Instructions / Assembly

IN022 Rev M 0321 33 Saber Way, Ward Hill, MA 01835 | spruce.com
1. WARNING – TO REDUCE THE RISK OF FIRE, USE ONLY METAL DUCTWORK.
2. WARNING – TO REDUCE THE RISK OF A RANGE TOP GREASE FIRE:
a)Neverleavesurfaceunitsunattendedathighsettings.Boilover’scausesmokingandgreasyspilloversthatmayignite.Heat
oils slowly on low or medium settings.
b)AlwaysturnhoodONwhencookingathighheatorwhenambéingfood(i.e.CrepesSuzette,CherriesJubilee,
PeppercornBeefFlambé’).
c)Cleanventilatingfansfrequently.Greaseshouldnotbeallowedtoaccumulateonfanorlter.
d)Useproperpansize.Alwaysusecookwareappropriateforthesizeofsurfaceelement.
3. WARNING – TO REDUCE THE RISK OF INJURY TO PERSONS IN THE EVENT OF A RANGE TOP GREASE FIRE,
OBSERVE THE FOLLOWING*:
a)SMOTHERFLAMESwithaclose-ttinglid,cookiesheetormetaltray,thenturnofftheburner.BECAREFULTOPREVENT
BURNS.Iftheamesdonotgooutimmediately,EVACUATEANDCALLTHEFIREDEPARTMENT.
b)NEVERPICKUPAFLAMINGPAN–Youmaybeburned.
c)DONOTUSEWATER,includingwetdishclothsortowels–aviolentsteamexplosionwillresult.
d)UseanextinguisherONLYif:
1)YouknowyouhaveaclassABCextinguisher,andyoualreadyknowhowtooperateit.
2)Thereissmallandcontainedintheareawhereitstarted.
3)Theredepartmentisbeingcalled.
4)Youcanghttherewithyourbacktoanexit.
*Basedon“KitchenFiresafetyTips”publishedbyNFPA.
4. NOTICE - USE OF THIS FAN WITHOUT AN ADEQUATE FILTERING SYSTEM IS NOT RECOMMENDED FOR
RANGE HOOD APPLICATIONS.
5.IfusedwithaHoodAssemblyseeHoodManualToDetermineSuitability.
6.Exercisecarewhencleaningthefan,lters,ductworketc.Ensurethatthepowersupplyisdisconnected.Useonlycleaning
agents or detergents compatible with the surface being cleaned. Obey all instructions applicable to the cleaning agent or
detergent.Useallpersonalprotectionspeciedforusewiththecleaningagentordetergentincludinggloves,eyeprotection,
clothingprotectionetc.Donotmixcleaningagentsand/ordetergents.
Fan Installation & Operating Instructions
RL Inline Fan Series
RL600p/n23040-1,p/n28126
RL500p/n23039-1,p/n28228
RL450p/n23043-1,p/n28227
RL350p/n23042-1,p/n28226
RL300p/n23037-1,p/n28225
RL200p/n23036-1,p/n28224
1.0 Mounting
The RL Series fan may be mounted at an angle without affecting performance although the vertical mounting position shown
inFig.1ishighly recommended. If the vertical mounting position is not possible, care should be taken to avoid creating a low
spotinthefan/ductsystemwherecondensationmightaccumulateinthefanhousingasshowninFig.2.Insituationswhere
horizontalmountingisdesiredandcondensationislikelytooccur(bathroomventilationincoldclimates)thisproblemmightbe
avoidedbymountingthefan30degreesbeyondhorizontalasshowninFig.3.