Report No.: 19PNS110176 11001 Safety Data Sheets Name of Goods: Li-ion Battery Commissioner: Dongguan Sunly Battery Technology Co., Ltd. GUANGDONG UTL CO., LTD.
Page 2 of 12 Report No.: 19PNS110176 11001 1. IDENTIFICATION OF THE SUBSTANCE/PREPARATION AND OF THE COMPANY/UNDERTAKING Product Identifier Product name:Li-ion Battery Model:303042 , 3.7V 360mAh 1.332Wh Other means of identification Synonyms: Recommended use of the chemical and restrictions on use Recommended Use: Uses advised against: a) Do not dismantle, open or shred secondary cells or batteries. b) Do not expose cells or batteries to heat or fire. Avoid storage in direct sunlight.
Page 3 of 12 Report No.: 19PNS110176 11001 Fax:0769-87285586 Postcode:N/A E-mail address:596320609@qq.com Emergency telephone number : 136 3521 8011 Company Emergency Phone Number: +86-769-87285025 2. HAZARDS IDENTIFICATION Classification This chemical is not considered hazardous by the 2012 OSHA Hazard Communication Standard (29 CFR 1910.1200). This product is an article which is a sealed battery and as such does not require an MSDS per the OSHA hazard communication standard unless ruptured.
Page 4 of 12 Report No.: 19PNS110176 11001 EYE DAMAGE/IRRITATION (CONTINUED) Hazard category: 2B Hazard statement: Causes eye irritation Prevention:Wash thoroughly after handing. Response:If in eye: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. If eye irritation persists: Get medical advice/attention.
Page 5 of 12 Report No.: 19PNS110176 11001 Product: Consisting of the following components Common Chemical Name Chemical Formula Concentration (%) CAS Number LiCoO2 41.6 12190-79-3 (C2H2F2)n 0.9 24937-79-9 Al 5.8 7429-90-5 C24X12 22.1 7782-42-5 (C8H8.C4H6)x 0.54 61789-96-6 C8H16O8 0.26 9000-11-7 Copper Cu 10.6 7440-50-8 Nickel Ni 0.4 7440-02-0 LiPF6 17.
Page 6 of 12 Report No.: 19PNS110176 11001 Formation of toxic gases is possible during heating or case of fire. In case of fire, the following can be released: Carbon monoxide (Co) Carbon dioxide Other irritating and toxic gases. Hazardous Combustion Products Carbon oxides.
Page 7 of 12 Report No.: 19PNS110176 11001 and clothing. Wear personal protective equipment. Wash thoroughly after handling. Use this material with adequate ventilation. The Product is not explosive. Conditions for safe storage, including any incompatibilities If the Li-ion Battery is subject to storage for such a long term as more than 3 months, it is recommended to recharge the Lithium-ion Polymer Battery Periodically.
Page 8 of 12 Report No.: 19PNS110176 11001 Eye/Face Protection: Tightly sealed goggles Body protection: Protective work clothing. Skin protection: Protective gloves Material of gloves: The selection of the suitable gloves does not noly depend on the material, but also on further marks of quality and varies from manufacturer to manufacturer.
Page 9 of 12 Report No.: 19PNS110176 11001 Solubility in other solvents Not determined. n-octanol/water partition coefficient Not determined. Auto-ignition temperature Product is not self-igniting. Decomposition temperature Not determined. Odout threshold Not determined. Evaporation rate Not determined. Viscosity Not determined. Other Information No further relevant information available. 10.
Page 10 of 12 Report No.: 19PNS110176 11001 Persistence and degradability: No further relevant information available. Bioaccumulation potential: No further relevant information available. Mobility in soil: No further relevant information available. Results of PBT and vPvB assessment PBT: Not applicable. vPvB: Not applicable. Other adverse effects: No information available. 13. DISPOSAL CONSIDERATIONS Waste treatment methods Recommendation: Must not be disposed together with household garbage.
Page 11 of 12 Report No.: 19PNS110176 11001 Meets requirements of DOT Special Provision 188 to be transported as non-dangerous goods Meets the requirements of 49CFR173.185 to be transported as non-dangerous goods for road, rail, air, and vessel (Effective August 6, 2014 per HM224F) The package must be handled with care and that a flammability hazard exists if the package is damaged; 15.
Page 12 of 12 Report No.: 19PNS110176 11001 Photos: Fig.1 Overall view I of battery Fig. 2 Overall view II of battery GUANGDONG UTL CO., LTD. Lianding Testing Building, No.18 Center Road of Yayuan Industrial Zone, Nancheng District, Dongguan, Guangdong, China Tel: +86-769-3893 3228 E-mail: sales@gdutl.com Web: http://www.gdutl.