certaine fonction à l'état solide avec une forme spécifique sans décharger aucune substance chimique lors de son utilisation et n'a aucune obligation d'écrire une (M)SDS.
NEONIX Co., Ltd. Date: Feb 22, 2022 MODEL VCA-RBT95 / DJ96-00234A Skin corrosion/ irritation : - Graphite : In the skin irritation test using rabbits, the test material was not irritating. (OECD Guideline 404, GLP) - Fe : In test on skin irritation with rabbits, skin irritations were not observed.(Read across; Fe3O4)(OECD TG 404, GLP) - Copper : In test on skin irritation with rabbits, skin irritations were not observed.
NEONIX Co., Ltd. Date: Feb 22, 2022 MODEL VCA-RBT95 / DJ96-00234A - 1-Methyl-2-pyrrolidinone : In the eye irritation test using rabbit, the test material was moderately irritating. (OECD Guideline 405, GLP) Respiratorysensitization : - Aluminum : Al2O3 was the least inflammatory material tested and led to only weak effects on the mouse lung. (Read across; Aluminium oxide) - Carbon black : In respiratory sensitization test with mice, it did not induce respiratory sensitization.
NEONIX Co., Ltd. Date: Feb 22, 2022 MODEL VCA-RBT95 / DJ96-00234A ACGIH - Nickel : A5 - Cobalt and cobalt compounds : A3 - Aluminum : A4 - Carbon black : A3 KOREA-ISHL - Cobalt and inorganic compounds : 2 - Carbon black : 2 - Nickel : 1A EU - Lithium nickelate : Carc.1A - Nickel : Carc.2 - Copper : EPA IRIS: D In carcinogenicity study with rat, tumor was not observed. - Polyethylene : Fifty rats were implanted with polyethylene.
NEONIX Co., Ltd. Date: Feb 22, 2022 MODEL VCA-RBT95 / DJ96-00234A Reproductive toxicity : - Copper : In reproductive toxicity with rats, there were no effects considered (up to 1500 ppm). (OECD TG 416, GLP) - Aluminum : No reproduction, breeding and early post-natal developmental toxicity was observed in rats at 1000 mg/kg bw for males and females.
NEONIX Co., Ltd. Date: Feb 22, 2022 MODEL VCA-RBT95 / DJ96-00234A - Hexafluorophosphate de lithium(1-) : Selon une étude d'experts sur l'apport de fluorure et ses effets sur la santé humaine, l'apport de fluorure dans l'eau potable à des niveaux proches ou supérieurs à 4 mg/l est associé à la fluorose dentaire et peut-être aussi à la fluorose et/ou à l'affaiblissement osseux .
NEONIX Co., Ltd. Date: Feb 22, 2022 MODEL VCA-RBT95 / DJ96-00234A - 42d-NOEC (Neanthes arenaceodentata) = 0.713 mg/L (ASTM Method E1562, GLP) - Aluminum : 48hr-LC50 = 0.071 mg/L (Read across; CAS 13473-90-0), 8d-NOEC (Ceriodaphnia dubia) = 4.
NEONIX Co., Ltd. Date: Feb 22, 2022 MODEL VCA-RBT95 / DJ96-00234A - (estimated) - 1,3-Dioxolan-2-one : Bioaccumulation is expected to be low according to the BCF < 500 (BCF = 3.
NEONIX Co., Ltd. Date: Feb 22, 2022 MODEL VCA-RBT95 / DJ96-00234A - Les déchets doivent être éliminés conformément aux réglementations fédérales, étatiques et locales de contrôle de l'environnement.
NEONIX Co., Ltd. Date: Feb 22, 2022 MODEL VCA-RBT95 / DJ96-00234A T5 External Short Circuit Passed - T6 Impact Passed - T7 Overcharge Passed For pack only T8 Forced Discharge Passed For cell only 14.3 UN Number : 3480 14.4 UN Proper shipping name : LITHIUM ION BATTERIES 14.5 Transport Hazard class : 9 14.6 Packing group : II 14.7 Special provisions : 188, 230, 384 14.8 Packing instructions : P903 14.9 Environmentalhazards : No 14.
NEONIX Co., Ltd. Date: Feb 22, 2022 MODEL VCA-RBT95 / DJ96-00234A - ethyl acetate : 5,000 lb - Nickel : 100 lb U.S.A management in formation (EPCRA302Regulation) : Not regulated U.S.A management in formation (EPCRA304Regulation) : Not regulated U.S.
NEONIX Co., Ltd.